NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
32 reportsClear category filter94,445 miles · Mar 16, 2012
Service Brakes, Hydraulic
AT 94,445 MILES: NOTICED A SMALL LEAKAGE ON GARAGE FLOOR, FORWARD OF LEFT REAR TIRE--WITHIN 10 MILES NOTED SIGNIFICANTLY REDUCED BRAKING CAPABILITY. TAKEN TO REPAIR FACILITY THE FOLLOWING MORNING...THE STEEL BRAKE LINES ON DRIVER'S SIDE WERE FOUND CORRODED AND CRACKED WHICH CAUSED BRAKE FLUID LOSS- IRONICALLY AS THE SERVICE TE…
Read full complaint
AT 94,445 MILES: NOTICED A SMALL LEAKAGE ON GARAGE FLOOR, FORWARD OF LEFT REAR TIRE--WITHIN 10 MILES NOTED SIGNIFICANTLY REDUCED BRAKING CAPABILITY. TAKEN TO REPAIR FACILITY THE FOLLOWING MORNING...THE STEEL BRAKE LINES ON DRIVER'S SIDE WERE FOUND CORRODED AND CRACKED WHICH CAUSED BRAKE FLUID LOSS- IRONICALLY AS THE SERVICE TECHNICIAN WAS PULLING THE VEHICLE INTO THE SERVICE BAY--THERE WAS A TOTAL LOSS OF REAR BRAKES-- ONLY THEN--IN THE BAY, DID THE "BRAKE" SERVICE WARNING LIGHT CAME ON! (GOOD REASON TO CALL THEM ' IDIOT' LIGHTS). *TR
NHTSA ODI #10451980
160,000 miles · Nov 8, 2011
Service Brakes, Hydraulic
UPON INSPECTION OF 2000 GMC JIMMY 4DR / 4WD BRAKE LINE DRIVERS SIDE OVER FRAME NEXT TO FUEL TANK HELD DOWN BY A CLIP LEADING TO REAR BRAKES RUPTURED DUE TO CORROSION AROUND THE CLIP AREA THAT HOLDS THE LINE TO FRAME CAUSING TOTAL LOSS REAR BRAKES AND PROPER BRAKING WHEN BRAKE PEDAL WENT TO THE FLOOR WHILE RETURNING HOME TO PAR…
Read full complaint
UPON INSPECTION OF 2000 GMC JIMMY 4DR / 4WD BRAKE LINE DRIVERS SIDE OVER FRAME NEXT TO FUEL TANK HELD DOWN BY A CLIP LEADING TO REAR BRAKES RUPTURED DUE TO CORROSION AROUND THE CLIP AREA THAT HOLDS THE LINE TO FRAME CAUSING TOTAL LOSS REAR BRAKES AND PROPER BRAKING WHEN BRAKE PEDAL WENT TO THE FLOOR WHILE RETURNING HOME TO PARK VEHICLE AT OUR RESIDENCE,.. LUCKILY AT TIME OF INCIDENT WE WERE ON OUR OWN RURAL PROPERTY IN DRIVEWAY WHICH IS (APPROXIMATELY 2/10 MILE LONG) AND NOT THE BUSY MAIN HIGHWAY WHICH WAS TRAVELED AT 55 MPH. THE TERRAIN WAS USED IN OUR DRIVEWAY TO BRING THE VEHICLE TO A SAFE STOP. THANKFULLY NO INJURY'S TO OCCUPANTS (INCLUDING A 3 YEAR OLD CHILD) OR DAMAGE TO VEHICLE OCCURRED WITH THIS INCIDENT. *TR
NHTSA ODI #10434873
113,875 miles · May 25, 2010
Service Brakes, Hydraulic
1999 AND 2000 GMC JIMMY'S. CONSUMER STATES LEFT STEEL BRAKE LINE WAS CORRODED/CRACKED WHICH CAUSED LOSS OF BRAKE FLUID IN THE 2000 AND NUMEROUS GAS LINES LEAKING, CORROSION ON THE 1999 GMC JIMMY. *TGW
NHTSA ODI #10331744
62,000 miles · Jan 22, 2009
Service Brakes, Hydraulic
NOTICED DAMPNESS AROUND THE LEFT REAR BRAKE HOSE TO REAR BRAKE CALIPER. WE TOOK OUR VEHICLE TO BE INSPECTED AND WERE TOLD THAT THERE ARE "2" COPPER WASHERS THAT ARE CAUSING THE LEAK AND REQUIRES REPLACEMENT. WE WERE ALSO TOLD THAT THIS IS QUITE A COMMON PROBLEM. IF THIS WAS NOT REPAIRED AND THE LEAK CONTINUED, IT WOULD HAVE …
