WHILE HAVING THE FRONT END ALIGNED MECHANIC NOTICED THE LOWER BALL JOINTS NEEDED TO BE REPLACED. CONSUMER WAS REIMBURSED FOR THE WORK PERFORMED. THEN, ON 01/06/2005, WHILE DRIVING THE VEHICLE AND TURNING A CORNER, CONSUMER THOUGHT VEHICLE SUSTAINED A FLAT. GOT OUT, AND SAW THAT THE RIGHT FRONT TIRE WAS TURNED UNDER THE VE…
Read full complaint
WHILE HAVING THE FRONT END ALIGNED MECHANIC NOTICED THE LOWER BALL JOINTS NEEDED TO BE REPLACED. CONSUMER WAS REIMBURSED FOR THE WORK PERFORMED. THEN, ON 01/06/2005, WHILE DRIVING THE VEHICLE AND TURNING A CORNER, CONSUMER THOUGHT VEHICLE SUSTAINED A FLAT. GOT OUT, AND SAW THAT THE RIGHT FRONT TIRE WAS TURNED UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO A REPAIR SHOP, AND MECHANIC DETERMINED THAT FRONT BALL JOINTS WERE DEFECTIVE.*AK....CONSUMER TOOK VEHICLE TO DEALER, THEY DID AN ALIGNMENT, AND REPLACED THE BALL JOINTS. *AK
NHTSA ODI #10107114
41,665 miles · Jan 3, 2005
Suspension
FRONT WHEEL BEARING FAILURE, CAUSING BOTH FRONT WHEELS TO LOOSEN ON THE HUB, I IMMEDIATELY TOOK IT TO ME MECHANIC WHO STATED BOTH WHEELS WERE READY TO FALL OFF. UPON RESEARCH, THIS PROBLEM SEEMS TO HAPPEN ON SIGNIFICANT NUMBERS OF THESE VEHICLES DO TO DESIGN FLAW OF FRONT SUSPENSION. THE SUSPNSION IS NOT DESIGEND FOR THE WEIGHT …
Read full complaint
FRONT WHEEL BEARING FAILURE, CAUSING BOTH FRONT WHEELS TO LOOSEN ON THE HUB, I IMMEDIATELY TOOK IT TO ME MECHANIC WHO STATED BOTH WHEELS WERE READY TO FALL OFF. UPON RESEARCH, THIS PROBLEM SEEMS TO HAPPEN ON SIGNIFICANT NUMBERS OF THESE VEHICLES DO TO DESIGN FLAW OF FRONT SUSPENSION. THE SUSPNSION IS NOT DESIGEND FOR THE WEIGHT OF THE NEWER MODELS JIMMY. *AK
NHTSA ODI #10105634
72,000 miles · Dec 10, 2004
EquipmentFuel System, GasolineSuspension
I OWN A 2000 JIMMY AND HAVE GONE THROUGH 2 SETS OF UPPER AND LOWER BALL JOINTS AND AT THIS TIME THE LEFT LOWER BALL JOINTS WENT AGAIN. WHAT IS THE PROBLEM WITH THE BALL JOINTS? THIS IS COSTLY TO REPAIR, AS WEL AS DANGEROUS, AFFECTING THE STEERING. I WOULD LIKE TO KNOW WHAT IMPROVMENTS ARE BEING DONE TO CORRECT THE PROBLEM, A…
Read full complaint
I OWN A 2000 JIMMY AND HAVE GONE THROUGH 2 SETS OF UPPER AND LOWER BALL JOINTS AND AT THIS TIME THE LEFT LOWER BALL JOINTS WENT AGAIN. WHAT IS THE PROBLEM WITH THE BALL JOINTS? THIS IS COSTLY TO REPAIR, AS WEL AS DANGEROUS, AFFECTING THE STEERING. I WOULD LIKE TO KNOW WHAT IMPROVMENTS ARE BEING DONE TO CORRECT THE PROBLEM, AND IF IT IS A COMMON OCCURANCE AMONG OTHER GMC SUV'S. THERE SHOULD NOT BE DISPOSIBLE PARTS PUT ON THE FRONT END OF ANY VEHICLE. *AK
NHTSA ODI #10102566
62,000 miles · Jul 12, 2004
Suspension
WHILE DRIVING 60 MPH FRONT END VIBRATED VIOLENTLY. DEALER STATED THE UPPER AND LOWER BALL JOINTS FAILED. *AK
NHTSA ODI #10081718
Mileage unknown · May 11, 2004
Suspension
TOOK CAR IN FOR INSPECTION WAS TOLD LOWER BALL JOINT WAS WORN AND NEEDED TO BE REPLACED BY GM DEALER CAR ONLY HAS 23,330 MILES ON IT AND WAS PURCHASED 9/03. DID NOTICE WHEN DRIVING THE CAR WOULD MAKE A LOUD "POPPING" NOISE WHEN IT WAS TURNING IN EITHER DIRECTION SINCE I PURCHASED CAR. THOUGHT EVERYTHING WAS CHEAKED OUT BY DEALER
NHTSA ODI #10072438
4,989 miles · Apr 9, 2004
Suspension
2000 JIMMY HAS HAD NOISE AND VIBRATION IN FRONT END SINCE IT HAD 4900 MILES ON IT. REPEATED COMPLAINTS TO THE DEALER BUT THEY "COULD NOT DUPLICATE" THE PROBLEM, SO NOTHING'S BEEN DONE. SOUNDS LIKE THE DRIVER'S SIDE FRONT WHEEL IS GOING TO FALL OFF, AND VIBRATION IS FELT IN STEERING WHEEL, SEAT AND FLOOR.*AK
NHTSA ODI #10065845
Mileage unknown · Apr 5, 2004
Suspension
PASSENGER SIDE WHEEL BEARING FAILED, DRIVERS SIDE HAS FAILED TWICE NOW. CAN'T SEEM TO GET THE FRONT END TO ALIGN EITHER. BEEN TO 3 SHOPS AND IT STILL EATS MY TIRES. GOT A NICE EMAIL BACK FROM GMC SAYS THEY DON'T SHOW ANY CLAIMS THROUGH DTEALERSHIPS, I COULD BARELY AFFORD THE $400 BEARING MUCH LESS HAVE THEM BEND ME 90 DEGREES…
Read full complaint
PASSENGER SIDE WHEEL BEARING FAILED, DRIVERS SIDE HAS FAILED TWICE NOW. CAN'T SEEM TO GET THE FRONT END TO ALIGN EITHER. BEEN TO 3 SHOPS AND IT STILL EATS MY TIRES. GOT A NICE EMAIL BACK FROM GMC SAYS THEY DON'T SHOW ANY CLAIMS THROUGH DTEALERSHIPS, I COULD BARELY AFFORD THE $400 BEARING MUCH LESS HAVE THEM BEND ME 90 DEGREES ON THE LABOR. *JB
NHTSA ODI #10064590
Mileage unknown · Mar 26, 2004
Electrical SystemEngine And Engine CoolingFuel System, Gasoline
2000 JIMMY ENVOY IS ONE BIG PIECE OF JUNK!!!!!*AK
NHTSA ODI #10063967
Mileage unknown · Nov 12, 2003
Suspension
WHEEL BEARING ASSEMBLY UNIT. *LA
NHTSA ODI #10046784
Mileage unknown · Oct 27, 2003
Suspension
BALL JOINTS UPPER AND LOWER.I HAD THEM REPAIRED ONCE, AND NOW NOT EVEN SIX MONTHS LATER THEY NEED REPAIR AGAIN. *AK
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
2000 GMC Jimmy Problems, Complaints & Recalls | Skip That Year
Illustration