Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Equipment. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
4 reports
350,000 miles · Sep 22, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED WHILE DRIVING 64 MPH, THE EXHAUST FUME CAME INTO THE CAB THROUGH THE AIR CONDITIONING SYSTEM INTAKE. THERE WAS A SMELL OF FUME PRESENT WITHIN THE VEHICLE. THE PROBLEM OCCURRED EITHER WHILE DRIVING OR WHEN IN AN IDLE POSITION. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THE CLUMPS AND MAN…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING 64 MPH, THE EXHAUST FUME CAME INTO THE CAB THROUGH THE AIR CONDITIONING SYSTEM INTAKE. THERE WAS A SMELL OF FUME PRESENT WITHIN THE VEHICLE. THE PROBLEM OCCURRED EITHER WHILE DRIVING OR WHEN IN AN IDLE POSITION. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO DETERMINED THE CLUMPS AND MANIFOLD HOSE WERE DEFECTIVE. THE PARTS WERE REPLACED.
NHTSA ODI #10168973
Mileage unknown · Aug 8, 2002
Suspension
WHILE DRIVING 50 MPH AND WITHOUT WARNING REAR LEFT LEAF SEPARATED FROM WHEEL FRAME, RESULTING IN MAJOR DAMAGE TO TRUCK. DEALER HAS BEEN NOTIFIED; HOWEVER UNABLE TO REMEDY THE PROBLEM.*AK
NHTSA ODI #8015853
Mileage unknown · Sep 28, 2001
Equipment
CONTINUAL PROBLEM WITH THE AIR GUAGES BEING INACCURATE, THEY WILL NOT DROP TO ZERO WHEN AIR TANKS ARE DRAINED THEY STILL SHOW 15-20 LBS OF AIR PRESSURE THEY ARE OFF 10-20% WHEN AIR TANKS ARE FULL, CHP INSPECTIONS AT TERMINAL HAVE FOUND ALL AIR GUAGES INCLUDING THE GUAGE THAT WAS REPLACED TO BE INACCURATE.*JB
NHTSA ODI #563555
Mileage unknown · Oct 27, 1998
TiresInjury
TIRE BLEW OUT ON SIDEWALL RESULTING IN VEHICLE ROLLOVER ACCIDENT.(BRIDGESTONE 295/75R/225).
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS AND SCHOOL BUS CHASSIS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
Consequence & remedy
Consequence: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THE WINDSHIELD WIPER CONNECTING LINKAGE SOCKETS CAN WEAR OUT PREMATURELY DUE TO INSUFFICIENT GREASING DURING ASSEMBLY.
Consequence & remedy
Consequence: THIS CAN LEAD TO A SEPARATION OF THE LINKAGE AND LOSS OF WIPER FUNCTION, IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL REPLACE THE CONNECTING LINKAGES WITH NEW LINKS THAT ARE PROPERLY LUBRICATED.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR INTERAXLE DRIVELINE U-JOINTS. DEFLECTOR RINGS, A PART OF THE SYSTEM TO SEAL THE U-JOINTS FROM CONTAMINATES, ARE LOOSE. THIS ALLOWS WATER TO ENTER THE U-JOINT BEARING AREA RESULT IN DILUTION OF THE LUBRICANT, OXIDATION OF THE BEARING AND SEAL SURFACES, AND LOSS OF LUBRICANT.
Consequence & remedy
Consequence: IF THIS PROBLEM GOES UNDETECTED, THE INTERAXLE DRIVELINE CAN SEPARATE FROM THE VEHICLE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE U-JOINTS WITH THE CURRENT DESIGN U-JOINTS.
VEHICLE DESCRIPTION: HEAVY DUTY TRUCK. LEAKS THROUGH THE FIREWALL OR STEERING SHAFT BOOTS ALLOWS WATER TO RUN DOWN THE STEERING SHAFT. THE STEERING SHAFT SLIP SPLINE CORRODES CAUSING IT TO SEIZE.
Consequence & remedy
Consequence: INCREASED STEERING EFFORT CAN RESULT INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING SHAFT WITH A NEW DESIGN THAT IS INSTALLED IN AN INVERTED ORIENTATION SO NO WATER CAN ENTER THE SPLINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE02088 · Integral Hub And Bearing Assembly
Opened Nov 22, 2002 · Closed May 1, 2003
Status: closed (inferred from source dates) · Wheels
FREIGHTLINER SUBMITTED A DEFECT REPORT ON MARCH 21, 2003 IN WHICH THEY IDENTIFIED APPROXIMATELY 5000 TRUCKS AS POSSIBLY BEINGAFFECTED BY THIS PROBLEM.ARVINMERITOR (FRONT AXLE MFR) SUBMITTED A DEFECT REPORT ONAPRIL 16, 2003, WHICH IDENTIFIES 6098 FREIGHTLINER TRUCKS ASBEING AFFECTED BY THIS RECALL AND 1191 AXLES SOLD TO FREIGHTLINER IN THE AFTERMARKET. ODI NOTES THAT THERE ARE TWOINTEGRAL HUB AND BEARING ASSEMBLIES PER FRONT AXLE.FREIGHTLINER IDENTIFIED VEHICLES INCLUDINGFREIGHTLINER,STERLING, AND WESTERN STAR BRAND NAME AS BEINGAFFECTED BY THIS RECALL.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.
Additional source detail variants (3)
Wheels
FREIGHTLINER SUBMITTED A DEFECT REPORT ON MARCH 21, 2003 IN WHICH THEY IDENTIFIED APPROXIMATELY 5000 TRUCKS AS POSSIBLY BEINGAFFECTED BY THIS PROBLEM.ARVINMERITOR (FRONT AXLE MFR) SUBMITTED A DEFECT REPORT ONAPRIL 16, 2003, WHICH IDENTIFIES 6098 FREIGHTLINER TRUCKS ASBEING AFFECTED BY THIS RECALL AND 1191 AXLES SOLD TO FREIGHTLINER IN THE AFTERMARKET. ODI NOTES THAT THERE ARE TWOINTEGRAL HUB AND BEARING ASSEMBLIES PER FRONT AXLE.FREIGHTLINER IDENTIFIED VEHICLES INCLUDINGFREIGHTLINER,STERLING, AND WESTERN STAR BRAND NAME AS BEINGAFFECTED BY THIS RECALL.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.
Wheels
FREIGHTLINER SUBMITTED A DEFECT REPORT ON MARCH 21, 2003 IN WHICH THEY IDENTIFIED APPROXIMATELY 5000 TRUCKS AS POSSIBLY BEINGAFFECTED BY THIS PROBLEM.ARVINMERITOR (FRONT AXLE MFR) SUBMITTED A DEFECT REPORT ONAPRIL 16, 2003, WHICH IDENTIFIES 6098 FREIGHTLINER TRUCKS ASBEING AFFECTED BY THIS RECALL AND 1191 AXLES SOLD TO FREIGHTLINER IN THE AFTERMARKET. ODI NOTES THAT THERE ARE TWOINTEGRAL HUB AND BEARING ASSEMBLIES PER FRONT AXLE.FREIGHTLINER IDENTIFIED VEHICLES INCLUDINGFREIGHTLINER,STERLING, AND WESTERN STAR BRAND NAME AS BEINGAFFECTED BY THIS RECALL.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.
Wheels
FREIGHTLINER SUBMITTED A DEFECT REPORT ON MARCH 21, 2003 IN WHICH THEY IDENTIFIED APPROXIMATELY 5000 TRUCKS AS POSSIBLY BEINGAFFECTED BY THIS PROBLEM.ARVINMERITOR (FRONT AXLE MFR) SUBMITTED A DEFECT REPORT ONAPRIL 16, 2003, WHICH IDENTIFIES 6098 FREIGHTLINER TRUCKS ASBEING AFFECTED BY THIS RECALL AND 1191 AXLES SOLD TO FREIGHTLINER IN THE AFTERMARKET. ODI NOTES THAT THERE ARE TWOINTEGRAL HUB AND BEARING ASSEMBLIES PER FRONT AXLE.FREIGHTLINER IDENTIFIED VEHICLES INCLUDINGFREIGHTLINER,STERLING, AND WESTERN STAR BRAND NAME AS BEINGAFFECTED BY THIS RECALL.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.
1997 Freightliner Century Problems, Complaints & Recalls | Skip That Year
Illustration