TL* THE CONTACT OWNS A 2004 GMC ENVOY. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH HE HAD THE SWERVE TO AVOID A HEADON COLLISION FROM A VEHICLE THAT WAS IN HIS LANE. THE VEHICLE WENT OFF THE ROAD AND CRASHED INTO A CONCRETE BARRIER.THE CONTACT HAD A FRACTURED STERNUM AND A BRUISED RIGHT ANKLE, KNEE AND ELBOW. THE CONTACT VIS…
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC ENVOY. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH HE HAD THE SWERVE TO AVOID A HEADON COLLISION FROM A VEHICLE THAT WAS IN HIS LANE. THE VEHICLE WENT OFF THE ROAD AND CRASHED INTO A CONCRETE BARRIER.THE CONTACT HAD A FRACTURED STERNUM AND A BRUISED RIGHT ANKLE, KNEE AND ELBOW. THE CONTACT VISITED THE EMERGENCY ROOM ON HIS OWN WITHOUT BEING TRANSPORTED BY AN AMBULANCE.THE CONTACT STATED THAT NONE OF THE AIR BAGS IN THE FRONT DEPLOYED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOTALED BY THE INSURANCE COMPANY AND TOWED FROM THE CRASH SITE. THE ENTIRE FRONT OF THE VEHICLE WAS SMASHED IN INCLUDING THE FRAME. THE BACK AXEL DROPPED AFTER THE COLLISION AND BOTH RIMS ON THE BACK TIRES WERE SHATTERED. THE FRONT RIMS WERE ALSO CRACKED. THE DEALER AND MANUFACTURER HAD NOT BEEN CONTACTED YET. THE FAILURE MILEAGE WAS 180,000.
NHTSA ODI #11378518
190,000 miles · May 9, 2020
Air Bags
REAR AIR COMPRESSOR BAGS ARE FAULTY....FROM WHAT I UNDERSTAND THIS IS HAPPENING TO MANY GMC ENVOYS AND NEED TO BE RECALLED!!! *TR
NHTSA ODI #11323942
169,000 miles · Oct 6, 2019
Air Bags
WAS DRIVING DOWN THE ROAD AND THE REPAIR SAFETY AIR BAG LIGHT CAME ON AND IS STILL ON
NHTSA ODI #11266637
Mileage unknown · Sep 16, 2019
Air Bags
THE SEAT BELT WAS ALWAYS ON SO I HAVE TO REPLACE THE BOTH IMPACTOR SENSOR.
NHTSA ODI #11255639
Mileage unknown · Mar 13, 2019
Air BagsElectrical SystemStructure
TL* THE CONTACT OWNS A 2004 GMC ENVOY. WHILE THE VEHICLE WAS PARKED, THE TAILGATE LATCH AND MOTOR FAILED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TAILGATE MOTOR FAILED AND NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE AIR COMPRESSOR FAILED TO INFLATE THE AIR BAGS EVENLY. THE VEHICLE WAS TAKEN TO W-K CHEVROLET BUICK …
Read full complaint
TL* THE CONTACT OWNS A 2004 GMC ENVOY. WHILE THE VEHICLE WAS PARKED, THE TAILGATE LATCH AND MOTOR FAILED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE TAILGATE MOTOR FAILED AND NEEDED TO BE REPLACED. THE CONTACT ALSO STATED THAT THE AIR COMPRESSOR FAILED TO INFLATE THE AIR BAGS EVENLY. THE VEHICLE WAS TAKEN TO W-K CHEVROLET BUICK GMC CADILLAC (LOCATED AT 3310 W BROADWAY BLVD, SEDALIA, MO 65301, (660) 826-8320), BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS UNKNOWN.
NHTSA ODI #11186598
Mileage unknown · Jul 2, 2018
Air BagsElectrical SystemService Brakes
THE ABS LIGHT STAYED ON AFTER THE FACT I HAD THE BREAKS SERVICED A FEW YEARS AGO. THE AIRBAG LIGHT HAS BEEN ON FOR ABOUT A YEAR. NOW MY BREAK LIGHT STOPPED WORKING, I REPLACED THE FUSE AND STILL NOT WORKING AND NOW THE HEADLAMPS STOPPED WORKING. THEY ONLY WORK ON HIGH BEAM.
