NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
60 reportsClear category filter120,000 miles · Nov 17, 2020
Fuel System, GasolinePower Train
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V767000 (POWER TRAIN) HOWEVER THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE LOCAL DEALER FULLERTON FORD LOCATED AT 1044 U.S. ROUTE 22 EAST, SOMERVILLE, NJ 08876 WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WA…
Read full complaint
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V767000 (POWER TRAIN) HOWEVER THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE LOCAL DEALER FULLERTON FORD LOCATED AT 1044 U.S. ROUTE 22 EAST, SOMERVILLE, NJ 08876 WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE VEHICLE EXPERIENCED THE FAILURE LISTED IN THE RECALL CAUSING THE VEHICLE TO STALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. PARTS DISTRIBUTION DISCONNECT.
NHTSA ODI #11375009
148,000 miles · Nov 16, 2020
Fuel/propulsion SystemPower TrainService Brakes
THE DRIVELINE BROKER FROM IT'S HOLDING MOUNT WHILE DRIVING AND TANGLED UP THE FUEL LINE AND BRAKE LINES GOING TO THE REAR OF THE VAN. MAKING THE VAN LOSE POWER AND NOT BE ABLE TO BE DRIVEN ANYMORE. THIS HAPPENED WHILE DRIVING ON THE FREEWAY. THIS IS EXTREMELY DANGEROUS. ALSO THEY HAVE A RECALL ON THE REAR FLEX JOINT WHICH THE…
Read full complaint
THE DRIVELINE BROKER FROM IT'S HOLDING MOUNT WHILE DRIVING AND TANGLED UP THE FUEL LINE AND BRAKE LINES GOING TO THE REAR OF THE VAN. MAKING THE VAN LOSE POWER AND NOT BE ABLE TO BE DRIVEN ANYMORE. THIS HAPPENED WHILE DRIVING ON THE FREEWAY. THIS IS EXTREMELY DANGEROUS. ALSO THEY HAVE A RECALL ON THE REAR FLEX JOINT WHICH THE FORD DEALERSHIP HAS RECOGNIZED BUT ARE REFUSING TO PAY FOR THE TOTAL REPAIR. HOW IS THAT FAIR? IT IS FORD'S DESIGN FLAW THAT MADE THIS HAPPEN.
NHTSA ODI #11374856
238,000 miles · Aug 7, 2020
Power Train
FLEXIBLE COUPLING CONNECTING TO DRIVESHAFT DAMAGED WHILE DRIVING AT SPEED OF 70 MPH. LOUD BOOM UNDERNEATH OF DRIVER SEAT. VEHICLE STARTS TO MAKE NOISE LIKE YOUR EXHAUST SYSTEM FAILED. IT ALSO SHAKES WHEN GOING FROM 0 TO 40 MPH THEN IT GOES AWAY. LUCKY IT DID NOT FALL APART. THIS RECALL MUST BE TAKEN SERIOUSLY BY FORD AND ENFORCE…
Read full complaint
FLEXIBLE COUPLING CONNECTING TO DRIVESHAFT DAMAGED WHILE DRIVING AT SPEED OF 70 MPH. LOUD BOOM UNDERNEATH OF DRIVER SEAT. VEHICLE STARTS TO MAKE NOISE LIKE YOUR EXHAUST SYSTEM FAILED. IT ALSO SHAKES WHEN GOING FROM 0 TO 40 MPH THEN IT GOES AWAY. LUCKY IT DID NOT FALL APART. THIS RECALL MUST BE TAKEN SERIOUSLY BY FORD AND ENFORCE IT TO BE FIXED ASAP TO ALL VEHICLE WITH SUCH ISSUE.
