IllustrationFIRE INSIDE DASH OF VEHICLE. FIRE WAS CAUSED BY A DEFECTIVE MODULE THAT ALREADY HAS A SAFETY RECALL. THE MFG. WILL NOT REPLACE PARTS/REPAIR VEHICLE. THEY STATE VEHICLE HAD RECALL DONE ALREADY. REPLACEMENT PARTS ARE NOT AVAILABLE AS THE RECALL UPDATES SUPERCEDES THESE PARTS WITH AN UPGRADE KIT (THE RECALL). *TR
2003 Gem Nev
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Nev years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports1 fire reports0 injury reports
What owners actually said
2 reportsTL*THE CONTACT OWNS A 2003 CHRYSLER ELECTRIC GEM. WHILE DRIVING AT 10 MPH THE CONTACT HEARD A LOUD CLINKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE FASTER THE VEHICLE ACCELERATED THE LOUDER THE NOISE BECAME . THE CONTACT CALLED GLOBAL ELECTRIC MOTOR COMPANY, AND THEY SUGGESTED THAT THE FAILURE MAY BE THE FRONT AXLE. …
Read full complaint
TL*THE CONTACT OWNS A 2003 CHRYSLER ELECTRIC GEM. WHILE DRIVING AT 10 MPH THE CONTACT HEARD A LOUD CLINKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE FASTER THE VEHICLE ACCELERATED THE LOUDER THE NOISE BECAME . THE CONTACT CALLED GLOBAL ELECTRIC MOTOR COMPANY, AND THEY SUGGESTED THAT THE FAILURE MAY BE THE FRONT AXLE. THE NECESSARY PARTS FOR THE REPAIR WERE ON BACK ORDER. THE CURRENT MILEAGE WAS 7,346, AND FAILURE MILEAGE WAS UNKNOWN.*AK THE CONSUMER STATED THAT THE DEALER SET UP APPOINTMENT AND CAME TO REPAIR THE VEHICLE. UPDATE 05/04/07*TR
Official recalls
106V222000 · Electrical System
Jun 21, 2006
ON CERTAIN 2 AND 4 PASSENGER, SHORT AND LONG BED LOW SPEED VEHICLES, THE 12 VOLT OUTPUT FROM THE AUXILIARY CARD CIRCUIT BOARD (A DC VOLTAGE TO DC VOLTAGE CONVERTER) MAY BECOME INOPERATIVE AND RESULT IN LOSS OF HEADLAMP, TAIL LAMP AND TURN SIGNAL LAMP FUNCTIONS.
Consequence & remedy
Consequence: A LOSS OF HEADLAMPS COULD IMPAIR A DRIVER'S VISIBILITY, INCREASING THE RISK OF A CRASH. IF THERE IS A LOSS OF TAIL LAMP OR TURN SIGNAL LAMP FUNCTION, A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED OR THAT THE VEHICLE IN FRONT IS TURNING, A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE AUXILIARY CARDS, INSTALL A SPLASH/SPRAY PROTECTION, AND ADJUST THE DASH SEAL FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS MAY CONTACT GLOBAL ELECTRIC AT 888-871-4367.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.