Read full complaint
NOTICED DAMPNESS AROUND THE LEFT REAR BRAKE HOSE TO REAR BRAKE CALIPER. WE TOOK OUR VEHICLE TO BE INSPECTED AND WERE TOLD THAT THERE ARE "2" COPPER WASHERS THAT ARE CAUSING THE LEAK AND REQUIRES REPLACEMENT. WE WERE ALSO TOLD THAT THIS IS QUITE A COMMON PROBLEM. IF THIS WAS NOT REPAIRED AND THE LEAK CONTINUED, IT WOULD HAVE RESULTED IN THE LOSS BRAKE PERFORMANCE, LOSS OF VEHICLE CONTROL AND INJURY TO THE OCCUPANTS. *TR
NHTSA ODI #10255996
Mileage unknown · Nov 23, 2008
Service Brakes, HydraulicCrashInjury
WHILE DRIVING MY 2000 GMC JIMMY MY GIRLFRIEND WAS INVOLVED IN AN ACCIDENT. SHE CAME AROUND A CORNER AND HAD TO COME TO A QUICK STOP, WHEN SHE HIT THE BRAKES THE PEDAL WENT RIGHT TO THE FLOOR AND SHE HIT THE VEHICLE IN FRONT OF HER. AFTER THE INCIDENT I TOOK MY VEHICLE TO MY MECHANIC, AND HE FOUND THE STEM THAT COMES OFF THE MAST…
Read full complaint
WHILE DRIVING MY 2000 GMC JIMMY MY GIRLFRIEND WAS INVOLVED IN AN ACCIDENT. SHE CAME AROUND A CORNER AND HAD TO COME TO A QUICK STOP, WHEN SHE HIT THE BRAKES THE PEDAL WENT RIGHT TO THE FLOOR AND SHE HIT THE VEHICLE IN FRONT OF HER. AFTER THE INCIDENT I TOOK MY VEHICLE TO MY MECHANIC, AND HE FOUND THE STEM THAT COMES OFF THE MASTER CYLINDER HAD BROKEN OFF. HE CONTACTED THE NHTSA AND THE AGENT AGREED WITH HIM THAT THIS PART SHOULD NOT HAVE BROKE OFF. MY VEHICLE WAS DAMAGED SEVERELY AND IF THIS PART DID NOT BREAK AND THE PARTS WORKED CORRECTLY THIS COULD HAVE BEEN AVOIDED. *TR
NHTSA ODI #10249613
Mileage unknown · Apr 29, 2008
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
I BOUGHT A 2000 JIMMY FROM OAK MOTORS. I HAVE HAD IT FOR 5 MONTHS. IN THE LAST 5 MONTHS I HAVE REPLACED THE ALTERNATOR, 3 PULLEYS, SERPENTINE BELT. THE BRAKES ARE GOING OUT, POWER STEERING IS GOING OUT, ENGINE IS TAPPING. I TOOK IT BACK AFTER HAVING IT FOR 10 DAYS BECAUSE THE SERVICE ENGINE LIGHT CAME ON. THEY WANTED 175.00…
Read full complaint
I BOUGHT A 2000 JIMMY FROM OAK MOTORS. I HAVE HAD IT FOR 5 MONTHS. IN THE LAST 5 MONTHS I HAVE REPLACED THE ALTERNATOR, 3 PULLEYS, SERPENTINE BELT. THE BRAKES ARE GOING OUT, POWER STEERING IS GOING OUT, ENGINE IS TAPPING. I TOOK IT BACK AFTER HAVING IT FOR 10 DAYS BECAUSE THE SERVICE ENGINE LIGHT CAME ON. THEY WANTED 175.00 TO LOOK AT IT. I WAS TOLD AT THE TIME OF PURCHASE THAT I HAD TO PURCHASE THE WARRANTY FOR 995.00, I THOUGHT THIS WAS TO COVER ANY PROBLEM WITH THE VEHICLE. IT DOESN'T. THEY NOW WANT 540.00 TO FIX IT. PLEASE HELP. *TR
NHTSA ODI #10226039
69,500 miles · Jun 20, 2007
Service Brakes, Hydraulic
ABS SENSOR FAILURE ON 2000 GMC JIMMY 4WD FRONT DRIVER'S SIDE.*AK
NHTSA ODI #10193783
78,000 miles · Apr 12, 2007
Fuel System, GasolineService Brakes, Hydraulic