NHTSA ODI #11343818
100,000 miles · Jul 14, 2020
Power Train
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT STATED WHILE AN EMPLOYEE WAS DRIVING 65 MPH, HE HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE, AND WAS UNABLE TO ACCELERATE ABOVE 15 MPH. THE DRIVER STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE DRIVER PULLED OVER AND PARKED THE VEHICLE ON THE SIDE OF THE ROAD. TH…
Read full complaint
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE CONTACT STATED WHILE AN EMPLOYEE WAS DRIVING 65 MPH, HE HEARD AN ABNORMAL NOISE COMING FROM THE VEHICLE, AND WAS UNABLE TO ACCELERATE ABOVE 15 MPH. THE DRIVER STATED THAT THERE WAS NO WARNING LIGHT ILLUMINATED. THE DRIVER PULLED OVER AND PARKED THE VEHICLE ON THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V767000 (POWER TRAIN). THE VEHICLE WAS NOT REPAIRED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
NHTSA ODI #11339310
160,000 miles · Nov 6, 2019
Power TrainCrashInjury
I OWN AND OPERATE A FORD F 250 TRANSIT VAN. TASK IS THE EXPEDITE OF AUTO & AEROSPACE PARTS THROUGH OUT THE COUNTRY. HAVE LEARNED THERE IS A SAFETY RECALL PER OEM AND NHTSA REGARDING DRIVETRAIN COUPLERS ( UNOINTS ). MY PARTICULAR VEHICLE HAS INCURRED DAMAGE AS RESULT OF COUPLER(S) FAILING. DAMAGE INCLUDING; NOT LIMITED TO DRIV…
Read full complaint
I OWN AND OPERATE A FORD F 250 TRANSIT VAN. TASK IS THE EXPEDITE OF AUTO & AEROSPACE PARTS THROUGH OUT THE COUNTRY. HAVE LEARNED THERE IS A SAFETY RECALL PER OEM AND NHTSA REGARDING DRIVETRAIN COUPLERS ( UNOINTS ). MY PARTICULAR VEHICLE HAS INCURRED DAMAGE AS RESULT OF COUPLER(S) FAILING. DAMAGE INCLUDING; NOT LIMITED TO DRIVESHAFT BECOMING DETACHED, SEVERANCE OF FUEL & BRAKE LINES, BREACH OF TRANSMISSION BELL HOUSING, OTHER. CATASTROPHIC FAILURE LEFT ME STRANDED IN DESERT FOR 2 DAYS, LOSS OF BUSINESS, LOSS OF INCOME, HEALTH RELATED ISSUES. THE RUBBER / POLYMER LIKE MATERIAL THESE COUPLERS ARE MADE OF ARE A SEVERE SAFETY HAZARD; ESPECIALLY IF VEHICLE IS OPERATED UNDER LOAD. FURTHERMORE, CUSTOMERS OPERATING THESE HAZARDS ARE NOT BEING NOTIFIED UNTIL NOVEMBER 11TH, 2019. SOMEONE NEEDS TO TAKE INITIATIVE BEFORE SOMEONE IS SERIOUSLY HURT. I WILL BE HAPPY TO FORWARD ANY ADDITIONAL INFORMATION/DOCUMENTS PERTAINING TO THIS MATTER. THANK YOU.
NHTSA ODI #11278542
191,000 miles · Oct 12, 2019
Power Train
I WAS AWARE OF THE RECALL 17S15 IN REFERENCE TO THE DRIVING SHAFT COUPLING, EVERY 30,000 MILES I CHECK THIS COUPLING AND EACH TIME THEY WOULD TELL ME THAT IT WAS CRACKED AND NEEDS TO BE CHANGE. AS SOON THE CALLED FIXED CAME OUT, IT WAS INSTALLED, BUT JUST LAST MONTH IT WAS CHECKED AGAIN AND THEY NOTICED THAT THE FAMOUS FIX ALSO …
Read full complaint
I WAS AWARE OF THE RECALL 17S15 IN REFERENCE TO THE DRIVING SHAFT COUPLING, EVERY 30,000 MILES I CHECK THIS COUPLING AND EACH TIME THEY WOULD TELL ME THAT IT WAS CRACKED AND NEEDS TO BE CHANGE. AS SOON THE CALLED FIXED CAME OUT, IT WAS INSTALLED, BUT JUST LAST MONTH IT WAS CHECKED AGAIN AND THEY NOTICED THAT THE FAMOUS FIX ALSO WAS CRACKED AND THIS TIME THEY (LEVITTOWN FORD LONG ISLAND)TOLD ME THAT IT WAS NOT COVERED UNDER RECALL AND I HAD TO PAY OVER $800.00 DOLLAR'S FOR A NEW FIX. THAT IS THE REASON I AM PUTTING THESE COMPLAINT. THE IS REALLY DANGEROUS
NHTSA ODI #11268070
85,500 miles · Sep 24, 2019
Power Train
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE VEHICLE WAS TAKEN TO PALLOTTA FORD LINCOLN (4199 CLEVELAND RD, WOOSTER, OH 44691, (330) 345-6600) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V408000 (POWER TRAIN); HOWEVER, THE REMEDY FAILED. WHILE DRIVING 25 MPH, THE VEHICLE VIBRATED VIOLENTLY. THE CONTACT INSPECTED THE VEHICLE AND…
Read full complaint
TL* THE CONTACT OWNS A 2016 FORD TRANSIT. THE VEHICLE WAS TAKEN TO PALLOTTA FORD LINCOLN (4199 CLEVELAND RD, WOOSTER, OH 44691, (330) 345-6600) TO BE REPAIRED PER NHTSA CAMPAIGN NUMBER: 17V408000 (POWER TRAIN); HOWEVER, THE REMEDY FAILED. WHILE DRIVING 25 MPH, THE VEHICLE VIBRATED VIOLENTLY. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FLEXIBLE COUPLING WAS FRACTURED. THE VEHICLE WAS NOT TAKEN BACK TO THE DEALER OR AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,500. *TT *AS
NHTSA ODI #11257646
93,370 miles · Sep 16, 2019
Power Train
THE VEHICLE HAS HAD THE FORD'S FINAL FIX FOR 17V408000. I PERIODICALLY INSPECT THE FLEXIBLE COUPLING AND DURING THE INSPECTION TODAY I OBSERVED A CRACK IN THE FLEXIBLE COUPLING. CRACKED FLEXIBLE COUPLINGS ARE A SAFETY ISSUE, AS EVIDENCED BY 17V408000. IT IS DISAPPOINTING THAT FORD IS UNABLE OR UNWILLING TO REPAIR THIS PROBLEM…
Read full complaint
THE VEHICLE HAS HAD THE FORD'S FINAL FIX FOR 17V408000. I PERIODICALLY INSPECT THE FLEXIBLE COUPLING AND DURING THE INSPECTION TODAY I OBSERVED A CRACK IN THE FLEXIBLE COUPLING. CRACKED FLEXIBLE COUPLINGS ARE A SAFETY ISSUE, AS EVIDENCED BY 17V408000. IT IS DISAPPOINTING THAT FORD IS UNABLE OR UNWILLING TO REPAIR THIS PROBLEM.
NHTSA ODI #11255518
106,000 miles · Jun 11, 2019
Power Train
DEALER PERFORMED RECALL 17S15 DRIVESHAFT ASSY THAT REPLACED THE REAR DRIVESHAFT COUPLING. AT THE TIME, THE FRONT DRIVESHAFT COUPLING WAS OBSERVED TO BE LOOSE. THE FRONT COUPLING WAS INSPECTED AND REASSEMBLED. LESS THAN 6000 MILES LATER THE FRONT DRIVESHAFT COUPLING (THE FIBROUS PART) DISINTEGRATED, THE SHAFT SEPARATED, CAUSIN…
Read full complaint
DEALER PERFORMED RECALL 17S15 DRIVESHAFT ASSY THAT REPLACED THE REAR DRIVESHAFT COUPLING. AT THE TIME, THE FRONT DRIVESHAFT COUPLING WAS OBSERVED TO BE LOOSE. THE FRONT COUPLING WAS INSPECTED AND REASSEMBLED. LESS THAN 6000 MILES LATER THE FRONT DRIVESHAFT COUPLING (THE FIBROUS PART) DISINTEGRATED, THE SHAFT SEPARATED, CAUSING DAMAGE TO THE BRAKE LINES. AT THE TIME THE VEHICLE WAS TRAVELING AT HIGHWAY SPEED AND DOWN HILL. THE DRIVER BROUGHT THE VEHICLE TO A STOP USING THE EMERGENCY BRAKE. PRIOR TO THE EVENT, THE DRIVER HAD NOTICED A LIGHT VIBRATION AND SOUND FOR ABOUT 50 MILES. THE VIBRATION SUDDENLY GOT WORSE JUST BEFORE THE EVENT.
