CAR HAS APPARENTLY HAD A RECALL ON THE PLASTIC INTAKE MANIFOLD FOR 7 YEARS. I HAVE OWNED THE CAR FOR OVER 2 YEARS, BUT HAVE NEVER RECEIVED ANY INFORMATION ON THIS DEFECT. WHILE DRIVING THE CARE APX. 60 MILES FROM MY HOME, MY DAUGHTER AND I WERE LEFT STRANDED WHEN THE INTAKE MANIFOLD STARTED FOUNTAINING WATER AND ANTIFREEZE ALL…
Read full complaint
CAR HAS APPARENTLY HAD A RECALL ON THE PLASTIC INTAKE MANIFOLD FOR 7 YEARS. I HAVE OWNED THE CAR FOR OVER 2 YEARS, BUT HAVE NEVER RECEIVED ANY INFORMATION ON THIS DEFECT. WHILE DRIVING THE CARE APX. 60 MILES FROM MY HOME, MY DAUGHTER AND I WERE LEFT STRANDED WHEN THE INTAKE MANIFOLD STARTED FOUNTAINING WATER AND ANTIFREEZE ALL OVER MY ENGINE. THE CRACK IS BIG ENOUGH THAT NO LIQUID WOULD STAY IN THE CAR, AND I COULD NOT BABY IT HOME. IT TOOK AN ENTIRE DAY STRANDED IN A STRANGE CITY TO FIND SOMEONE WHO WOULD HAUL THE CAR ALL THE WAY TO MY HOME. FORD MOTOR COMPANY WILL NOT HONOR RECALL BECAUSE IT EXPIRED 4 MONTHS PRIOR TO INCIDENT.*AK
NHTSA ODI #10067851
66,421 miles · Jan 15, 2004
Unknown Or Other
INTAKE MANIFOLD IS CRACKED AND LEAKING ENGINE COOLANT. I HAVE NOT HAD THE VEHICLE REPAIRED DUE TO THE COST. I SEARCHED THE INTERNET FOR RECALLS ON THIS AND FOUND THE TSB# 97M91. I CALLED FORD AND SPOKE WITH PHILOMENA, ID #3157 AND WAS TOLD THIS WAS AN EXTENDED WARRANTY AND THAT THEY HAD NOTIFIED ME IN WRITING IN FEBRUARY 98. …
Read full complaint
INTAKE MANIFOLD IS CRACKED AND LEAKING ENGINE COOLANT. I HAVE NOT HAD THE VEHICLE REPAIRED DUE TO THE COST. I SEARCHED THE INTERNET FOR RECALLS ON THIS AND FOUND THE TSB# 97M91. I CALLED FORD AND SPOKE WITH PHILOMENA, ID #3157 AND WAS TOLD THIS WAS AN EXTENDED WARRANTY AND THAT THEY HAD NOTIFIED ME IN WRITING IN FEBRUARY 98. FOUND THE LETTER ON THE INTERNET IN A PDF FILE DATED MAY 1998. SO, ACCORDING TO FORD, THEY NOTIFIED ME A FEW MONTHS BEFORE THEY WERE NOTIFIED????? I NEVER RECEIVED ANY RECALL NOTICE OR ANY INFORMATION ON THIS. I'M SURE IF I WOULD HAVE, I WOULD HAVE TAKEN IT TO THE DEALERSHIP TO GET IT CORRECTED (WHO WOULDN'T?). MY WARRANTY ON THIS ENDING FEB. 17, 2003==WAS TOLD I WAS 6 MONTHS TOO LATE TO GET IT COVERED UNDER WARRANTY. IS THERE SOMETHING I CAN DO ABOUT THIS - OR AM I OUT OF $675.80?
NHTSA ODI #10070546
Mileage unknown · May 4, 2001
Engine And Engine CoolingUnknown Or Other
ENGINE CHECK LIGHT WAS ILLUMINATING ON DASHBOARD. CONTACTED DEALER, DEALER HAS DETERMINED THAT HEAD GASKET WAS LEAKING FLUIDS ONTO OXYGEN SENSOR, CAUSING ENGINE CHECK LIGHT TO ILLUMINATE. ALSO, NOTE HEAD GASKET NEEDED TO BE REPLACED. *AK
NHTSA ODI #887444
Mileage unknown · Apr 7, 2000
Engine And Engine CoolingUnknown Or OtherVehicle Speed Control
ENGINE CHECK LIGHT ON, DEALER REPLACED MASS AIR FLOW SENSOR. RETURNED TO DEALER 4 TIMES FOR GAS MILEAGE DOWN 10-20%, LOW IDLE AND STALLS, POOR DRIVEABILITY - FORD AND DEALER STATE CAR IS NORMAL - ALL DATA FROM PURCHASE DATE AVAILABLE - CLEARLY SHOWS NEGATIVE CHANGE AT TIME OF PART REPLACEMENT
NHTSA ODI #711190
Mileage unknown · Jun 10, 1999
Engine And Engine CoolingUnknown Or Other
OIL GAUGE PRESSURE VARIES, BROUGHT IN TWICE DURING WARRANTY, THEY REPLACED ENGINE DUE TO SLAPPING ROD, GOT CAR BACK OIL PRESSURE ON GAUGE STILL VARIES HIGH & LOW. *AK
NHTSA ODI #707402
Mileage unknown · Aug 27, 1998
Fuel System, GasolineUnknown Or Other
DRIVING VEHICLE WHEN IT STARTED LEAKING COOLANT. NO OVERHEATING. VEHICLE TOWED HOME. NEXT DAY AT DEALER & INTAKE MANIFOLD REPAIRED DUE TO A CRACK. VEHICLE STARTED TO GET WORSE. VEHICLE DIED. ENGINE CHECK LIGHT CAME ON. MOISTURE ON SPARK PLUGS & IGNITION WIRES. *AK
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
Consequence & remedy
Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1996 Ford Thunderbird Problems, Complaints & Recalls | Skip That Year
Illustration