ENGINE AND ENGINE COOLING:COOLING SYSTEM. ENGINE COOLANT HAS BROKEN DOWN AT 60,000 MILES 10/1/2001, 70,000 MILES 6/1/2002, 79,000 1/30/2003 AND HAS BECAME SLUDGE. OWNER'S MANUAL STATES 100,000 MILE MAINTENANCE. DEALER (GMC)WANTS TO REPLACE THERMOSTAT, RADIATOR, HEATER CORE AT MY EXPENSE. SYSTEM HAS BEEN SUPER FLUSHED, CLE…
Read full complaint
ENGINE AND ENGINE COOLING:COOLING SYSTEM. ENGINE COOLANT HAS BROKEN DOWN AT 60,000 MILES 10/1/2001, 70,000 MILES 6/1/2002, 79,000 1/30/2003 AND HAS BECAME SLUDGE. OWNER'S MANUAL STATES 100,000 MILE MAINTENANCE. DEALER (GMC)WANTS TO REPLACE THERMOSTAT, RADIATOR, HEATER CORE AT MY EXPENSE. SYSTEM HAS BEEN SUPER FLUSHED, CLEANED AND NEW DEX-COOL COOLANT PER DEALER RECOMMENDATIONS. DEALER EVEN STATES COOLANT IS BAD. GMC STATES IIT IS MY FAULT.
NHTSA ODI #10005053
Mileage unknown · Jan 30, 2002
Engine And Engine CoolingEquipmentFuel System, Gasoline
CONSUMER STATED THAT VEHICLE IS ON ITS 3RD TRANMISSION, THE TRANSMISSION DIPSTICK AND HOUSING NEEDED TO BE REPLACED DUE TO RUST FORMING ON THE TRANMISSION FLUID STICK, ALSO THE REAR AXLE SEALS WER REPLACED.*JB
NHTSA ODI #564181
Mileage unknown · Dec 19, 2000
Electrical SystemEquipmentFuel System, Gasoline
I WOULD LIKE TO SUGGEST THAT THE ENTIRE 1996 GMC- JIMMY SERIES MADE NEED TO BE RECALLED BECAUSE THE OWNER HAS TO MANY REPAIRS TO BE DONE ON THE VEHICLE. THE SERVICES ENGINE LIGHT COMES VERY OFTEN TO INDICATE REPAIRS ON THE TRUCK AND THEIR ARE TO BE PROBLEMS WITH THIS 1996 JIMMY. I SUGGEST A TOTAL RECALL OF THIS VEHICLE AND THI…
Read full complaint
I WOULD LIKE TO SUGGEST THAT THE ENTIRE 1996 GMC- JIMMY SERIES MADE NEED TO BE RECALLED BECAUSE THE OWNER HAS TO MANY REPAIRS TO BE DONE ON THE VEHICLE. THE SERVICES ENGINE LIGHT COMES VERY OFTEN TO INDICATE REPAIRS ON THE TRUCK AND THEIR ARE TO BE PROBLEMS WITH THIS 1996 JIMMY. I SUGGEST A TOTAL RECALL OF THIS VEHICLE AND THIS VEHICLE IS UNSAFE TO BE ON THE ROAD. IT HAS A VERY BAD BRAKING SYSTEM ABS.*AK
NHTSA ODI #738028
Mileage unknown · Jul 27, 1998
Equipment
THE COMPRESSOR AND CONVERTER COIL BURNED OUT WHEN USING THE AIR CONDITIONER . *AK
NHTSA ODI #825917
Mileage unknown · Sep 2, 1997
Electrical SystemEngine And Engine CoolingEquipment
DRAIN PLUG AND OIL PAN BOLTS WERE LEAKING.
NHTSA ODI #520993
Mileage unknown · Aug 15, 1997
Engine And Engine CoolingEquipmentFuel System, Gasoline
OIL LEAKS CONTINUOUSLY FROM THE ENGINE COMPARTMENT.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR DURING BAD WEATHER, DRIVER VISIBILITY WOULD BE REDUCED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER. OWNER NOTIFICATION BEGAN ON JUNE 19, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Consequence & remedy
Consequence: THIS CAN RESULT IN IMPAIRED STEERING OR STEERING LOSS, OR A PARTIAL OR COMPLETE COLLAPSE OF THE FRONT SUSPENSION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE BOTH UPPER BALL JOINTS. OWNER NOTIFICATION BEGAN SEPTEMBER 4, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT CHEVROLET AT 1-800-222-1020, GMC AT 1-800-462-8782, OR OLDSMOBILE AT 1-800-442-6537.
VEHICLE DESCRIPTION: CERTAIN 4-WHEEL DRIVE PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH ABS (ANTILOCK BRAKING SYSTEM) MANUFACTURED FROM SEPTEMBER 1989 THROUGH AUGUST 1996. UNDER CERTAIN DRIVING CONDITIONS THE SWITCH WHICH SIGNALS THE ABS SYSTEM WHETHER THE VEHICLE IS IN 2-WHEEL OR 4-WHEEL DRIVE CAN MALFUNCTION CAUSING INCREASED STOPPING DISTANCES DURING ABS STOPS WHILE IN THE TWO-WHEEL DRIVE MODE.
Consequence & remedy
Consequence: IF THIS OCCURRED AT A TIME WHEN MINIMUM STOPPING DISTANCE WAS REQUIRED, A VEHICLE CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE OR REPAIR THE 4-WHEEL/2-WHEEL DRIVE SWITCH.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS AND SPORT UTILITY VEHICLES, 2 AND 4-WHEEL DRIVE. SOLDER JOINTS NEAR THE WIRING HARNESS CONNECTOR CAN CRACK CAUSING THE WINDSHIELD WIPERS TO WORK INTERMITTENTLY.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INOPERATIVE WIPERS, REDUCING A DRIVER'S VISIBILITY, AND INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE WIPER MOTOR CIRCUIT BOARD AND COVER.
VEHICLE DESCRIPTION: EXTENDED CAB PICKUP TRUCKS EQUIPPED WITH 60/40 FRONT BENCH SEATS AND EXTENDED CAB PICKUP TRUCKS AND 2-DOOR UTILITY VEHICLES EQUIPPED WITH MANUAL LOCKING RECLINER BUCKET SEATS. THE OUTBOARD SAFETY BELT WEBBING ON THE DRIVER'S AND/OR PASSENGER'S SEAT CAN SEPARATE DURING A FRONTAL IMPACT.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED AND THERE WERE SECONDARY CRASH EVENTS OR VEHICLE ROLLOVER, THERE WOULD BE NO BELT RESTRAINT OF THE OCCUPANT AND INCREASED INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSTALL A PROTECTIVE COVER OVER THE RECLINER MECHANISM.
VEHICLE DESCRIPTION: 4-DOOR, 4-WHEEL DRIVE AND ALL-WHEEL DRIVE MULTI-PURPOSE PASSENGER VEHICLES. DURING DEVELOPMENT TESTING, THE PROP SHAFT CONTACTED THE INBOARD SIDE OF THE FUEL TANK ALLOWING FUEL LEAKAGE. THIS LEAKAGE WAS IN EXCESS OF THE AMOUNT PERMITTED BY FMVSS 301, "FUEL SYSTEM INTEGRITY."
Consequence & remedy
Consequence: IF AN IGNITION SOURCE IS PRESENT, AND THERE IS A FUEL LEAK, A FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL ADDITIONAL SHIELDING OF THE FUEL TANK. THIS WILL BE ADDED WITHOUT REMOVING OR DISASSEMBLING THE FUEL SYSTEM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
EA02006 · Windshield Wiper Failure
Opened May 31, 2002 · Closed Jul 23, 2003
Status: closed (inferred from source dates) · Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Additional source detail variants (2)
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
Visibility:windshield Wiper/washer:motor
AS A RESULT OF THIS, AND THE PRECEDINGINVESTIGATION, RQ99-003, GM HAS EXPANDED THE POPULATION OF SAFETY RECALL 98V-150 (REPLACEMENT OF THE WINDSHIELD WIPER CONTROL MODULE) TO INCLUDE AN ADDITIONAL 1.77 MILLION VEHICLES.INCLUDED ARE VARIOUS 1994-1997 MY M/L VANS, S/T TRUCKS AND SUVS, & C/K TRUCKS AND SUVS.SEE ATTACHED TECHNICAL REPORT FOR DETAILS.
EA99022 · Upper And Lower Control Arm Ball Joint
Opened Jul 30, 1999 · Closed Aug 28, 2001
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
Additional source detail variants (2)
Suspension
There is no summary currently available
Suspension
There is no summary currently available
PE99021 · Upper Control Arm Ball Joint Breakage
Opened Mar 5, 1999 · Closed Jul 30, 1999
Status: closed (inferred from source dates) · Power Train
AN UPPER CONTROL ARM BALL JOINT FAILS, RESULTING IN THE FRONT SUSPENSION COLLAPSING ON THE FAILED SIDE.
EA97004 · Seat Belt Webbing Separation
Opened Feb 28, 1997 · Closed Aug 5, 1997
Status: closed (inferred from source dates) · Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Additional source detail variants (2)
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
Seat Belts:front:webbing
NHTSA'S NEW CAR ASSESSMENT PROGRAM (NCAP) TESTED A 1997 CHEVROLET S-10 EXTENDED CAB PICKUP EQUIPPED WITH A DRIVER-SIDE AIR BAG.THE FRONT PASSENGER SEAT BELT WAS COMPLETELY CUT DURING THE TEST.
EA94038 · Abs Braking System
Opened Oct 31, 1994 · Closed Feb 28, 2000
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Additional source detail variants (2)
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
Service Brakes, Hydraulic
THIS INVESTIGATION RESULTED IN A SAFETY RECALL, 99V-193, AND A SERVICE CAMPAIGN, 99I-006.
1996 GMC Jimmy Problems, Complaints & Recalls | Skip That Year
Illustration