NHTSA ODI #11219325
104,000 miles · Jun 4, 2019
Power Train
DRIVE TRAIN RUBBER COUPLING FAILURE 104000 MILES. PRIOR INSTALLATION OF COUPLING AT 70,000 MILES. THIS OCCURRENCE DAMAGED DRIVE SHAFT AND COUPLING AT REAR OF TRANSMISSION.
NHTSA ODI #11217775
Official recalls
21Sep 3, 2025
Ford Motor Company (Ford) is recalling certain 2015-2019 Lincoln MKC, Mustang, F-350 SD, F-250 SD, F-450 SD, 2015-2017 Lincoln Navigator, Expedition, 2015-2018 Edge, Transit Connect, 2016-2019 F-550 SD, Transit, 2017-2019 Econoline, and 2019 Ranger vehicles. The rearview camera may display a distorted, inverted, or blank image when the vehicle is in reverse.
Consequence & remedy
Consequence: A rearview camera that displays an inverted, distorted, or blank image can reduce the driver’s view behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the rearview camera as necessary, free of charge. Owner notification letters were mailed January 13, 2026. Ford owners will receive letters in phases, beginning January 2026 and June 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S89. This recall expands previous NHTSA recall number 25V270. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning September 8, 2025.
Aug 11, 2021
Ford Motor Company (Ford) is recalling certain 2015-2020 Transit vehicles. An incorrect driveshaft torsional damper service kit may have been installed, which can allow the damper shield to contact the parking brake cable, possibly resulting in parking brake failure.
Consequence & remedy
Consequence: Parking brake failure can result in unintended vehicle movement, increasing the risk of a crash.
Remedy: Dealers will replace the passenger side parking brake cable with a cable that provides sufficient clearance to the damper shield, free of charge. Interim owner notification letters were mailed on September 24, 2021. Owner notification letters were mailed on March 14, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S39.
Oct 25, 2019
Ford Motor Company (Ford) is recalling certain 2015-2017 Transit vehicles. This recall includes all full-size Transit vehicles previously recalled under 17V-408 except ones that received mechanical universal joint (u-joint) as a remedy and any 156" or 178" wheelbase Chassis Cab and Cut-Away bodies models. The flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash or injury.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling every 40,000 miles until the final remedy is available. The final remedy will consist of installation of a driveshaft front section equipped with a mechanical u-joint in place of the flexible coupling. These repairs will be made free of charge. Owner notification letters were mailed on April 1, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S38. Note: This recall supersedes recall number 17V-408.
Apr 29, 2019
New England Wheels (New England) is recalling certain 2014-2018 Ford Transit and 2014-2019 Ram Promaster 2500 and 3500 vehicles modified to be equipped with Freedman Go-ES Foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: New England has notified owners, directing them to contact Freedman for repairs to the foldaway seats, free of charge. The recall began May 27, 2019. Owners may contact Freedman customer service at 1-800-443-4540 or New England at 1-800-886-9247.
Apr 26, 2019
Fenton Mobility Products, Inc. (Fenton Mobility) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Fenton Mobility will notify owners, and a Fenton Mobility technician will repair the foldaway seats, free of charge. The recall is expected to begin in June 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014.
Apr 18, 2019
Mobility Transportation Services (MobilityTrans) is recalling certain 2014-2018 Ford Transit and Ram Promaster vehicles and 2014-2015 Ford Econoline vehicles modified to be equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: MobilityTrans will notify owners and Freedman Seating dealers will inspect and repair the foldaway seat, free of charge. The recall began May 19, 2019. Owners may contact Mobility Transportation Services customer service at 1-734-453-6452.