NHTSA ODI #11105041
117,000 miles · Nov 21, 2016
Air BagsCrashInjury
TL* THE CONTACT OWNED A 2004 GMC ENVOY. WHILE DRIVING 50 MPH, THE CONTACT DROVE THROUGH A RED LIGHT AND WAS IMPACTED BY ANOTHER VEHICLE ON THE DRIVER SIDE. THE AIR BAGS FAILED TO DEPLOY. DUE TO NOT WEARING A SEAT BELT, THE DRIVER WAS EJECTED THROUGH THE WINDSHIELD. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED ROAD RASH AND CU…
Read full complaint
TL* THE CONTACT OWNED A 2004 GMC ENVOY. WHILE DRIVING 50 MPH, THE CONTACT DROVE THROUGH A RED LIGHT AND WAS IMPACTED BY ANOTHER VEHICLE ON THE DRIVER SIDE. THE AIR BAGS FAILED TO DEPLOY. DUE TO NOT WEARING A SEAT BELT, THE DRIVER WAS EJECTED THROUGH THE WINDSHIELD. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED ROAD RASH AND CUTS THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN IMPOUND LOT AND THEN TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS DESTROYED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 117,000.
NHTSA ODI #10927207
159,335 miles · Jun 2, 2015
Air BagsSeatsUnknown Or Other
GOING DOWN THE ROAD TO WORK MY AIRBAG LIGHT COMES ON AND WONT GO OFF AND NOW I CANT GET A INSPECTION STICKER THERE WAS NO REASON FOR MY LIGHT TO COME ON UNLESS THERE IS SOMETHING WRONG WITH VEHICLE!!
NHTSA ODI #10722867
50,000 miles · Feb 28, 2015
Air BagsElectrical SystemSeat BeltsCrash
: NO AIR BAG/[ DEPLOYMENT FAILURE] FRONT/ SIDE/ REAR [ SIDE DESIGNED TO DEPLOY IN ROLLOVER OR SIDE IMPACT CRASHES] AIR BAG'S FAILURE / DEPLOYMENT COMPLETE ROLL ALL FOUR SIDES LANDED BACK ON WHEELS. I WAS SLAMMED ONTO LEFT DRIVER SIDE WINDOW LEFT SIDE FACE BROKE THE WINDOW AND GLASS AND DIRT FILLED VEHICLE SEAT BELT FAILURE:…
Read full complaint
: NO AIR BAG/[ DEPLOYMENT FAILURE] FRONT/ SIDE/ REAR [ SIDE DESIGNED TO DEPLOY IN ROLLOVER OR SIDE IMPACT CRASHES] AIR BAG'S FAILURE / DEPLOYMENT COMPLETE ROLL ALL FOUR SIDES LANDED BACK ON WHEELS. I WAS SLAMMED ONTO LEFT DRIVER SIDE WINDOW LEFT SIDE FACE BROKE THE WINDOW AND GLASS AND DIRT FILLED VEHICLE SEAT BELT FAILURE: LEFT/DRIVERS ONLY ROLLED FOUR TIMES LANDED BACK ON ALL FOURS I FLAILED AROUND HEAD BUTTED THE PASSENGER AS THE FORCE OVER TOOK MY BODY ONSITE OFFICER ACKNOWLEDGED THE INDICATIONS SEAT BELT FRICTION BURNS ALL ON AROUND NECK AND SHOULDER TRAUMATIC BRAIN INJURY TORN ROTATOR CUFF SHOULDER ISSUES/ ALSO BLADDER DAMAGE AS THE DRIVER'S SIDE SEAT BELT FAILED TO LOCK DURING CRASH DEALER SHOULD HAVE BEEN CITED FOR SEAT BELT FAILURE WORST THINGS OF ALL TIME ...IT WAS A TEST DRIVE ENGINE STALL FAILURE : AT HIGH SPEED/ HEARD NOISE AND BOOM LOST ALL POWER STEERING LOUD NOISE LOSS OF POWER/ I HAD NO IDEAL AT THE TIME THOUGHT POSSIBLE BLOW OUT AND INDICATED SUCH TO THE RESPONDING OFFICER ELECTRICAL - ALSO BRAKE LIGHT TURN SIGNAL FAILURE/ APPEARS TO BE FUNCTIONAL LIGHTS SIGNALS/ BUT ARE NOT WORKING ON THE OUTSIDE OTHERS DON'T SEE SIGNALS OR BRAKE LIGHTS . I WAS SITED FOR BTW GM SHOULD BE RESPONSIBLE AS WELL DEALERSHIP ALL THE RECALL AND COMPLAINT'S, INCIDENT REPORTS ACCIDENTS AND GM MAJOR IGNITION ISSUES....ENGINE FAILURE WHILE DRIVING/ EROSION AND MANY OTHER VEHICLES. *TR
NHTSA ODI #10691276
100,000 miles · Dec 16, 2014
Air Bags
TL* THE CONTACT OWNS A 2004 GMC ENVOY. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
ON CERTAIN TRUCKS AND SPORT UTILITY VEHICLES, THE DRIVER WISHING TO SIGNAL A TURN BY MOVING THE DIRECTIONAL SIGNAL LEVER, (UP OR DOWN) MAY CAUSE THE FRONT MARKER/TURN LIGHTS AND REAR TURN LIGHTS TO FLASH IN A MANNER SIMILAR TO HAZARD WARNING, RATHER THAN FLASHING ON THE DESIRED SIDE ONLY.