TL* - THE CONTACT OWNS A 2000 GMC JIMMY. THE VEHICLE VIBRATED LOUDLY WHEN BEING STARTED. THE REPAIR SHOP REPLACED THE WHEEL CYLINDER FOR A THIRD TIME. ALSO, THE FUEL SENSOR NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 78,000 AND THE CURRENT MILEAGE WAS 87,000. *AK
NHTSA ODI #10187655
85,000 miles · Feb 13, 2006
Service Brakes, Hydraulic
DT*: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS COMING TO A STOP, THE ANTILOCK BRAKES ENGAGED MAKING THE VEHICLE DIFFICULT TO STOP. THE DEALERSHIP AND MANUFACTURER WAS NOTIFIED HOWEVER, NO REPAIRS WERE MADE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. UPON INSPECTION, THE MECHANIC TOOK OUT THE FUS…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS COMING TO A STOP, THE ANTILOCK BRAKES ENGAGED MAKING THE VEHICLE DIFFICULT TO STOP. THE DEALERSHIP AND MANUFACTURER WAS NOTIFIED HOWEVER, NO REPAIRS WERE MADE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP FOR INSPECTION. UPON INSPECTION, THE MECHANIC TOOK OUT THE FUSE TO THE ANTILOCK BRAKES.
NHTSA ODI #10150135
Mileage unknown · Nov 29, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATES THERE IS NHTSA RECALL CAMPAIGN 99V220000 CONCERNING ANTI LOCK BRAKES. THIS VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL, BUT IT IS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK
NHTSA ODI #10143921
Official recalls
4May 21, 2008
GENERAL MOTORS IS RECALLING 5,862 MY 2000-2002 CHEVROLET BLAZER, MY 2000-2001 GMC JIMMY, AND MY 2000 OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. THE RECALL BEGAN ON JUNE 17, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, OR OLDSMOBILE AT 1-800-630-6537, OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> . NOTE: THIS CAMPAIGN IS AN EXPANSION OF A PREVIOUS RECALL (PLEASE SEE 01V364).
Dec 3, 2001
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence & remedy
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Exterior Lighting:brake Lights:switch
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES. THE MULTIFUNCTION SWITCH COULD DEVELOP AN OPEN CIRCUIT CONDITION THAT RESULTS IN THE STOP LAMPS AND THE REAR HAZARD LAMPS BECOMING INOPERATIVE. THE CENTER HIGH MOUNTED STOP LAMP AND TURN SIGNAL FUNCTIONS ARE NOT AFFECTED.
Consequence: THE LOSS OF STOP LAMPS AND REAR HAZARD LAMPS COULD FAIL TO WARN A FOLLOWING DRIVER THAT THE VEHICLE IS BRAKING AND/OR IS STOPPED AND COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE HAZARD SWITCH CARRIER. OWNER NOTIFICATION WILL BE CONDUCTED IN TWO PHASES. THE FIRST PHASE BEGAN APRIL 15, 2002, WITH MAILINGS TO OWNERS OF 2000 AND EARLY 2001 VEHICLES. THE SECOND MAILING PHASE WILL BE TO REMAINING 2001 AND 2002 VEHICLES. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
Aug 7, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE VEHICLE'S SAFETY BELT BUCKLE ASSEMBLY DATE CODES AND, IF NECESSARY, WILL REPLACE ANY SAFETY BELT BUCKLE ASSEMBLY.
