IllustrationWHEN DRIVING AT ANY SPEED VEHICLE WAS ALL OVER THE ROAD. REAR END WAS OUT OF ALIGNMENT. *AK
2004 Freightliner Xc Motorhome Chassis
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Xc Motorhome Chassis years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
Suspension complaints
1 reportsOfficial recalls
205V408000 · Steering:linkages
Sep 13, 2005
ON CERTAIN TRUCK AND MOTOR HOME CHASSIS EQUIPPED WITH I-SHAFTS SUPPLIED BY ZF HEAVY DUTY STEERING, THERE IS A POTENTIAL FOR A FAILURE OF THE FORK/SHAFT CONNECTION.
Consequence & remedy
Consequence: IF THIS OCCURS, THE VEHICLE COULD SUFFER A LOSS OF STEERING ABILITY, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT AND ATTACH A TENSION COLLAR TO THE STEERING SHAFT TO SECURE THE CONNECTION TO THE YOKE. THE RECALL BEGAN ON NOVEMBER 16, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
04V283000 · Service Brakes, Air:supply:low Pressure Warning:switch
Jun 9, 2004
CERTAIN MOTOR HOME CHASSIS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' IN A SITUATION IN WHICH MULTIPLE ALARMS ARE ACTIVE, A CHECK ENGINE, STOP ENGINE, OR SIMILAR WARNING INDICATOR IS GIVEN PRIORITY OVER THE LOW AIR ALARM BY THE INSTRUMENT SYSTEM CONTROLLER SOFTWARE. IF THE OPERATOR DOES NOT ACKNOWLEDGE THESE HIGHER PRIORITY ALARMS, A LOW AIR ALARM MAY NOT BE DISPLAYED.
Consequence & remedy
Consequence: THIS MEANS THAT A VEHICLE COULD BE DRIVEN WITH THE AIR PRESSURE BELOW 60 PSI WITHOUT THE LOW AIR WARNING SOUNDING, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL RE-PROGRAM THE MULTI-MODULE DATA CONTROLLER SOFTWARE. THE RECALL BEGAN ON JULY 6, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.