IllustrationWHILE DRIVING 5 MPH FRONT DRIVER SIDE WHEEL CAME COMPLETELY OFF. *AK CONSUMER STATED IT WAS THE FRONT BALL JOINT THAT CAUSED THAT WHEEL TO COME OFF. *YH
1996 Ford Thunderbird
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Thunderbird years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 36 of 233 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 46 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports4 fire reports9 injury reports
Suspension complaints
9 reportsTHE FRONT SPRINGS ARE DEFECTIVE AND BREAK THUS COLLASPSING THE STRUTS AND MAKING THE VEHICLE HARD TO HANDLE. THE PLASTIC INTAKE MANIFILD COOLANT CHANNEL WALLS ARE TO THIN AND TEND TO BLOW-OUT. FINALLY, THE BACKLIT REAR REFLECTOR TENDS TO BURNOUT TO OFTER FOR A INTEGRATED PART. THE VEHICLE WILL NOT PASS INSPECTION BECAUSE THE …
Read full complaint
THE FRONT SPRINGS ARE DEFECTIVE AND BREAK THUS COLLASPSING THE STRUTS AND MAKING THE VEHICLE HARD TO HANDLE. THE PLASTIC INTAKE MANIFILD COOLANT CHANNEL WALLS ARE TO THIN AND TEND TO BLOW-OUT. FINALLY, THE BACKLIT REAR REFLECTOR TENDS TO BURNOUT TO OFTER FOR A INTEGRATED PART. THE VEHICLE WILL NOT PASS INSPECTION BECAUSE THE REFLECTOR IS AN INTEGRATED PART OF THE TAIL LIGHT ASSEMBLY. THE COST OF REPLACEMENT IS PROHIBITIVE SO THE REFLCTOR REMAINS BURNED OUT ON MANY OF THE OTHER T-BIRDS I SEE ON THE ROAD CAUSING A PROBLEM WITH THE VEHICLE'S VISIBILITY. THE ILUMENATOR IN THE REFLECTOR SHOULD BE SERVICABLE. *AK
4/97 VEHICLE PULLS TO RIGHT. DEALER ALIGNED FRONT END. 1/98 VEHICLE PULLS TO RIGHT AND VIBRATES AT HIGHWAY SPEED. DEALER SAYS IT IS A TIRE PROBLEM, ONE TIRE REPLACED. 5/99 VEHICLE STILL PULLS TO RIGHT AND VIBRATES AT HIGHWAY SPEED AND WHILE BRAKING. FRONT ROTORS WARPED AND PADS WORN. ROTORS TURNED AND PADS REPLACED BY GOODYEAR S…
Read full complaint
4/97 VEHICLE PULLS TO RIGHT. DEALER ALIGNED FRONT END. 1/98 VEHICLE PULLS TO RIGHT AND VIBRATES AT HIGHWAY SPEED. DEALER SAYS IT IS A TIRE PROBLEM, ONE TIRE REPLACED. 5/99 VEHICLE STILL PULLS TO RIGHT AND VIBRATES AT HIGHWAY SPEED AND WHILE BRAKING. FRONT ROTORS WARPED AND PADS WORN. ROTORS TURNED AND PADS REPLACED BY GOODYEAR SERVICE CENTER. 9/99 VEHICLE PULLING TO RIGHT AND VIBRATING AT SPEED AND DURING BRAKING. FRONT ROTORS WARPED AND PADS WORN AGAIN. DEALER CLAIMS IT IS OWNERS DRIVING STYLE. ROTORS TURNED AND PADS REPLACED AT OWNERS EXPENSE. 10/00 VEHICLE PULLS TO RIGHT AND VIBRATES. ROTORS FEEL WARPED AGAIN. APPOINTMENT WITH DEALER TO REPAIR. 10/16 TRANSMISSION HAS A SHUDDER IN 3RD AND 4TH GEAR DURING LIGHT TO MODERATE ACCELERATION. DEALER SAYS PROBABLY TORQUE CONVERTER. UNKNOWN AT THIS TIME IF THIS WILL BE CONSIDERED AN WARRANTY ITEM OR ROUTINE MAINTENANCE.
WHILE DRIVING AT SPEEDS BETWEEN 65- 70 MPH VEHICLE WILL SHAKE AND VIBRATE . DRIVER CAN FEEL IT IN STEERING AND ACCELERATOR PEDAL. DEALER CANNOT FIX DEFECT, AND CLAIMS THAT IS HOW VEHICLE IS DESIGNED. *AK
WHILE DRIVING 50 MPH OR GREATER THE STEERING WHEEL VIBRATES AND SHAKES VIGOROUSLY, CAUSING THE VEHICLE TO SWAY LEFT TO RIGHT. BEEN IN THE DEALER 8 TIMES. DEALER REPLACED 4 SETS OF TIRES/ROTORS. PROBLEM STILL OCCURRING. DEALER CANNOT DETERMINE PROBLEM. *AK
WHEN DRIVING THE VEHICLE AT HIGHWAY SPEED THE STEERING WHEEL VIBRATES, AND IT ALSO VIBRATES AT LOW SPEED WHEN BRAKING. ON WARM DAYS, WHEN STARTING AND STOPPING IN TRAFFIC ONE CAN SMELL RAW GASOLINE INSIDE AND AROUND THE OUTSIDE OF THE CAR, BUT THERE ARE NO LEAKS IN THE VEHICLE. *AK
WHILE GOING 40MPH, WOULD EXPERIENCE A VIBRATION IN STEERING WHEEL. HAD TAKE VEHICLE TO DEALER & INFORMED THAT ITS A PROBLEM THAT HAPPENS IN THUNDERBIRDS SOMETIMES. CANNOT LOCATE PROBLEM OF VIBRATION. *AK
VEHICLE HAS CONSTANT DRIFT/PULL TO THE RIGHT, CREATING TIRES THAT BECOME FEATHERES, THUS MAKING VEHICLE DANGEROUS TO DRIVE. *AK
WHILE DRIVING VEHICLE PULLS TO THE RIGHT, ALSO WARPED FRONT BRAKE ROTORS, CAUSING BRAKES TO VIBRATE AND AIR CONDITIONING MALFUNCTIONED. *AK
Official recalls
296V070000 · Latches/locks/linkages:doors:latch
Apr 22, 1996
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
96V007000 · Equipment:appliance:air Conditioner
Jan 16, 1996
UNDER CERTAIN CONDITIONS, THE CLIMATE CONTROL BLOWER DOES NOT OPERATE AS INTENDED. THE BLOWER COULD (1) STICK ON "HIGH;" (2) OPERATE ERRATICALLY WITH BLOWER OUTPUT VARYING BETWEEN NO BLOWER AND MAXIMUM BLOWER; OR (3) NOT OPERATE AT ALL DUE TO MALFUNCTION OF THE TEMPERATURE CONTROL MODULE.
Consequence & remedy
Consequence: BLOWER MALFUNCTIONS LIMITING OR STOPPING OUTPUT CAN ADVERSELY AFFECT WINDSHIELD DEFROSTING AND DEFOGGING PERFORMANCE INCREASING THE POTENTIAL FOR A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE SEMI-AUTOMATIC TEMPERATURE CONTROL MODULES WITH MODULES CONTAINING REVISED SOFTWARE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.