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO CLEARLY SIGNAL THEIR INTENTIONS TO TURN, CHANGE TRAVEL LANES, OR POTENTIALLY WARN OTHERS OF AN IMPAIRED VEHICLE OPERATING CONDITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE SUSPECT FLASHER MODULES WITH A NEW FLASHER MODULE DESIGNED WITH SEALED RELAYS AND MORE DURABLE CONTACT MATERIAL INSIDE OF THE RELAYS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 4, 2005. ISUZU BEGAN MAILING OWNER LETTERS ON AUGUST 4, 2005. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, ISUZU AT 1-800-255-6727, BUICK AT 1-866-608-8080, AND OLDSMOBILE AT 1-800-630-6537.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
RQ17002 · Loss Of Headlights
Opened Apr 24, 2017 · Closed Mar 29, 2021
Status: closed (inferred from source dates) · Exterior Lighting:headlights
The subject vehicles are model year (MY) 2002-2009 Chevrolet Trailblazer, GMC Envoy, 2004-2007 Buick Rainier, 2003-2008 Isuzu Ascender, 2005-2009 Saab 9-7X, 2002-2004 Oldsmobile Bravada, 2003-2006 Chevrolet SSR, 2005-2009 Buick Lacrosse, and 2006-2008 Pontiac Grand Prix. This scope includes the Trailblazer/Envoy variants: 2002-2006 Envoy XL/Trailblazer EXT and 2004-2005 Envoy XUV. The original scope of this investigation was expanded to include all vehicles equipped with the subject Headlight Driver Module (HDM). The focus of the investigation was to determine whether actions performed by General Motors adequately addressed any unreasonable risk to motor vehicle safety in the subject vehicles concerning the headlights and the HDM that controls them.Under normal electrical load and environmental conditions, the HDM can overheat inside the Underhood Electrical Center (UEC). This can cause the module to fail and result in a simultaneous loss of both low beam headlights and both daytime running lights (DRLs), often with no warning or prior detectability to the driver. This failure can be intermittent or permanent. No other exterior lights are affected. High beams, turn signals, brake lights, and reverse lights are still operational.General Motors addressed this issue with 2 recalls (14V755 & 15V519) and a special coverage program (N172091910). In view of the recalls and special coverage program implemented by GM and the vehicle high beams continuing to operate, ODI has tentatively concluded that the actions taken by GM mitigate any unreasonable risk to safety posed by HDM failure in the subject vehicles.Accordingly, the investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take additional action if warranted by new circumstances.The ODI reports cited above are available for review online at NHTSA.gov under the identification numbers in the attached document.
DURING THE COURSE OF THIS EA INVESTIGATION, ODI OBSERVED THAT THE MAJORITY OF THE COMPLAINTS (88%) AND WARRANTY CLAIMS (94%) WERE REPORTED FOR VEHICLES THAT ARE REGISTERED FOR USE IN THE SALT BELT REGION OF THE US.THIS AREA INCLUDES 20 STATES IN THE NORTHEAST, MID ATLANTIC AND THE MIDWEST REGIONS AND THE DISTRICT OF COLUMBIA.CONSUMERS IN THE SALT BELT REGION REPORTED TO ODI THAT THEY COULD SMELL FUEL VAPORS IN THEIR VEHICLES WHILE DRIVING.UPON FURTHER EXAMINATION OF THEIR VEHICLES, THEY DISCOVERED THAT FUEL VAPORS WERE COMING OUT OF THE TOP OF THE FUEL TANK. THIS CONDITION IS CAUSED BY CORROSION OF THE RETURN AND SENDER LINES OF THE FUEL PUMP MODULE.WATER AND ROAD SALT COLLECT ON TOP OF THE FUEL PUMP LEADING TO SMALL PINHOLES APPEARING ON THE FUEL LINES.FUEL MAY LEAK AND COLLECT ON TOP OF THE MODULE AND/OR SPILL ONTO THE GROUND.THE DATA EVALUATED UNDER THIS INVESTIGATION REFLECT A RELATIVELY LOW FREQUENCY OF OCCURRENCE THAT LARGELY ARISES IN SALT BELT STATES.GM HAS EXTENDED THE WARRANTY ON THE SUBJECT COMPONENT TO TEN YEARS OR 120,000 MILES.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED AT THIS TIME; ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION SELECT DOCUMENT SEARCH.
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Additional source detail variants (3)
Exterior Lighting:turn Signal:flasher Unit
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
Exterior Lighting:turn Signal:switch
BY LETTER DATED APRIL 29, 2005, GM NOTIFIED THE AGENCY THAT IT IS CONDUCTING ASAFETY RECALL ( NHTSA RECALL NO. 05V198 ) INVOLVING CERTAIN MODEL YEARS (MY) 2003-2004 ISUZU ASCENDER, CHEVROLET TRAILBLAZER, GMC ENVOY, OLDSMOBILE BRAVADA AND MY 2004 BUICK RAINER VEHICLES.THE RECALL APPLIES TO VEHICLES BUILT FROM APRIL 2003 THROUGH NOVEMBER 2003 FOR A TOTAL VEHICLE POPULATION OF 286,478.GM REPORTS THE DIRECTIONAL/HAZARD SIGNALS FAILURE IS DUE TO STICKING CONTACTS ON ROUTING RELAYS IN THE FLASHER MODULE.GM WILL REPLACE THE FLASHER MODULE ON ALL INVOLVED VEHICLES.BASED ON GM'S SAFETY RECALL ACTION, THIS INVESTIGATION IS CLOSED.
EA04021 · Brake Lamp Failure
Opened Aug 3, 2004 · Closed Nov 4, 2004
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights
GM STATES THAT SOME BRAKE/TAIL LAMP BULBS CAN PREMATURELY BECOME INOPERATIVE DUE TO MALFUNCTIONING BRAKE/TAIL LAMP SOCKETS.ON MARCH 2, 2004, GM INITIATED A 6-YEAR/72,000 MILE SPECIAL POLICY FOR 989,487 SUBJECT VEHICLES TO INSPECT AND REPLACE THE REAR BRAKE/TAIL LAMP BULB SOCKET ASSEMBLIES.ON APRIL 4, 2004, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE04-032) BASED ON CONSUMER COMPLAINTS ALLEGING BRAKE LIGHTS NOT OPERATING WHEN THE BRAKE PEDAL IS DEPRESSED.ON AUGUST 3, 2004 ODI UPGRADED PE04-032 TO AN ENGINEERING ANALYSIS (EA04-021).BY LETTER DATED OCTOBER 27, 2004 GM NOTIFIED NHTSA THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA # 04V527) COVERING SUBJECT VEHICLES THAT WERE NOT ALREADY REPAIRED UNDER GM'S SPECIAL POLICY.MY 2004 SUBJECT VEHICLES BUILT AFTER AUGUST 8, 2003 CONTAIN IMPROVED BRAKE LAMP ASSEMBLIES AND ARE NOT INCLUDED IN THE RECALL.GM DEALERS WILL INSTALL THE IMPROVED BRAKE LAMP ASSEMBLY ON SUBJECT VEHICLES BUILT ON AUGUST 8, 2003 AND EARLIER.THE ACTION TAKEN BY GM IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
2004 GMC Envoy Problems, Complaints & Recalls | Skip That Year
Illustration