IllustrationNO RECALL? MY SPEEDOMETER AND ALL MY GAUGES CUT OUT WHEN THE CAR IS DRIVING. THIS CAUSE MANY DIFFRENT ELCTRONIC DEVISES IN MY CAR TO NOT WORK CORRECTLY.*AK
2000 GMC Jimmy
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Jimmy years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
50–25K
2325–50K
2450–75K
2275–100K
16100–150K
4150K+
94 reports with mileage · 117 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 39 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 32 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
15 crash reports4 fire reports7 injury reports
What owners actually said
211 reportsI AM WRITING TO ADVISE THE NHTSB OF A POTENTIALLY DANGEROUS DEFECT IN THE GM 4L60-E TRANSMISSION AND TO REQUEST THE NHTSB OPEN AN INVESTIGATION TO IDENTIFY AND RESOLVE SAID DEFECTS. MY REQUEST IS IN REFERENCE TO THE REACTION SUN SHELL, A PART WITHIN THE 4L60-E TRANSMISSION PRONE TO CATASTROPHIC FAILURE. I OWN TWO GMC JIMMY 4X…
Read full complaint
I AM WRITING TO ADVISE THE NHTSB OF A POTENTIALLY DANGEROUS DEFECT IN THE GM 4L60-E TRANSMISSION AND TO REQUEST THE NHTSB OPEN AN INVESTIGATION TO IDENTIFY AND RESOLVE SAID DEFECTS. MY REQUEST IS IN REFERENCE TO THE REACTION SUN SHELL, A PART WITHIN THE 4L60-E TRANSMISSION PRONE TO CATASTROPHIC FAILURE. I OWN TWO GMC JIMMY 4X4 SUVS. MY FIRST JIMMY IS A 2000 WITH 60000 MILES AND THE SECOND IS A 2001 WITH 50000 MILES. WITHIN THE LAST 2 MONTHS, THE REACTION SUN SHELL IN BOTH OF THE VEHICLES HAS FAILED, RESULTING IN SEVERE DAMAGE TO THE 4L60-E TRANSMISSIONS. THE FAILURES OCCURRED DURING THE OPERATION OF THE VEHICLES AT HIGHWAY SPEEDS. IN BOTH CASES, THERE WAS NO WARNING OF A PENDING FAILURE. BOTH SUVS EXPERIENCED A SUDDEN LOSS OF 2ND, 3RD, OD, AND REVERSE GEARS, RESULTING IN SIGNIFICANT DEGRADATION IN THE PERFORMANCE OF THE VEHICLES AND DRASTICALLY REDUCED THE OPERATORS ABILITY TO CONTROL THE VEHICLES. FAILURE OF A SINGLE TRANSMISSION IN ANY VEHICLE CAN BE ATTRIBUTED TO A VARIETY OF CIRCUMSTANCES. HOWEVER, IDENTICAL FAILURES IN MULTIPLE 4L60-E TRANSMISSIONS STRONGLY INDICATE A SYSTEMATIC FAULT IN DESIGN AND/OR QUALITY. BOTH VEHICLES EXPERIENCE ONLY LIGHT DUTY OPERATION AND ARE VERY WELL MAINTAINED. GMC HAS BEEN MADE AWARE OF THE FAILURES VERBALLY AND IN WRITING. THUS FAR, GMC HAS REFUSED TO ACCEPT RESPONSIBILITY FOR THE FAULT IN DESIGN AND/OR QUALITY AND HAS STATED IT IS UNWILLING TO CORRECT THE PROBLEM. HOWEVER, GMC IS AWARE OF THE PROBLEM AND ITS MAGNITUDE AS EVIDENCED BY GMC TSB 00-07-30-022. ANY TIME THERE IS A SUDDEN AND DRASTIC CHANGE IN THE OPERATING CHARACTERISTICS OF A MOTOR VEHICLE, THE OPERATOR IS PRESENTED WITH A DANGEROUS SITUATION THREATENING THE SAFETY OF THE OPERATOR, PASSENGERS, AND FELLOW DRIVERS. WITH THIS IN MIND, IT IS MY HOPE THAT THE NHTSB WILL INVESTIGATE THE GRIEVANCE I HAVE PRESENTED, IDENTIFY THE FAULT AS A SYSTEMATIC FAILURE ON THE PART OF GMC, AND ISSUE THE APPROPRIATE RECALL NECESSARY TO ENSURE THE SAFETY OF EVERYONE ON OUR HIGHWAYS. *AK *SC
AT 50,000 MILES, BOTH FRONT WHEEL BEARINGS HAD TO BE REPLACED, AS THE VEHICLE WAS PULLING OFF THE ROAD AS IT WAS BEING DRIVEN. I WAS TOLD THAT THEY WORE BECAUSE OF NO GREASE. NOW AT 61,000 MILES, THE INTAKE MANIFOLD GASKET IS LEAKING, AND THE OIL LINES ARE ALSO LEAKING. THE DEALERSHIP ESTIMATED REPAIR COSTS AT WELL OVER $1100 DO…
Read full complaint
AT 50,000 MILES, BOTH FRONT WHEEL BEARINGS HAD TO BE REPLACED, AS THE VEHICLE WAS PULLING OFF THE ROAD AS IT WAS BEING DRIVEN. I WAS TOLD THAT THEY WORE BECAUSE OF NO GREASE. NOW AT 61,000 MILES, THE INTAKE MANIFOLD GASKET IS LEAKING, AND THE OIL LINES ARE ALSO LEAKING. THE DEALERSHIP ESTIMATED REPAIR COSTS AT WELL OVER $1100 DOLLARS. THIS IS A 2000 GMC JIMMY, AND ONLY HAS 61,000 MILES. *NM
WHILE HAVING THE FRONT END ALIGNED MECHANIC NOTICED THE LOWER BALL JOINTS NEEDED TO BE REPLACED. CONSUMER WAS REIMBURSED FOR THE WORK PERFORMED. THEN, ON 01/06/2005, WHILE DRIVING THE VEHICLE AND TURNING A CORNER, CONSUMER THOUGHT VEHICLE SUSTAINED A FLAT. GOT OUT, AND SAW THAT THE RIGHT FRONT TIRE WAS TURNED UNDER THE VE…
Read full complaint
WHILE HAVING THE FRONT END ALIGNED MECHANIC NOTICED THE LOWER BALL JOINTS NEEDED TO BE REPLACED. CONSUMER WAS REIMBURSED FOR THE WORK PERFORMED. THEN, ON 01/06/2005, WHILE DRIVING THE VEHICLE AND TURNING A CORNER, CONSUMER THOUGHT VEHICLE SUSTAINED A FLAT. GOT OUT, AND SAW THAT THE RIGHT FRONT TIRE WAS TURNED UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO A REPAIR SHOP, AND MECHANIC DETERMINED THAT FRONT BALL JOINTS WERE DEFECTIVE.*AK....CONSUMER TOOK VEHICLE TO DEALER, THEY DID AN ALIGNMENT, AND REPLACED THE BALL JOINTS. *AK
I WOULD JUST LIKE TO START OUT BY SAYING I ENJOY GM VEHICLES. THEY ARE ALL I DRIVE, BUT SOMETIMES THEY HAVE LITTLE PROBLEMS. LIKE MY 2000 GMC JIMMY SLS. THE RECLINE HANDLE ON THE DRIVERS AND PASSENGERS SEAT KEEP FALLING OFF AND STRIPPING THE BEAR METAL. I NEVER PULL ON THEM SO THEY DONT GET PULLED ON. I WOULD JUST LIKE TO KNOW H…
Read full complaint
I WOULD JUST LIKE TO START OUT BY SAYING I ENJOY GM VEHICLES. THEY ARE ALL I DRIVE, BUT SOMETIMES THEY HAVE LITTLE PROBLEMS. LIKE MY 2000 GMC JIMMY SLS. THE RECLINE HANDLE ON THE DRIVERS AND PASSENGERS SEAT KEEP FALLING OFF AND STRIPPING THE BEAR METAL. I NEVER PULL ON THEM SO THEY DONT GET PULLED ON. I WOULD JUST LIKE TO KNOW HOW YOU INTEND TO FIX THE PROBLEM AND WHEN. NOW THERE IS NOTHING ELSE WRONG WITH THE SUV BUT MINOR THINGS DUE TO AGE. I WOULD JUST LIKE TO KNOW HOW YOU INTEND TO FIX THE PROBLEM. THANK YOU FOR YOUR TIME. *AK MICHAEL DIEMERT
FRONT WHEEL BEARING FAILURE, CAUSING BOTH FRONT WHEELS TO LOOSEN ON THE HUB, I IMMEDIATELY TOOK IT TO ME MECHANIC WHO STATED BOTH WHEELS WERE READY TO FALL OFF. UPON RESEARCH, THIS PROBLEM SEEMS TO HAPPEN ON SIGNIFICANT NUMBERS OF THESE VEHICLES DO TO DESIGN FLAW OF FRONT SUSPENSION. THE SUSPNSION IS NOT DESIGEND FOR THE WEIGHT …
Read full complaint
FRONT WHEEL BEARING FAILURE, CAUSING BOTH FRONT WHEELS TO LOOSEN ON THE HUB, I IMMEDIATELY TOOK IT TO ME MECHANIC WHO STATED BOTH WHEELS WERE READY TO FALL OFF. UPON RESEARCH, THIS PROBLEM SEEMS TO HAPPEN ON SIGNIFICANT NUMBERS OF THESE VEHICLES DO TO DESIGN FLAW OF FRONT SUSPENSION. THE SUSPNSION IS NOT DESIGEND FOR THE WEIGHT OF THE NEWER MODELS JIMMY. *AK
I OWN A 2000 JIMMY AND HAVE GONE THROUGH 2 SETS OF UPPER AND LOWER BALL JOINTS AND AT THIS TIME THE LEFT LOWER BALL JOINTS WENT AGAIN. WHAT IS THE PROBLEM WITH THE BALL JOINTS? THIS IS COSTLY TO REPAIR, AS WEL AS DANGEROUS, AFFECTING THE STEERING. I WOULD LIKE TO KNOW WHAT IMPROVMENTS ARE BEING DONE TO CORRECT THE PROBLEM, A…
Read full complaint
I OWN A 2000 JIMMY AND HAVE GONE THROUGH 2 SETS OF UPPER AND LOWER BALL JOINTS AND AT THIS TIME THE LEFT LOWER BALL JOINTS WENT AGAIN. WHAT IS THE PROBLEM WITH THE BALL JOINTS? THIS IS COSTLY TO REPAIR, AS WEL AS DANGEROUS, AFFECTING THE STEERING. I WOULD LIKE TO KNOW WHAT IMPROVMENTS ARE BEING DONE TO CORRECT THE PROBLEM, AND IF IT IS A COMMON OCCURANCE AMONG OTHER GMC SUV'S. THERE SHOULD NOT BE DISPOSIBLE PARTS PUT ON THE FRONT END OF ANY VEHICLE. *AK
WHILE DRIVING 30-35 MPH CONSUMER'S VEHICLE HAS COLLIDED INTO THE REAR BUMPER OF ANOTHER VEHICLE . UPON IMPACT, NEITHER FRONTAL AIR BAG DEPLOYED. NO INJURY WAS REPORTED. *AK
PULLED OVER TO SIDE OF HIGHWAY (RAINING) AND ENGAGED THE HAZARD SIGNAL BRIEFLY AND DISENGAGED AND DIRECTIONAL SIGNAL AND BRAKE LIGHTS FAILED TO OPERATE. MECHANIC CHANGED ALL BULBS THAT WERE BURN OUT. HAZARD LIGHTS AND BRAKING LIGHTS ARE STILL NOT OPERATIONAL.*AK
1) CAR WOULD START, CHECK ENGINE LIGHT CAME ON AND THE GAS GAUGE FLUCTATED BACK AND FORTH WHILE PARK AND NEUTRAL. TOOK VEHICLE TO BE REPAIRED (IN EXCESS OF $1000+ *AK
Official recalls
408V231000 · Exterior Lighting:brake Lights:switch
May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
01V364000 · Exterior Lighting:brake Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:switch
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
00V228003 · Seat Belts
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
99V220000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.