Aug 11, 1999
VEHICLE DESCRIPTION: S -TRUCKS EQUIPPED WITH 2 WHEEL DRIVE. THESE VEHICLES MAY HAVE HAD THE RIGHT-HAND ANTILOCK BRAKE SYSTEM (ABS) MODULE FEED PIPE AND/OR BRAKE CROSSOVER PIPE TUBE NUTS TIGHTENED WITHOUT SEATING THE PIPE-FLARED-ENDS ENOUGH TO WITHSTAND NORMAL ASSEMBLY AND VEHICLE INPUTS WITHOUT PARTIALLY UNSEATING. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 105, "HYDRAULIC SERVICE BRAKE NORMAL, EMERGENCY, AND PARK BRAKING PERFORMANCE."
Consequence & remedy
Consequence: IF THIS OCCURRED, THE SEATING SEAL COULD BE BROKEN DURING VEHICLE ASSEMBLY, OR FROM EARLY ROAD INPUTS OR BRAKE FLUID CYCLING, AND A LEAK COULD OCCUR INCREASING THE BRAKE STOPPING DISTANCE.
Remedy: DEALERS WILL INSPECT THE BRAKE PIPE UNION FOR SIGNS OF BRAKE FLUID, AND IF NECESSARY, INSTALL A NEW BRAKE PIPE UNION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ08001 · Hazard Light Switch Failure
Opened Feb 28, 2008 · Closed Jul 9, 2008
Status: closed (inferred from source dates) · Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Exterior Lighting:hazard Flashing Warning Lights:switch
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
Exterior Lighting:hazard Flashing Warning Lights:unit
ON NOVEMBER 30, 2001, GENERAL MOTORS (GM) CONDUCTED SAFETY RECALL 01V-364 FOR THE SUBJECT VEHICLES BUILT BETWEEN SEPTEMBER 16, 1999 AND AUGUST 28, 2001 TO REMEDY A DEFECTIVE HAZARD SWITCH THAT WOULD CAUSE A LOSS OF HAZARD AND STOP LAMP ILLUMINATION.THE HAZARD SWITCH IS CONTAINED WITHIN THE VEHICLE MULTIFUNCTION SWITCH.ODI OPENED THIS INVESTIGATION BASED ON REPORTS THAT SOME CONSUMERS WERE NOT NOTIFIED OF THE ORIGINAL RECALL OR THAT THEY HAD REPAIRS DONE UNDER 01V-364 BUT EXPERIENCED SUBSEQUENT MULTIFUNCTION SWITCH FAILURES.THE MULTIFUNCTION SWITCH SUPPORTS THE OPERATION OF CRUISE CONTROL, WINDSHIELD WIPERS, EXTERIOR LIGHTING AND TURN SIGNALS IN ADDITION TO HAZARD AND STOP LAMPS. ON MAY 21, 2008, GM NOTIFIED THE AGENCY THAT IT ERRONEOUSLY MISSED IDENTIFYING 5,862 VEHICLES THAT SHOULD HAVE BEEN INCLUDED IN RECALL 01V-364.GM WILL NOW NOTIFY OWNERS OF THESE VEHICLES UNDER A NEW NHTSA RECALL NUMBER 08V-231.OWNER NOTIFICATION BEGAN ON JUNE 17.THE PRIMARY CAUSE OF BRAKE LAMP FAILURE WAS A DESIGN CHANGE FROM COPPER TO BRASS CONTACT MATERIAL IN THE HAZARD SWITCH.THIS CHANGE WAS EFFECTIVE FOR VEHICLES BUILT AFTER SEPTEMBER 16, 1999.GM CHANGED THE MATERIAL BACK TO COPPER FOR VEHICLES BUILT AFTER AUGUST 28, 2001. THE REMEDY PART FOR BOTH 01V-364 AND 08V-231 CONTAINS COPPER CONTACTS.GM'S DATA SHOWS THAT LESS THAN 1% OF VEHICLES REPAIRED UNDER RECALL 01V-364 REQUIRED ADDITIONAL SUBSEQUENT REPAIR OR REPLACEMENT OF THE HAZARD OR MULTIFUNCTION SWITCH.THIS INVESTIGATION IS CLOSED.
PE01032 · Loss Of Stop Lamp Illumination
Opened Sep 6, 2001 · Closed Dec 20, 2001
Status: closed (inferred from source dates) · Exterior Lighting
No summary supplied.
Illustration