NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
9 reportsClear category filter127,115 miles · Dec 4, 2012
SteeringSuspension
WHILE DRIVING MY 2000 GMC JIMMY MY LEFT SIDE UPPER BALL JOINT BROKE. LUCKILY I HAD JUST CAME OUT OF A SHARP CORNER AND MY SPEED WAS ONLY ABOUT 25 MPH. A CAR HAD JUST PASSED IN THE OTHER DIRECTION WHEN MY VEHICLE SWERVED TO THE LEFT, HALFWAY INTO THE OTHER LANE BEFORE I WAS ABLE TO GET CONTROL OF IT. UPON INSPECTION, THE TIRE WAS…
Read full complaint
WHILE DRIVING MY 2000 GMC JIMMY MY LEFT SIDE UPPER BALL JOINT BROKE. LUCKILY I HAD JUST CAME OUT OF A SHARP CORNER AND MY SPEED WAS ONLY ABOUT 25 MPH. A CAR HAD JUST PASSED IN THE OTHER DIRECTION WHEN MY VEHICLE SWERVED TO THE LEFT, HALFWAY INTO THE OTHER LANE BEFORE I WAS ABLE TO GET CONTROL OF IT. UPON INSPECTION, THE TIRE WAS LEANING INWARD AND MY BRAKE LINE WAS SEVERED. I HAD TO USE MY EMERGENCY BRAKE TO STOP. *TR
NHTSA ODI #10487301
75,000 miles · Mar 27, 2007
Electrical SystemFuel System, GasolineLatches/locks/linkages
THE ENTIRE CAR IS DEFECTIVE, THOUGH IT DOES NOT STATE IT IS A LEMON. I PURCHASED IT USED. I HAVE REPLACED MANY MAJOR PARTS THAT ARE NOT CONSIDERED ROUTINE MAINTENANCE, SUCH A DRIVER'S DOOR HINGES AND BEARINGS, HOOD RELEASE CABLE, STEERING ARM (TWICE) HUBS (TWICE) THE WIRING SYSTEM IS FAULTY. I HAVE GONE THROUGH 4 ALTERNATORS …
Read full complaint
THE ENTIRE CAR IS DEFECTIVE, THOUGH IT DOES NOT STATE IT IS A LEMON. I PURCHASED IT USED. I HAVE REPLACED MANY MAJOR PARTS THAT ARE NOT CONSIDERED ROUTINE MAINTENANCE, SUCH A DRIVER'S DOOR HINGES AND BEARINGS, HOOD RELEASE CABLE, STEERING ARM (TWICE) HUBS (TWICE) THE WIRING SYSTEM IS FAULTY. I HAVE GONE THROUGH 4 ALTERNATORS IN UNDER 2 1/2 YEARS. *JB
NHTSA ODI #10186255
38,000 miles · May 25, 2004
EquipmentPower TrainService Brakes, Hydraulic
MANY PROBLEMS WITH THIS 2000 JIMMY. BOUGHT IT USED FROM CARMAX AT 18K MILES ON JAN 2003, GOT EXT. WARRANTY, BUT SOON AFTER, FRONT BRAKES NEED TO BE REPLACED, REPLACED BY CARMAX FOR FREE, BUT 6 MOS LATER BRAKES NEEDED REPLACED. WAS ADVISED THAT REAR ROTORS AND BRAKES WERE ALMOST AT END OF LIFE. 9 MOS LATER, REPLACED REAR BRAKE…
Read full complaint
MANY PROBLEMS WITH THIS 2000 JIMMY. BOUGHT IT USED FROM CARMAX AT 18K MILES ON JAN 2003, GOT EXT. WARRANTY, BUT SOON AFTER, FRONT BRAKES NEED TO BE REPLACED, REPLACED BY CARMAX FOR FREE, BUT 6 MOS LATER BRAKES NEEDED REPLACED. WAS ADVISED THAT REAR ROTORS AND BRAKES WERE ALMOST AT END OF LIFE. 9 MOS LATER, REPLACED REAR BRAKES AND ROTORS, NOT COVERED UNDER WARRANTY DUE TO WEAR AND TEAR, SPENT $450 AS WELL AS REPLACING SERPENTINE BELT AND FLUSHING BREAK FLUID, TOTAL COST $650. PROBLEMS WITH SUNROOF STARTED IN APR 2003, IT FINALLY STOPPED WORKING AND WAS REPLACED AT 43K MILES UNDER EXT WARRANTY, HAD TO GET NEW BATTERY, NOISE IN UNDER CARRIAGE ON DRIVERS SIDE, DETERMINED TO BE PROBLEMS WITH HUB BEARINGS AND IDLE ARM, INNER TIE ROD, ALL REPLACED UNDER EXT WARRANTY, TOTAL COST WOULD HAVE BEEN $750. *NM
NHTSA ODI #10073164
48,242 miles · Mar 30, 2004
Steering
WHILE DRIVING STEERING COLUMN STARTED SMOKING . NO FIRE REPORTED. *AK
NHTSA ODI #10065229
35,000 miles · Jan 15, 2004
Steering
I AM CONCERNED BECAUSE I AM THE THIRD PERSON I KNOW OF WITH GMC JIMMY 99 OR NEWER WHO HAD TO HAVE UPPER BALL JOINTS, TIEROD(S) AND THE RIGHT WHEEL BEARING REPLACED WHEN VEHICLE WAS AT OR JUST OVER 3 YRS OLD. THE FACT THAT 2 OF THE 3 HAD THE PROBLEMS PAID FOR BY GMC DEALER, EVEN THOUGH VEHICLE WAS OUT OF WARRANTY, MAKES ME THINK…
Read full complaint
I AM CONCERNED BECAUSE I AM THE THIRD PERSON I KNOW OF WITH GMC JIMMY 99 OR NEWER WHO HAD TO HAVE UPPER BALL JOINTS, TIEROD(S) AND THE RIGHT WHEEL BEARING REPLACED WHEN VEHICLE WAS AT OR JUST OVER 3 YRS OLD. THE FACT THAT 2 OF THE 3 HAD THE PROBLEMS PAID FOR BY GMC DEALER, EVEN THOUGH VEHICLE WAS OUT OF WARRANTY, MAKES ME THINK GM KNEW THIS PROBLEM WAS OCCURRING & CHOSE TO ADDRESS IT ON AN "AS NEEDED BASIS, INSTEAD OF A RECALL. MY COSTS WERE SAID TO BE A "GM CUSTOMER LOYALTY ADJUSTMENT". I AM CONFUSED THAT MY DEALER AT FIRST SAID I WAS TO PAY FOR PARTS ONLY, NO LABOR. THEN CHANGED IT TO LABOR ONLY, NOT PARTS. I NOTICED AFTERWARD THAT MY INVOICE FOR THE WORK SHOWS WORDING THAT LIFETIME WARRANTY APPLIES TO ONLY CUSTOMER PAID PARTS. DOES THAT MEAN SINCE I DID NOT PAY FOR THE PARTS, THERE IS NO WARRANTY? I APPRECIATE NOT HAVING TO PAY FOR THE REPAIRS, BUT SOMETHING DEFINITELY SMELLS FISHY.
NHTSA ODI #10070076
Mileage unknown · Jun 18, 2002
SteeringSuspension
VEHICLE IS PULLING TO RIGHT AT ALL TIMES, 5 ALIGNMENTS WERE DONE, PITMAN ARM AND ROTOR ARM WAS REPLACED. THEN, WHEEL BEARINGS WERE REPLACED.*AK
NHTSA ODI #8012033
Mileage unknown · Apr 24, 2002
Steering
WHEN THE STEERING IDLER ARM FELL OFF THE FRONT LEFT SIDE SOUNDS LIKE IT'S GOING TO COME THROUGH THE HOOD! AND THEY CAN'T SEEM TO FIGURE OUT THE PROBLEM!!*AK
NHTSA ODI #761135
Mileage unknown · Jul 10, 2001
Service Brakes, HydraulicSteering
CONSUMER WAS GOING 30MPH ON A DIRT ROAD AND SUDDENLY APPLIED BRAKES TO KEEP FROM HITTING AN ANIMAL. VEHICLE SPUN AROUND, AND WHEELS LOCKED UP. CONSUMER WENT TO 1 DEALER, WHO SAID THERE WAS NO PROBLEM WITH REAR BRAKES. CONSUMER WAS PULLING INTO A DIRT DRIVEWAY AND NOTICED LEFT REAR WHEEL HAD LOCKED UP. WHEEL LEFT TRACTS IN …
Read full complaint
CONSUMER WAS GOING 30MPH ON A DIRT ROAD AND SUDDENLY APPLIED BRAKES TO KEEP FROM HITTING AN ANIMAL. VEHICLE SPUN AROUND, AND WHEELS LOCKED UP. CONSUMER WENT TO 1 DEALER, WHO SAID THERE WAS NO PROBLEM WITH REAR BRAKES. CONSUMER WAS PULLING INTO A DIRT DRIVEWAY AND NOTICED LEFT REAR WHEEL HAD LOCKED UP. WHEEL LEFT TRACTS IN DIRT. CONSUMER DECIDED TO GET A 2ND OPINON ON PROBLEM. AFTER PLUGGING THE VEHICLE, IT SHOWED THERE WAS A PROBLEM WITH ABS SYSTEM. DEALER EXPLAINED HOW THIS WAS FIRST YEAR THAT VEHICLES HAVE THE INTEGRATED ABS, AND WERE HAVING ALOT OF PROBLEMS WITH THEM. ALSO, REAR ROTORS WERE FROZEN AND CALIPERS NEEDED TO BE REPLACED.*AK CONSUMER STATES THERE HAS BEEN 7 BRAKE REPAIRS, CONSUMER IS STILL EXPERIENCING ABS PROBLEMS. CENTER LINK AND IDLER ARM WORE AND WERE REPLACED, CONSUMER IS STILL EXPERIENCING STEERING PROBLEMS. *SLC
NHTSA ODI #892288
Mileage unknown · Jun 17, 2000
Steering
SEAT AND/OR COMPONENTS MOVES AT VEHICLE TAKE OFF AND STOPS MAKING ALSO MAKING A BOLD NOISE ON DRIVER SEAT GIVING THE SENSATION THAT DRIVER DOES NOT STOP/MOVES W/ VEHICLE WICH CAN BE DANGEROUS AT ANY REQUIRED MANUVERING MOMENT. *AK( DOT NUMBER: TIRE SIZE: P235/70R15 )
NHTSA ODI #724131
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration