IllustrationMY WIFE'S 2003 FORD TAURUS WITH 58,000 MILES HAD THE TORQUE CONVERTER SPLINE GEAR,THAT WAS NOT HEAT TREATED PROPERLY. FAIL.JUST OUT OF NOWHERE.IT HAPPENED AT AN INTERSECTION.NO FORWARD OR REVERSE. THIS COULD HAVE BEEN DEADLY.THIS IS A VERY COMMON PROBLEM, AND WE FEEL A RECALL IS IN ORDER.THANK YOU. *TR
2003 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 2003 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
740–25K
14925–50K
25250–75K
25375–100K
261100–150K
70150K+
1,059 reports with mileage · 164 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 316 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 313 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 191 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
56 crash reports12 fire reports45 injury reports
Power Train complaints
316 reportsTL*THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE DASHBOARD.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAM SENSOR WAS REPLACED. APPROXIMATELY 5 MONTHS LATER THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHERE THE CAM SENSOR…
Read full complaint
TL*THE CONTACT OWNS A 2003 FORD TAURUS. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE DASHBOARD.THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CAM SENSOR WAS REPLACED. APPROXIMATELY 5 MONTHS LATER THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO AN INDEPENDENT MECHANIC WHERE THE CAM SENSOR WAS AGAIN REPLACED. THE FAILURE RECURRED AGAIN AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CAM SENSOR WAS RESET. THE FAILURE HAS NOT RECURRED. APPROXIMATELY 1 YEAR LATER WHILE DRIVING AT APPROXIMATELY 20 MPH THE FRONT PASSENGER SIDE TIRE BLEW OUT. UPON EXAMINING THE VEHICLE THE CONTACT NOTICED THE COIL SPRING WAS BROKEN AND PIERCED THE TIRE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE FRONT PASSENGER SIDE COIL SPRING WAS REPLACED. THE CONTACT ALSO STATED THAT APPROXIMATELY 2 MONTHS LATER WHILE ATTEMPTING TO OPERATE THE VEHICLE IT WOULD NOT SHIFT INTO GEAR AND WOULD NOT MOVE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE IT WAS IN THE PROCESS OF BEING DIAGNOSED. THE FAILURE MILEAGE WAS 77,000 AND THE CURRENT MILEAGE WAS 90,600.
2003 FORD TAURUS. CAR WAS RUNNING OKAY. I WAS STOPPED AT A RED LIGHT AND WHEN THE LIGHT CHANGED. I PUT MY FOOT ON THE GAS PEDAL AND THE CAR WOULD NOT MOVE. A FEW DAYS EARLIER DURING A HEAVY RAINFALL I NOTICED THE RPMS METER GO UP WHILE THE SPEED DIPPED. I PANICKED BUT HE CAR MADE IT HOME AND DROVE FINE FOR SEVERAL DAYS THEREAFT…
Read full complaint
2003 FORD TAURUS. CAR WAS RUNNING OKAY. I WAS STOPPED AT A RED LIGHT AND WHEN THE LIGHT CHANGED. I PUT MY FOOT ON THE GAS PEDAL AND THE CAR WOULD NOT MOVE. A FEW DAYS EARLIER DURING A HEAVY RAINFALL I NOTICED THE RPMS METER GO UP WHILE THE SPEED DIPPED. I PANICKED BUT HE CAR MADE IT HOME AND DROVE FINE FOR SEVERAL DAYS THEREAFTER. I WAS TOLD THE TRANSMISSION WAS SHOT. *TR
I WAS DRIVING MY 2003 FORD TAURUS DOWN A STATE HIGHWAY, IN ARKANSAS, AND THE TRANSMISSION WENT OUT WHILE DRIVING IT. I WENT TO PASS A VEHICLE, AND INSTEAD OF THE VEHICLE KICKING INTO PASSING GEAR, IT WAS AS IF THE VEHICLE WENT INTO NEUTRAL INSTEAD. THE ENGINE JUST REVVED UP AND THE VEHICLE STARTED TO SLOW. I BARELY MADE IT TO…
Read full complaint
I WAS DRIVING MY 2003 FORD TAURUS DOWN A STATE HIGHWAY, IN ARKANSAS, AND THE TRANSMISSION WENT OUT WHILE DRIVING IT. I WENT TO PASS A VEHICLE, AND INSTEAD OF THE VEHICLE KICKING INTO PASSING GEAR, IT WAS AS IF THE VEHICLE WENT INTO NEUTRAL INSTEAD. THE ENGINE JUST REVVED UP AND THE VEHICLE STARTED TO SLOW. I BARELY MADE IT TO THE SIDE OF THE ROAD, WITHOUT BEING STRUCK BY ANOTHER VEHICLE. THE VEHICLE GAVE NO INDICATION OF ANY TRANSMISSION PROBLEMS AND HAS APPROXIMATELY 132,000 MILES ON IT. THERE WERE NO SHIFTING ISSUES, SOUNDS, OR WARNING LIGHTS. I HAVE READ WHERE MANY OTHER FORD TAURUS OWNERS HAVE EXPERIENCED NEARLY THE SAME ISSUE. THIS COULD HAVE BEEN MUCH WORSE THAN IT WAS, SINCE I WAS IN THE MIDDLE OF A MAIN HIGHWAY AND TRAVELING AT APPROXIMATELY 55 MILES PER HOUR AT THE TIME OF THE INCIDENT. THE VEHICLE WILL NOT SHIFT INTO ANY FORWARD GEAR OR REVERSE. *TR
TRANSMISSION FAILURE. WHILE DRIVING ON AN EXPRESSWAY, I FELT THE GEARS SLIP AS THE TRANSMISSION WAS AUTOMATICALLY SHIFTING FROM DRIVE TO OVERDRIVE. AFTER THE GEAR CHANGE, I ATTEMPTED TO ACCELERATE, HOWEVER, POWER DID NOT TRANSFER FROM THE ENGINE TO THE WHEELS. I COASTED TO A STOP. THE TRANSMISSION WAS REBUILT AT MY OWN EXPEN…
Read full complaint
TRANSMISSION FAILURE. WHILE DRIVING ON AN EXPRESSWAY, I FELT THE GEARS SLIP AS THE TRANSMISSION WAS AUTOMATICALLY SHIFTING FROM DRIVE TO OVERDRIVE. AFTER THE GEAR CHANGE, I ATTEMPTED TO ACCELERATE, HOWEVER, POWER DID NOT TRANSFER FROM THE ENGINE TO THE WHEELS. I COASTED TO A STOP. THE TRANSMISSION WAS REBUILT AT MY OWN EXPENSE. *TR
2003 FORD TAURUS V6 3.0 SE THE TRANSMISSION FAILED WITHOUT WARNING ON A BUSY SAN FRANCISCO STREET WHILE MAKING A TURN AND ACCELERATING SLIGHTLY OUT OF THE TURN. HAD TO PUSH THE CAR OUT OF THE STREET AT SOME PERIL TO MYSELF. I HAVE INVESTIGATED AND THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT TRANSMISSION FAILURES ON THE 2003 TAURU…
Read full complaint
2003 FORD TAURUS V6 3.0 SE THE TRANSMISSION FAILED WITHOUT WARNING ON A BUSY SAN FRANCISCO STREET WHILE MAKING A TURN AND ACCELERATING SLIGHTLY OUT OF THE TURN. HAD TO PUSH THE CAR OUT OF THE STREET AT SOME PERIL TO MYSELF. I HAVE INVESTIGATED AND THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT TRANSMISSION FAILURES ON THE 2003 TAURUS. TRANSMISSION HAS TO BE REPLACED WITH A REBUILD. THE COST IS $1300.00 PLUS TOWING FEE. *TR
2003 FORD TAURUS, 120,000 MILES NO WARNING CAR JUST STOPPED GOING MOVING, TRANSMISSION SEEMS TO NOT BE WORKING, GOES IN EVERY GEAR JUST NO MOVEMENT, HAVE HAD NOTHING BUT TROUBLE WITH THIS CAR SINCE I BOUGHT IT 3 YRS AGO. *TR
I WAS COMING HOME FROM WORK AND HAD JUST STARTED UP AN INCLINE AFTER STOPPING AT A STOPLIGHT AT ONE OF THE BUSIEST INTERSECTIONS IN ST.LOUIS (HWY 64 & LINDBERGH). AS I TRIED TO ACCELERATE, I HEARD AN AWFUL NOISE AND REALIZED I DIDN'T HAVE ANY POWER. THERE WERE NO WARNING SIGNS....JUST GONE! LUCKILY, I WAS ABLE TO IMMEDIATELY…
Read full complaint
I WAS COMING HOME FROM WORK AND HAD JUST STARTED UP AN INCLINE AFTER STOPPING AT A STOPLIGHT AT ONE OF THE BUSIEST INTERSECTIONS IN ST.LOUIS (HWY 64 & LINDBERGH). AS I TRIED TO ACCELERATE, I HEARD AN AWFUL NOISE AND REALIZED I DIDN'T HAVE ANY POWER. THERE WERE NO WARNING SIGNS....JUST GONE! LUCKILY, I WAS ABLE TO IMMEDIATELY PULL OFF/COAST INTO A NEARBY MALL'S PARKING LOT (PLAZA FRONTENAC). WHEN I GOT TO A STOP, I PUT THE CAR IN PARK, THEN PROCEEDED TO TRY ALL THE GEARS ON THE GEARSHIFT. NO DIFFERENCE BETWEEN THEM....THEY ALL SEEMED LIKE NEUTRAL. I KEPT THE CAR RUNNING, CHECKED THE TRANSMISSION FLUID, AND NOTICED SOME GREY/BLACK IN WITH THE PINK (JUST ON THE EDGES). ONCE MY HUSBAND GOT THERE, HE VERIFIED HE THOUGHT THE GREY WAS FROM METAL SHAVINGS FROM THE TRANSMISSION. I HAD THIS HAPPEN TO MY 1997 DODGE AVENGER (TRANSMISSION GAVE OUT AT 37K ON BUSY HIGHWAY AT RUSH HOUR), SO I KNEW THE SIGNS. AFTER HAVING AAA TOW MY CAR TO A TRANSMISSION REPAIR SHOP, WE WAITED FOR THE VERDICT. IT WILL BE AT LEAST $1600 TO REBUILD THE TRANSMISSION. THIS WILL INCLUDE THE TORQUE CONVERTER. THE SHOP SAYS THEY WILL ALSO REPLACE SOME OF THE OTHER WEAK PARTS THE TAURUS IS KNOWN FOR IN THEIR TRANSMISSIONS. THE CAR IS A 2003 FORD TAURUS SES WITH 115K ON IT. I'VE HAD IT SINCE BRAND NEW AND CAN'T BELIEVE ALL OF THE COMPLAINTS ONLINE, ESPECIALLY IN REGARDS TO THE 2003 TAURUS. WHY HASN'T THERE BEEN A RECALL?!? I DON'T CURRENTLY HAVE THE CAR OR MY INSURANCE INFO.ON ME TO SUPPLY THE VIN NUMBER.... *TR
MY HUSBAND WAS DRIVING MY 2003 FORD TAURUS TO THE CORNER STORE AND THE TRANSMISSION FAILED IN THE MIDDLE OF THE ROAD. THERE WERE NO WARNING LIGHTS OR SIGNS LEADING UP TO THE FAILURE. LUCKILY MY HUSBAND WAS ABLE TO GET TO THE END OF OUR QUARTER MILE DRIVEWAY WERE WE THEN PUSHED IT TO THE HOUSE. I AM VERY THANKFUL THIS DID NOT HAP…
Read full complaint
MY HUSBAND WAS DRIVING MY 2003 FORD TAURUS TO THE CORNER STORE AND THE TRANSMISSION FAILED IN THE MIDDLE OF THE ROAD. THERE WERE NO WARNING LIGHTS OR SIGNS LEADING UP TO THE FAILURE. LUCKILY MY HUSBAND WAS ABLE TO GET TO THE END OF OUR QUARTER MILE DRIVEWAY WERE WE THEN PUSHED IT TO THE HOUSE. I AM VERY THANKFUL THIS DID NOT HAPPEN TO MY THREE CHILDREN AND I WHEN WE WERE OUT SHOPPING EARLIER THAT DAY. THIS A POTENTIALLY DEADLY FAILURE THAT I HAVE FOUND MANY CASES OF ONLINE. *TR
1) EVENTS LEADING UP TO THE FAILURE, NONE. CAR HAD NO PROBLEMS, TRANSMISSION MADE NO NOISE, WAS NOT SLIPPING, ETC... CAR WAS WELL MAINTAINED. 2) THE FAILURE, HOW OFTEN IT OCCURS, THE CONSEQUENCES. THE TRANSMISSION FAILED ON THE CAR AT 107,000 MILES, NO WARNING, WAS ON THE FREEWAY COMING HOME FROM WORK, DEPRESSED THE GAS PEDA…
Read full complaint
1) EVENTS LEADING UP TO THE FAILURE, NONE. CAR HAD NO PROBLEMS, TRANSMISSION MADE NO NOISE, WAS NOT SLIPPING, ETC... CAR WAS WELL MAINTAINED. 2) THE FAILURE, HOW OFTEN IT OCCURS, THE CONSEQUENCES. THE TRANSMISSION FAILED ON THE CAR AT 107,000 MILES, NO WARNING, WAS ON THE FREEWAY COMING HOME FROM WORK, DEPRESSED THE GAS PEDAL TO PASS ANOTHER CAR AND THEN RPMS MAXED OUT. CAR DID NOTHING IN ANY GEARS. LUCKILY I WAS ABLE TO MERGE OVER 3 LANES AND ARRIVE SAFELY TO THE SHOULDER. HOWEVER, HAD I NOT HAD ENOUGH SPEED THIS MOST DEFINITELY COULD HAVE CAUSE AN ACCIDENT. 3) WHAT WAS DONE TO CORRECT THE FAILURE? THE TRANSMISSION NEEDED TO BE REPLACED. LUCKILY MY DAD, A FORMER MECHANIC, WAS ABLE TO PUT IN A USED (16,000 MILES) TRANSMISSION FOR ME. THIS COST ME ABOUT $700 DOLLARS. WHILE THIS TRANSMISSION IS STILL DOING FINE, CAR NOW HAS 135,000 MILES, THIS GIVES ME NO ASSURANCE AS THESE TRANSMISSIONS TEND TO GO WITHOUT WARNING AT LOW MILEAGE. *TR
Official recalls
304V105000 · Engine And Engine Cooling
Mar 2, 2004
ON CERTAIN VEHICLES, THE AIR FILTER PAPER IN THESE VEHICLES CAN SMOLDER OR BURN.
Consequence & remedy
Consequence: THIS CAN LEAD TO DAMAGE TO THE AIR INDUCTION SYSTEM ON THESE VEHICLES AND/OR AN UNDERHOOD FIRE.
Remedy: DEALERS WILL REPLACE THE AIR FILTER ELEMENT. OWNER NOTIFICATION BEGAN ON MARCH 10, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
04V106000 · Exterior Lighting:brake Lights:switch
Mar 2, 2004
CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence & remedy
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
03V087000 · Visibility:windshield
Mar 10, 2003
CERTAIN PASSENGER VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." THE WINDSHIELDS MAY POTENTIALLY EXHIBIT INCREASED WIND NOISE, WATER LEAKAGE, AND SQUEAKS AND RATTLES.
Consequence & remedy
Consequence: POTENTIAL LOSS OF WINDSHIELD RETENTION MAY ALSO REDUCE OCCUPANT PROTECTION IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE THESE WINDSHIELDS. OWNER NOTIFICATION BEGAN ON MARCH 31, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD/MERCURY AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4PE12033 · Speed Control Cable Damage
Opened Oct 24, 2012 · Closed Jun 26, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Additional source detail variants (3)
Vehicle Speed Control:cables
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
EA08018 · Front Suspension Coil Spring Fracture
Opened Aug 28, 2008 · Closed Jun 30, 2011
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
To date, ODI is aware of 2,401 non-duplicative complaints related to the alleged defect. In addition, ODI is aware of 1,411 subject vehicles with one or more warranty claims related to the alleged defect. In total, ODI is aware of 3,645 unique subject vehicles that have experienced one or more front suspension coil spring fractures. ODI is also aware of four minor crashes related to the alleged defect resulting in one minor injury.With greater than eight years of exposure, a large subject vehicle population and approximately 2,052 reported front tire punctures caused by fractured coil springs (at all speeds), there have been no reported severe crashes, deaths or injuries related to the alleged defect. The real world consequences of these defective coil springs have been a small number of minor control problems that resulted in minor damage; suggesting that the effect of the defect on vehicle control is minor.A safety-related defect has not been identified at this time and further use of agency resources does not appear to be warranted. Accordingly, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor this issue and will take further action if warranted by the circumstances. See the EA08-018 Engineering Analysis Closing Report for more details.
DP06005 · Engine Stalling Ffv
Opened Dec 4, 2006 · Closed Dec 28, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail; Fuel System, Gasoline:fuel Injection System:injectors; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:auxillary Tank; Fuel System, Gasoline:storage:auxillary Tank:selector Devices; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap; Fuel System, Gasoline:storage:tank Assembly:mounting; Fuel System, Other; Fuel System, Other:delivery; Fuel System, Other:delivery:fuel Pump; Fuel System, Other:delivery:hoses, Lines/piping, And Fittings; Fuel System, Other:fuel Injection System; Fuel System, Other:storage; Fuel System, Other:storage:fuel Gauge System; Fuel System, Other:storage:tank Assembly; Fuel System, Other:storage:tank Assembly:filling/charging; Fuel System, Other:storage:tank Assembly:mounting; Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Additional source detail variants (23)
Fuel System, Gasoline:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:fuel Injection System:injectors
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:auxillary Tank:selector Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Gasoline:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:fuel Pump
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:delivery:hoses, Lines/piping, And Fittings
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:fuel Injection System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:fuel Gauge System
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:filling/charging
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:mounting
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
Fuel System, Other:storage:tank Assembly:pressure Relief Devices
ON OCTOBER 11, 2006, PUBLIC CITIZEN PETITIONED ODI TO INVESTIGATE REPORTS OF ENGINE STALLS CAUSED BY E85 FUEL IN CERTAIN MODEL YEAR (MY) 2003 - 2005 FORD TAURUS FLEX-FUEL VEHICLES (FFV). ODI'S REVIEW OF THE PETITION AND OTHER AVAILABLE DATA FOUND A LOW STALL RATE ATTRIBUTABLE TO E-85 FUELING AND THAT THE MAIN CONCERNS,PROLONGED ENGINE START AND ROUGH IDLE DURING COLD ENGINE STARTUP AT WINTER TEMPERATURES, WERE RESOLVED BY AN ENGINE SOFTWARE UPDATE.TO ENSURE THAT ALL SUBJECT VEHICLES RECEIVE THIS UPDATE, FORD INITIATED A NOTIFICATION CAMPAIGN TO OFFER FREE ENGINE COMPUTER RECALIBRATION.BASED ON THIS INFORMATION, THIS DEFECT PETITION IS DENIED. THIS DENIAL SHOULD NOT BE CONSTRUED AS A FINDING THAT NO SAFETY DEFECT EXISTS.ODI RESERVES THE RIGHT TO RECONSIDER THIS ISSUE IF FUTURE DATA WARRANT.ADDITIONAL DETAILS CAN BE FOUND IN THE FEDERAL REGISTER NOTICE POSTED IN THE DP06-005 PUBLIC FILE.
RQ03008 · Brake Light Switch Failure
Opened Oct 23, 2003 · Closed Mar 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Additional source detail variants (5)
Exterior Lighting:brake Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:brake Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.