1995 Ford Thunderbird

ON TWO OCCASIONS IN HEAVY TRAFFIC VEHICLE SUDDENLY LURCHED FORWARD. DEALER WAS NOTIFIED. *AK ENGINE ROARS, CONSUMER WOULD TAP THE ACCELERATOR AND WOULD GO TO THE FLOOR, FEELS AS IF VEHICLE IS PUT IN NEUTRAL. DEALER REPLACED TRANSMISSION GEAR SHIFT SWITCH ASSEMBLY. CHECK ENGINE LIGHT CAME ON INTERMITTENTLY. DEALER REPLACE 2 O2 SENSORS AND MAF SENSOR. VEHICLE PULLS TO RIGHT. WHEEL ALIGNMENT PERFORMED. STEERING WHEEL SHIMMY WHEN APPLYING BRAKES. PRFORMED FRONT DISC/ REAR DRUM BRAKE SERVICE. REPLACED FRONT ROTORS AFTER BRAKE JOB DUE TO PULSATION. STEERING COLUMN HAD TO BE REPLACED. AT TIMES, VEHICLE WILL NOT SHUTT OFF. RIGHT DOOR LOCK INOPERATIVE. DEALER CAN NOT DUPLICATE. CUSTOMER STATES FLUID LEAK AT REAR END. RIGHT AXLE SEAL REPLACED. PASSENGER HEAD REST RATTLES OVER BUMPS. DEALER COULD NOT DUPLICATE. CONSUMER STATES NOISE FROM SEAT WHEN NO ONE IS SITTING THERE, DEALER STATES THIS IS NORMAL. SEAT TRACK COVERS MISING ONE LAYING IN THE REAR FLOOR. SEAT TRACK COVER REINSTALLED. CONSUMER STATS THERE IS A PINGING NOISE UPON ACCELERATION. DEALER SUGGESTED HIGHER FUEL OCTANE. CUSTOMER STATES BRAKE PEDAL SEEMS LOW. BRAKES OK. FRONT END SHIMMIES AT 50 TO 60 MPH. 4 TIRES BALANCED. DOME LIGHT WILL NOT COME ON WHEN DRIVER OUTSIDE DOOR HANDLE PULLED UP. TEMPERATURE AND SPEEDOMOTER LIGHT BURNED WAS INOPERATIVE. DEALER REPLACED INSTRUMENT CLUSTER BULBS. COOLANT LEAK UNDER CAR AND WARNING LIGHT IS ON. DEALER FOUND NO LEAKS AND COOLANT LEVEL LOW. CONSUMER STATES MOTOR WILL ROAR AND SHIFT INTO GEAR. DRIVER SIDE HEADLAMP BURNT OUT. HEADLAMP REPLACED. TRANSMISSION SLIPS WHEN NOT IN OVERDRIVE. DEALER REPLACED TRANSMISSION OIL PAN AND GASKET. *TT

AFTER STARTING MY CAR AT 5:30 AM TO PROCEED TO WORK THE KEY FELT A BIT STRANGE AFTER I STARTED THE CAR. UPON DRIVING THE CAR ON THE FREEWAY I DREW MY ATTENTION BACK TO THE KEY AND FELT THAT IT WAS SPINNING FREELY, AND COULD BE REMOVED, AS THE ENGINE CONTINUED TO RUN, ( THE START POSITION APPEARED TO WORK OK). I HAD NO WAY I COULD TURN THE CAR OFF. A TECHNITIAN ON THE 800 PHONE LINE TO FORD SUGGESTED I HIT THE FUEL SHUT OFF IN THE TRUNK ONCE I REACHED MY LOCATION. THIS WOULD SIMULATE A CRASH AND SHUT OFF THE FUEL. I ELECTED TO PULL A LARGE FUSE AND DETACH THE BATTERY. THE CAR WAS SUBSEQUENTLY REPAIRED AT MY EXPENSE ($283) TO REPLACE AN $11 ACTUATOR PIN IN THE STEERING COLUMN THAT INTERFACED WITH THE IGNITION SWITCH. I T WAS PROBABLY WRONG ON MY PART AS I LOOK BACK AT CONTINUING TO DRIVE THE CAR BECAUSE THE BROKEN PIN COULD HAVE POSSIBLY LODGED ITSELF AND PREVENTED ME FROM STEERING THE CAR. MY CONCERN NOW IS ONE OF SAFETY AND WHAT A PERSON NOT TOO FAMILAR WITH AUTOMOBLIES MIGHT DO IN THIS SITUATION. FORD SHOULD CONSIDER THE DESIGN AND MAKE CORRECTIONS TO PREVENT THIS SORT OF OCCURRENCE.*AK

WHILE DRIVING ABOUT 40 MPH, SMOKE STARTED COMING FROM REAR OF VEHICLE, DEALER TOLD CONSUMER THAT SMOKE WAS OFF DUE TO A BLOWN HEAD GASKET. *AK CONSUMER STATED THAT TO START THE VEHICLE, HE HAD TO TRY COUPLE OF TIMES AND WHILE DRIVING 65 MPH HE NOTICED ENGINE OVERHEATING POINTER MOVING TOWARDS HIGHER THAN NORMAL AND LOWERED HIS SPEED TO 40 MPH AND STOPPED THE VEHICLE, WHILE BACKING UP, THE ENGINE STARTED SHAKING, WHEN PUTTING IN DRIVE IT RAN NORMALLY THEN NOTICED ABNORMAL SMOKE COMING OUT OF MUFFLER, THE SERVICE ENGINEER TOLD HIM THAT HEAD CYLINDER GASKET WAS BLOWN, AND COOLANT WAS LEAKING INTO ENGINE AND TO THE MUFFLER. *YD