Apr 3, 2019
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain 2014-2017 Ford E-150 and Transit vans modified to be equipped with Ricon S-Series and K-Series wheel chair lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height.
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Mobility Specialists, working with Ricon, has notified the owners. Ricon will provide instructions and materials for replacing defective parts. Owners may contact Ricon customer service at 1-800-322-2884.
Mar 28, 2019
Cabot Coach Builders, Inc. DBA Royale Limousine (Royale) is recalling certain 2015-2018 Ford Transit-based mini-coaches equipped with Freedman GO-ES foldaway seats recalled under 18E-076. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Royale will notify owners and dealers will inspect and repair the seat. The recall began June 6, 2019. Owners may contact Royale customer service at 1-800-544-5587.
Mar 26, 2019
Vantage Mobility International, LLC (Vantage) is recalling certain 2015-2018 Ford Transit Van, Mercedes-Benz Sprinter, and 2007 Ford F-250-based shuttle vehicles equipped with Freedman GO-3S foldaway seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Vantage has notified owners, instructing them to contact Freedman for a repair kit, free of charge. The recall began March 25, 2019. Owners may contact Freedman customer service at 1-800-443-4540.
Mar 22, 2019
TransitWorks is recalling certain 2015-2018 Ford Transit, 2018 Ford Transit Connect, and 2016 Dodge Ram ProMaster vehicles modified to be equipped with Freedman Seating GO-ES seats. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: TransitWorks has notified owners and instructed them to contact Freedman seats for a repair kit. The recall began December 19, 2019. Owners may contact Freedman Seating customer service at 1-800-443-4540 or TransitWorks customer service at 1-855-337-9543.
Mar 18, 2019
Quality Van Sales, Inc. (Quality Van) is recalling certain 2015-2018 Ford Transit and E-350 vehicles modified to be equipped with Freedman GO-ES Foldaway Seat back cushions. The seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Quality Van will notify owners and dealers will inspect and repair the foldaway seat, free of charge. The recall began March 21, 2019. Owners may contact Quality Van customer service at 1-800-408-8550.
Mar 6, 2019
Fenton Mobility Products, Inc. (Fenton) is recalling certain 2015-2017 Ford Transit passenger vans modified to be equipped with Ricon S & K Titanium Wheelchair Lifts. The wheelchair lift positioning input cam may fail while the lift is in use, allowing the platform to travel higher than the vehicle's floor height. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 403, "Platform Lift Systems."
Consequence & remedy
Consequence: If the wheelchair lift platform stops above the vehicle floor, the wheelchair user can tip inwards toward the vehicle when exiting the lift, increasing their risk of injury.
Remedy: Fenton will notify owners, and a service technician will install Ricon Recall Parts Kit RI61396, free of charge. The recall began April 24, 2019. Owners may contact Fenton Mobility customer service at 1-716-484-7014. Fenton's number for this recall is RI61396.
Mar 1, 2019
Prime-Time Specialty Vehicles (Prime-Time) is recalling certain 2016-2018 Ram ProMaster and Ford Transit vehicles modified to be equipped with Freedman GO-ES Foldaway Seats. When the seat back cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop.
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: Prime-Time Specialty Vehicles has notified owners, and Freedman dealers have inspected and repaired the foldaway seats, free of charge. The recall began November 16, 2018. Owners may contact Freedman customer service at 1-800-443-4540 or Prime-Time Specialty Vehicles at 1-574-293-9191.
Feb 21, 2019
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence & remedy
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Additional source detail variants (2)
Power Train:driveline:driveshaft
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Power Train:driveline:universal Joint
XL Hybrids, Inc (XL) is recalling certain 2015-2018 Ford Transit vehicles modified to be equipped with XL's electric hybrid system. The cardan (universal) joint on the front driveshaft may fail, possibly causing the front driveshaft to detach.
Consequence: If the front driveshaft detaches from the vehicle, drive power will be lost, increasing the risk of a crash. The detached driveshaft may also create a road hazard, increasing the risk of a crash for following traffic.
