2021 Ford Transit

Sun visors become exceptionally stiff and cannot no be dropped to protect from glaring sun. This creates a driving distraction. The visors reach a point where they are so tightly frozen that an effort to lower them causes the sun visor mount to sheer off. Now I have no working sun visors. Ford says it's not a reported issue, but that's not true at all. See this string from Ford Transit USA Forum. [XXX] There are many other reports of the problem. Ford dealers say it's not a warranty or recall issue. Some people have had the sun visors replaced, but the defect shows up again. There is definitely a design and manufacturing issue that creates a very serious safety issue. Try driving into the sun without a visor! It's blinding and extremely dangerous. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The belts were shifting/separating from the trade of my tire. I noticed an increasing vibration in the steering which lead me to take it to a tire shop to check it out. Fortunately I had read about this issue on a forum and caught the problem before a catastrophic failure, I took the van to a Ford dealership to replace the two front tyres, and the remaining four tyres are on order in due to be replaced in the next few days. Unfortunately, I did not think to keep the tire or take any photographs. But he wasn’t noticeable bulge in the tire. The tire was manufactured in the 44th week of 2000. The van was delivered to Forest River and built out as an RV in 2002.

The contact's business owns a 2021 Ford Transit. The contact stated while an employee was driving at approximately 30 MPH, the rear passenger’s side tire detached from the axle and landed into a front yard. The vehicle was stopped immediately. The vehicle was taken to an independent mechanic where it was diagnosed that the hub bolts sheared off and needed to be replaced. The vehicle was currently being repaired. The manufacturer was notified of the failure. The failure mileage was 160,215.

On my 2021 Transit 250, Ford has warrantied 2 front drive axles, the 1st was at 42.4k and second was at 50k. Service writer and tech could not explain why this is occurring. Called Ford customer service line, no tsb or ssm out there, no recall(same as dealer advised). I am aware this is not an isolated incident to me as have found online other instances. If front axle seizes due to lack of fluid due to this issue sudden loss of power or control would be possible. To my understanding and dealers understanding there is no warring light for low diff oil. tried to upload service writeup but would not take

Noise in the rear of the vehicle during low speed tight turns (parking lot speed). Vehicle has had axle bearing/hub replaced along with 7585W oil. The problem never went away even after this repair and has become worse. The dealership has had my vehicle for over 2 weeks and cannot find the problem. My concerns are: The dealership cannot diagnose the problem and if the problem is related to the drive line it could lead to a failure at highway speeds which could be catastrophic.

The contact owns a 2021 Ford Transit. The contact stated that while attempting to enter the rear of the vehicle, he became aware that the rear door would not latch closed. After a visual inspection, the contact observed a gap between the door and frame of the vehicle, as well as the rear door protruding outward. The door-ajar warning light was illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the lock and unlock rod. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but referred the contact to the NHTSA Hotline for assistance. The failure mileage was 10,000.

Per Mr. [XXX]: My daughter and members of our church’s high school youth group were on their way to a summer missions project in western Virginia/eastern Tennessee in an Enterprise rental van when the [DRIVERS' SIDE] rear tire started to separate from the vehicle as they were driving south on [XXX] near Staunton! Fortunately, the dad who was driving was able to safely steer the van to the side of the road, where the kids and their suitcases were re-distributed among the other vehicles in the caravan. They called Enterprise, but they had no vehicles to spare, so they told the driver to leave the van by the side of the road and they would dispatch a wrecker to pick it up. Have you seen this happen before with Ford Transit axles? But for the driver’s alertness, this could have been a headline-making event! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I received a letter fromKIA that said a fire can occur in the area of the tow hitch harness module while driving or while the vehicle is parked with the ignition off.Debris and moisture contamination on the tow hitch harness module printed circuit board ( PCB) which may cause an electrical short circuit , increasing the risk of a fire. A fire increases the risk of injury.I received a letter from KIA America Headquarters that a Recall Number 22V703 applies to my 2017 KIA Sportage which is equipped with a Genuine KIA tow hitch harness accessory. It said KIA has identified my vehicle as one that has the above defect. This letter was dated 11/11/22 but I received it in my mail today 12/20/22. It also said KIA will send me a letter when a remedy is found. In the mean time I should park my vehicle outdoors and away from other vehicles or structures until They have this recall performed. KIA also said in this letter they will send me another letter when a recall remedy is available.I need a vehicle to take me, my wife and family to doctor appointments, the hospital and other medically necessary places. This is not an acceptable nor reasonable request from KIA. It is causing unreasonable and untimely risk to us and we are asking you for help with this issue. The least KIA should provide is another vehicle to drive until they resolve this safety risk. Thank you for your help.

Broken Valve Stem - While on vacation the warning light came on telling me I only had 15 pounds of pressure in my right inside rear tire (has dual tires.) I pumped it and took it to a tire store in Twin Falls Idaho. They could not find a leak and sent me on my way. When home in California I took it to La Mesa RV who found the broken valve stem. They said they had seen quite a few on this vehicle and recommended replacing all. They gave me the name of several close by tire shops. The one I picked recommended changing all the stems out because they had seen a number of failures with the 2021 Transits. I did this but now don't have a TPMS since I didn't want to get another one that was likely to fail. Ford should do a recall and put in long stem valve stems that don't brake and also making adding air easier than the OEM ones. I am picking safety over having a TPMS. I wish I could have both. Picture will show removed stems with the one that broke off.