Remedy: XL will notify owners, and dealers will replace the front driveshaft with an updated one, free of charge. The recall began April 15, 2019. Owners may contact XL Hybrid's customer service at 1-833-953-5338.
Nov 6, 2018
National Van Builders, Inc. (National Van) is recalling certain 2015-2018 Ford Transit vehicles equipped with Freedman GO-ES Foldaway Seats, part numbers 43705, 45467, 48923, and 75719. When the back seat cushion is rotated from the stowed position to the upright position, the seat cushion may not remain locked into place when under load, such as in a crash or a sudden stop. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 207, "Seating Systems."
Consequence & remedy
Consequence: In the event of a crash, if the seat back moves, the seat occupant has an increased risk of injury.
Remedy: National Van will notify owners, and dealers will inspect and repair the foldaway seat, free of charge. The recall began November 26, 2018. Owners may contact National Van customer service at 1-508-222-2272.
Apr 30, 2018
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Note: This is an expansion of recall 17V-668 (Ford recall 17S34). Ford's number for this recall expansion is 17S34-S1.
Oct 23, 2017
Ford Motor Company (Ford) is recalling certain 2015-2017 Ford Transit vehicles, equipped with a trailer tow module. Water can enter the tow modules and corrode the wiring causing issues such as rapidly flashing turn signals, loss of instrument panel display, an electrical short and possibly the deployment of seatbelt pretensioner.
Consequence & remedy
Consequence: An electrical short can increase the risk of a fire. Turn signal, instrument cluster or seatbelt pretensioner problems can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will add a drainage hole in the driver's door stepwell and incorporate a fuse into the vehicle's wiring harness, free of charge. The recall began on February 9, 2018. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S34.
Jun 26, 2017
Ford Motor Company (Ford) is recalling all 2015-2017 Transit vehicles except 156" and 178" wheelbase Chassis Cab and Cut-Away bodies. In the affected vehicles, the flexible coupling connecting the transmission to the driveshaft may prematurely fail.
Consequence & remedy
Consequence: If the coupling fails, the vehicle will not be able to move under its own power and the disconnected driveshaft may impact and damage the brake and fuel lines. Additionally, the separated driveshaft may allow the vehicle to roll if the vehicle is exited when the transmission is in 'Park' but the parking brake is not applied. These scenarios may increase the risk of a crash.
Remedy: Ford will notify owners, and as an interim repair, dealers will replace the flexible coupling on any vehicle with more than 30,000 miles. A final remedy repair of a redesigned flexible coupling or a revised driveshaft equipped with a universal joint is being developed and is expected in early 2018. These repairs will be made free of charge. Interim notifications informing owners of the safety risk were mailed July 21, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S15.
Aug 24, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence & remedy
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Additional source detail variants (2)
Fuel System, Diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Engine And Engine Cooling:engine:diesel
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured July 15, 2015, to April 14, 2016 and equipped with a 3.2L diesel engine. A fuel injector or the fuel volume control valve may clog due to metallic debris within the fuel system.
Consequence: If debris clogs the fuel system, the engine may stall, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the fuel injection pump and associated parts and, if necessary, will replace the fuel filter and flush the fuel system, free of charge. The recall began on October 14, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S32.
Apr 4, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured March 12, 2014, to March 18, 2016. In the affected vehicles, the side curtain air bag may not deploy with the proper trajectory due to being folded and packaged incorrectly.
Consequence & remedy
Consequence: A side curtain air bag that does not deploy as intended may increase the risk of occupant injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and re-orient the side curtain air bag assembly, as necessary, free of charge. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S13.
Feb 25, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Transit vehicles manufactured February 13, 2014, to January 13, 2016 and equipped with rear passenger seats. The rear seat belt buckles may be damaged if a heavy object is placed on, or impacts, the top of the buckle. The damage may prevent the buckle from latching or from remaining latched.
Consequence & remedy
Consequence: An unlatched seat belt increases the risk of injury to the occupant in the event of a crash.
Remedy: Ford will notify owners, and dealers will modify or replace the seat belt buckles, depending on their location in the vehicle, free of charge. The recall began May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration