NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
87 reportsClear category filter100,000 miles · Oct 28, 2012
Vehicle Speed Control
FROM A SPEED OF 20 MPH, I BEGAN TO APPLY THE BRAKES TO SLOW DOWN FOR A STOP SIGN AND NOTICED THAT THE VEHICLE SPEED CONTINUED TO ACCELERATE EVEN AS I WAS APPLYING THE BRAKES. I WAS ABLE TO BRING THE VEHICLE TO A STOP WITH GREAT DIFFICULTY AND WHEN I RELEASED THE BRAKE, THE VEHICLE SURGED FORWARD WITHOUT ANY PRESSURE ON THE G…
Read full complaint
FROM A SPEED OF 20 MPH, I BEGAN TO APPLY THE BRAKES TO SLOW DOWN FOR A STOP SIGN AND NOTICED THAT THE VEHICLE SPEED CONTINUED TO ACCELERATE EVEN AS I WAS APPLYING THE BRAKES. I WAS ABLE TO BRING THE VEHICLE TO A STOP WITH GREAT DIFFICULTY AND WHEN I RELEASED THE BRAKE, THE VEHICLE SURGED FORWARD WITHOUT ANY PRESSURE ON THE GAS PEDAL. THIS SAME PROBLEM HAS HAPPENED A TOTAL OF 10 - 12 TIMES SINCE THE FIRST INCIDENT. I HAVE TRIED TO DRIVE THIS CAR AS LITTLE AS POSSIBLE DUE TO THIS PROBLEM AND WOULD REALLY APPRECIATE HAVING FORD CORRECT WHATEVER DEFECTIVE MECHANICAL ISSUE IS CAUSING THIS DANGEROUS CONDITION. *TR
NHTSA ODI #10482464
115,000 miles · Oct 25, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE ATTEMPTING TO MAKE AN U-TURN HE ENGAGED THE ACCELERATOR PEDAL AND THE VEHICLE LUNGE FORWARD. THE CONTACT MENTIONED THAT THE ACCELERATOR PEDAL BECAME STUCK. ALSO, THE CONTACT STATED THAT HE HAD TO ENGAGE THE BRAKES AND SHIFT INTO NEUTRAL IN ORDER TO STOP THE V…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE ATTEMPTING TO MAKE AN U-TURN HE ENGAGED THE ACCELERATOR PEDAL AND THE VEHICLE LUNGE FORWARD. THE CONTACT MENTIONED THAT THE ACCELERATOR PEDAL BECAME STUCK. ALSO, THE CONTACT STATED THAT HE HAD TO ENGAGE THE BRAKES AND SHIFT INTO NEUTRAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 115,000.
NHTSA ODI #10482274
88,000 miles · Jun 5, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL BECAME STUCK IN A PARTIALLY DEPRESSED POSITION AND THE VEHICLE SURGED FORWARD. THE CONTACT APPLIED THE BRAKES IN ORDER TO RELEASE THE ACCELERATOR PEDAL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO HA…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE ACCELERATOR PEDAL BECAME STUCK IN A PARTIALLY DEPRESSED POSITION AND THE VEHICLE SURGED FORWARD. THE CONTACT APPLIED THE BRAKES IN ORDER TO RELEASE THE ACCELERATOR PEDAL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 88,000.
NHTSA ODI #10460709
94,000 miles · Apr 18, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WERE APPLIED AND THE VEHICLE UNEXPECTEDLY ACCELERATED. THE VEHICLE WAS SHIFTED INTO NEUTRAL AND THE BRAKES WERE APPLIED TO ASSIST WITH STOPPING. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED …
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE BRAKES WERE APPLIED AND THE VEHICLE UNEXPECTEDLY ACCELERATED. THE VEHICLE WAS SHIFTED INTO NEUTRAL AND THE BRAKES WERE APPLIED TO ASSIST WITH STOPPING. THE MANUFACTURER HAD NOT BEEN MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 94,000 AND THE CURRENT MILEAGE WAS 94,010.
NHTSA ODI #10455666
30,000 miles · Mar 23, 2012
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT UPON SHIFTING INTO REVERSE, THE VEHICLE ACCELERATED FORWARD. THE CONTACT APPLIED THE BRAKES, BUT THE VEHICLE CONTINUED TO ACCELERATE AT A LOW SPEED UNTIL CRASHING INTO A BUILDING. THE FAILURE RECURRED A FEW YEARS LATER AND THE VEHICLE CRASHED INTO ANOTHER VEHICLE A…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT UPON SHIFTING INTO REVERSE, THE VEHICLE ACCELERATED FORWARD. THE CONTACT APPLIED THE BRAKES, BUT THE VEHICLE CONTINUED TO ACCELERATE AT A LOW SPEED UNTIL CRASHING INTO A BUILDING. THE FAILURE RECURRED A FEW YEARS LATER AND THE VEHICLE CRASHED INTO ANOTHER VEHICLE AT A LOW SPEED. THE FAILURE OCCURRED ON A THIRD OCCASION, BUT DID NOT RESULT IN A CRASH. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON VARIOUS OCCASIONS, BUT A FAILURE WAS NEVER DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 30,000.
NHTSA ODI #10452805
169,000 miles · Mar 13, 2012
Vehicle Speed Control
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE BRAKES WERE APPLIED BUT THE CONTACT HAD DIFFICULTIES WITH GETTING THE VEHICLE TO STOP. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC BUT THE MECHANIC COULD NOT DIAGNOSE A FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD TAURUS. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE BRAKES WERE APPLIED BUT THE CONTACT HAD DIFFICULTIES WITH GETTING THE VEHICLE TO STOP. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC BUT THE MECHANIC COULD NOT DIAGNOSE A FAILURE. THE FAILURE MILEAGE WAS 169,000.
NHTSA ODI #10451481
100,000 miles · Mar 12, 2012
Vehicle Speed ControlCrash
I WAS CRUISING ON THE FREEWAY, AS I APPROACHED MY EXIT I BEGAN HITTING THE BRAKES AND NOTICED THE CAR WAS HARDLY SLOWING DOWN. I CONTINUED TO SLAM ON THE BRAKES ATTEMPTING TO GET DOWN TO THE OFF RAMP SPEED LIMIT UNTIL I REALIZED IT WASN'T GOING TO HAPPEN. I WAS RAPIDLY APPROACHING A BUSY INTERSECTION AND BEFORE I COULD EVEN THIN…
Read full complaint
I WAS CRUISING ON THE FREEWAY, AS I APPROACHED MY EXIT I BEGAN HITTING THE BRAKES AND NOTICED THE CAR WAS HARDLY SLOWING DOWN. I CONTINUED TO SLAM ON THE BRAKES ATTEMPTING TO GET DOWN TO THE OFF RAMP SPEED LIMIT UNTIL I REALIZED IT WASN'T GOING TO HAPPEN. I WAS RAPIDLY APPROACHING A BUSY INTERSECTION AND BEFORE I COULD EVEN THINK TO PUT THE CAR IN NEUTRAL I HAD TO TURN QUICKLY INTO A SNOWBANK TO AVOID AN EVEN WORSE ACCIDENT. I WAS TERRIFIED AND I'M JUST HAPPY NO ONE WAS SEVERELY HURT OR KILLED, MY CAR SUFFERED DAMAGE AND THE EFFECTS ARE STILL THERE. *TR
NHTSA ODI #10451259
Mileage unknown · Mar 2, 2010
Vehicle Speed Control
2000 FORD TAURUS WITH SUDDEN ACCELERATION. *KB THE CONSUMER MANAGED TO STOP THE VEHICLE. ANOTHER MOTORIST PULLED THE CONSUMER OUT OF THE VEHICLE, BECAUSE THE VEHICLE'S BRAKES WERE ON FIRE DUE TO THEM OVERHEATING. THE FIRE WAS PUT OUT. THE MECHANIC STATED UNDER THE CIRCUMSTANCES IN WHICH THE CONSUMER WAS DRIVING, ICE FORMS IN …
Read full complaint
2000 FORD TAURUS WITH SUDDEN ACCELERATION. *KB THE CONSUMER MANAGED TO STOP THE VEHICLE. ANOTHER MOTORIST PULLED THE CONSUMER OUT OF THE VEHICLE, BECAUSE THE VEHICLE'S BRAKES WERE ON FIRE DUE TO THEM OVERHEATING. THE FIRE WAS PUT OUT. THE MECHANIC STATED UNDER THE CIRCUMSTANCES IN WHICH THE CONSUMER WAS DRIVING, ICE FORMS IN THROTTLE BODY WHICH WOULD CAUSE THE VEHICLE TO ACCELERATE UNCONTROLLABLY. *JB
NHTSA ODI #10315411
142,000 miles · Feb 19, 2009
Air BagsService Brakes, HydraulicVehicle Speed ControlCrash
MY MOTHER HAD A HORRIFYING EXPERIENCE AND A ACCIDENT WHILE DRIVING MY 2000 FORD TAURUS. AS SHE WAS PUTTING CAR IN DRIVE, WHEN LEAVING RESTAURANT THE CAR SUDDENLY WENT OUT OF CONTROL AND SPED UP ON ITS OWN AND EVEN WHILE SHE HAD HER FOOT ON THE BRAKE ALL THE WAY TO FLOOR CAR WOULD NOT STOP, THE ACCELERATOR WAS STUCK AND SHE WAS T…
Read full complaint
MY MOTHER HAD A HORRIFYING EXPERIENCE AND A ACCIDENT WHILE DRIVING MY 2000 FORD TAURUS. AS SHE WAS PUTTING CAR IN DRIVE, WHEN LEAVING RESTAURANT THE CAR SUDDENLY WENT OUT OF CONTROL AND SPED UP ON ITS OWN AND EVEN WHILE SHE HAD HER FOOT ON THE BRAKE ALL THE WAY TO FLOOR CAR WOULD NOT STOP, THE ACCELERATOR WAS STUCK AND SHE WAS TERRIFIED AS SHE WAS HEADING HEAD ON TO THE RESTAURANTS BRICK BUILDING WHERE SHE ENDED UP CRASHING INTO AND PEOPLE INSIDE RESTAURANT SAID THEY WERE HURT AS WELL AS MY CAR GOT BADLY DAMAGED AND THE BUILDING. MY MOTHER AND THE PEOPLE INSIDE ARE LUCKY TO BE ALIVE BECAUSE OF THIS PROBLEM WITH THE GAS PEDAL AND BRAKES THIS COULD HAVE BEEN A DEADLY ACCIDENT. MY MOTHER IS BRUISED AND STILL VERY SORE FROM THE ACCIDENT AND THE IMPACT WAS SO HARD WHEN SHE CRASHED INTO THE BRICK BUILDING THAT BOTH FRONT AIR BAGS FAILED TO DEPLOY. PLEASE SOMEONE NEEDS TO LOOK INTO THIS BECAUSE THIS I UNDERSTAND THAT THIS HAS HAPPEN TO OTHERS WHO OWN 2000 FORD TAURUS. I CALLED FORD AND THEY SAID THEY HAD A RECALL ON THIS VEHICLE IN 2002 AND THE PROBLEM WAS CORRECTED BUT HERE IT IS 2009 AND IT HAS HAPPENED AGAIN SO SOMETHING ISN'T RIGHT WITH THESE CARS AND IT SHOULDN'T HAVE TO TAKE SOMEONE TO DIE BEFORE FORD REALIZES THAT THIS PROBLEM IS STILL HAPPENING AND THEY NEED TO DO SOMETHING ABOUT THIS. THERE ARE SEVERAL COMPLAINTS ABOUT THIS SAME PROBLEM. AND IF FORD SAID THEY CORRECTED THE PROBLEM IN 2002 THEN WHY IS IT STILL HAPPENING??????????? PLEASE DO SOMETHING BEFORE ITS TO LATE. I WAS REALLY UPSET AFTER READING ALL THE COMPLAINTS ABOUT 2000 FORD TAURUS OWNERS WHO ARE HAVING THE SAME PROBLEM WITH THERE CAR AND THIS WAS AFTER THE 2002 RECALL WHEN FORD CLAIM THEY FIXED IT. I WISH I KNEW THIS BEFORE I BROUGHT THE CAR OR EVEN LET MY MOTHER DRIVE IT BECAUSE I WOULD NEVER HAVE PUT HER LIFE OR OTHERS IN JEOPARDY LIKE THAT. TOW TRUCK HAD TO PULL MY CAR FROM BUILDING AND THEN IT HAD TO BE TOWED AWAY. *TR
NHTSA ODI #10259407
112,865 miles · Jan 25, 2008
Vehicle Speed ControlFire
WHILE DRIVING OFF THE PARKING LOT OF OUR CORNER CONVENIENCE STORE, MY SON TURN ON THE A/C ONLY TO HAVE SMOKE AND FLAMES SHOOT OUT FROM THE VENTS. IN AN INSTANT PANIC HE LOOKED AROUND AND FOUND THAT THEY WERE TRYING TO FLAG HIM THAT FLAMES WERE SHOOTING FROM UNDER THE CAR. HE IMMEDIATELY CROSSED THE STREET AND WAS ABLE TO GET OUT…
Read full complaint
WHILE DRIVING OFF THE PARKING LOT OF OUR CORNER CONVENIENCE STORE, MY SON TURN ON THE A/C ONLY TO HAVE SMOKE AND FLAMES SHOOT OUT FROM THE VENTS. IN AN INSTANT PANIC HE LOOKED AROUND AND FOUND THAT THEY WERE TRYING TO FLAG HIM THAT FLAMES WERE SHOOTING FROM UNDER THE CAR. HE IMMEDIATELY CROSSED THE STREET AND WAS ABLE TO GET OUT OF THE CAR SAFELY. THE FLAMES BURNED THROUGH THE TOP OF THE HOOD AND THANKFULLY THE FIRE DEPT WAS QUICK AND WAS ABLE TO EXTINGUISH THE FIRE. EVERYTHING UNDER THE HOOD WAS DESTROYED AND EVEN THE FRONT TIRES WOULDN'T BUDGE WHEN TRYING TO PUSH THE VEHICLE OUT OF THE WAY AFTERWARDS. WE HAD THE VEHICLE TOWED TO OUR HOME AND STILL ARE IN POSSESSION OF IT. THOUGH NO WORK HAS BEEN DONE ON IT AND IN OUR OPINION NOTHING LEFT TO WORK ON, WE KNOW THAT THERE HAS TO HAVE BEEN SOMETHING FAULTY. SEVERAL MECHANIC FRIENDS ALL SAY THE SAME THING ABOUT LOOKING INTO THE CRUISE CONTROL DEACTIVATION SWITCH WHICH HAS BEEN HAVING RECALLS, HOWEVER, OUR MAKE AND MODEL IS NOT ON THE RECALL LIST. STILL WE KNOW IT DOESN'T JUST HAPPEN WITHOUT A CAUSE WE ARE GRATEFUL THAT OUR SON WAS NOT INJURED AND THOUGH HE WAS DEFINITELY TRAUMATIZED, WE REALIZE IT COULD HAVE BEEN WORSE AS WE HEAR THE STORIES. WE NOW HAVE NO CAR AND STILL OWE A BALANCE SINCE IT TURNS OUT WHAT WE THOUGHT WE WERE PAYING FOR IN LIABILITY W/ COMP AND COLLISION TURNED OUT TO BE ONLY LIABILITY. THE FORD COMPANY SAYS IT CAN'T HELP US AND SO WE WERE GIVEN TO THIS SITE FOR SOME KIND OF DIRECTION. *TR
NHTSA ODI #10216041
Official recalls
8Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Mar 2, 2004
CERTAIN PASSENGER VEHICLES ARE BEING RECALLED TO CORRECT A PROBLEM WITH A MALFUNCTIONING STOP LAMP SWITCH AND/OR ASSOCIATED WIRING. THIS MALFUNCTIONING COULD RENDER THE STOP LAMPS INOPERABLE OR CAUSE THEM TO STAY ON ALL THE TIME. THIS COULD CAUSE CONFUSION TO A FOLLOWING DRIVER, WHICH COULD LEAD TO A CRASH.
Consequence & remedy
Consequence: IN ADDITION, IF THE SWITCH AND/OR ASSOCIATED WIRING FAIL IN THE OPEN POSITION, THE BRAKE LIGHTS WILL NOT ACTUATE AND THE DRIVER WILL NOT BE ABLE TO SHIFT THE VEHICLE OUT OF "PARK" IF THEY FAIL IN THE CLOSED POSITION, THE BRAKE LIGHTS WILL REMAIN ON, WHICH WILL NOT ALLOW THE SPEED CONTROL TO BE ACTIVATED. THIS COULD ALSO CAUSE THE BATTERY TO DISCHARGE.
Remedy: DEALERS WILL REMOVE THE STOP LAMP SWITCH AND ASSOCIATED WIRING ASSEMBLY AND INSTALL A NEWLY DESIGNED STOP LAMP SWITCH AND WIRE ASSEMBLY. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON APRIL 5, 2004. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Oct 2, 2002
CERTAIN PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PADELS ARE BEING RECALLED IN ORDER TO ADJUST THE BRAKE AND ACCELERATOR PEDALS TO A MINIMUM OF 50 MM OF LATERAL SEPARATION. SIMULTANEOUS APPLICATION OF BOTH THE BRAKE AND ACCELERATOR PEDALS COULD RESULT IN AN INCREASE IN ENGINE RPM.
Consequence & remedy
Consequence: THIS COULD RESULT IN A CUSTOMER EXPERIENCING AN "UNINTENDED VEHICLE SPEED INCREASE" OR A PERCEIVED "UNABLE TO STOP" CONDITION.
Remedy: OWNERS WILL BE INSTRUCTED AS TO THE PROPER WAY TO SET THE POSITION OF THE PEDALS AND TO TAKE THEIR VEHICLES TO A DEALER TO HAVE THE SPACING BETWEEN THE BRAKE AND ACCELERATOR PEDALS MEASURED. IF THE SPACING IS FOUND TO BE LESS THAN 50 MM, THE DEALER WILL ADJUST THE PEDALS TO INCREASE THE DISTANCE BETWEEN THEM TO GREATER THAN 50 MM. OWNER NOTIFICATION BEGAN OCTOBER 28, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
Mar 12, 2001
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES. DUE TO THE USE OF INCORRECT MATERIAL BY A SUPPLIER, THE HEADLAMP SWITCH KNOB CAN FRACTURE AND SEPARATE FROM THE HEADLAMP SWITCH.
Consequence & remedy
Consequence: THIS WOULD CAUSE DIFFICULTY FOR THE DRIVER TO ACTIVATE THE HEADLAMPS, WHICH COULD AFFECT DRIVER VISIBILITY, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH KNOB. OWNER NOTIFICATION BEGAN APRIL 9, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Mar 12, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS. IF THE GREASE FROM THE ADJUSTABLE PEDAL ASSEMBLY ENTERS THE STOP LAMP SWITCH, IT CAN CONTAMINATE THE CONTACTS LEADING TO CARBON BUILD UP, AND POTENTIALLY, A SHORT CIRCUIT.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD LEAD TO EITHER THE BRAKE LAMPS STAYING ON, OR TO A LOSS OF BRAKE LAMP FUNCTION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LAMP SWITCH AND WIPE DOWN THE ADJUSTABLE PEDAL ASSEMBLY TO REMOVE EXCESS GREASE. OWNER NOTIFICATION BEGAN MARCH 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Feb 28, 2001
VEHICLE DESCRIPTION: PASSENGER SEDANS WITH FACTORY OR DEALER-INSTALLED DECK LID SPOILERS WITH LED CENTER HIGH MOUNTED STOP LAMPS (CHMSL). VEHICLES PRODUCED WITH SPOILERS WERE MANUFACTURED FROM MARCH 1 THROUGH OCTOBER 31, 2000; AND VEHICLES WITH SPOILERS INSTALLED BY DEALERS WERE MANUFACTURED FROM JANUARY 1 THOROUGH DECEMBER 30, 2000. WITH THE IGNITION SWITCH IN THE START OR RUN POSITIONS AND THE HAZARD WARNING LIGHTS OPERATING, THE CHMSL CAN ILLUMINATE (AT REDUCED INTENSITY) EVEN THOUGH THE SERVICE BRAKES HAVE NOT BEEN APPLIED. THIS DOES NOT MEET THE REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." ALSO, IN SOME CASES THE VEHICLE BRAKE-SHIFT INTERLOCK WOULD NOT FUNCTION PROPERLY, ALLOWING THE SHIFT LEVER TO BE MOVED FROM PARK WITHOUT APPLYING THE BRAKE.
Consequence & remedy
Consequence: UNDER THE REQUIREMENTS OF THE STANDARD, THE CHMSL SHALL BE ACTIVATED ONLY UPON APPPLICATION OF THE SERVICE BRAKES. ALSO, THE VEHICLE COULD ROLL INCREASING THE RISK OF A CRASH, IF THE SHIFT LEVER CAN BE SHIFTED OUT OF PARK WITHOUT DEPRESSING THE BRAKE PEDAL.
Remedy: DEALERS WILL INSTALL A JUMPER/RESISTOR ASSEMBLY AT THE SPOILER THAT PROVIDES AN ELECTRICAL RESISTOR TO GROUND AND CORRECTS THE CHMSL AND BRAKE-SHIFT INTERLOCK CONDITIONS. OWNER NOTIFICATION BEGAN MARCH 19, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Aug 24, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE "VEHICLE CAPACITY WEIGHT" AND "DESIGNATED SEATING CAPACITY" INFORMATION WAS NOT PRINTED ON THE SAFETY CERTIFICATION LABELS AFFIXED TO THESE VEHICLES. ON AFFECTED SABLE SEDAN VEHICLES, THE "VEHICLES CAPACITY WEIGHT" (AND ALSO THE LUGGAGE LOAD) INFORMATION PRINTED ON THIS LABEL IS INCORRECT - SABLE WAGON LUGGAGE LOAD WAS INCORRECTLY USED FOR THE SABLE SEDAN. THESE VEHICLES DO NOT COMPLY WITH THE LABEL REQUIREMENTS OF FMVSS NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: EXCESSIVE LOADING CAN CAUSE TIRE AND VEHICLE DAMAGE THAT COULD RESULT IN A CRASH.
Remedy: OWNERS WILL BE PROVIDED WITH A SUPPLEMENTAL LABEL WITH THE CORRECT INFORMATION, ALONG WITH INSTRUCTIONS FOR AFFIXING THE LABEL ADJACENT TO THE VEHICLE CERTIFICATION LABEL. OWNER NOTIFICATION BEGAN OCTOBER 20, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
9PE12033 · Speed Control Cable Damage
Opened Oct 24, 2012 · Closed Jun 26, 2013
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:cables; Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Additional source detail variants (3)
Vehicle Speed Control:cables
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control:cruise Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
Vehicle Speed Control
On June 21, 2013, Ford initiated Customer Satisfaction Program 13B04 to address a concern with Speed Control Cable damage in certain model year (MY) 2000 through 2003 Taurus and Sable vehicles equipped with 3.0L 4V Duratec engines and built at the Chicago assembly plant.In the dealer letter for the program, Ford indicates that the Speed Control Cables on affected vehicles may be susceptible to damage or becoming partially disconnected during under hood vehicle maintenance (e.g., replacing a battery or changing the air filter) and that a damaged Speed Control Cable could interfere with the throttle's full return to idle when the accelerator pedal is released.Ford's program instructs dealers to inspect the Speed Control Cables and replace any with any portion of either collar retention tab missing.Dealers will install a Collar Reinforcement Clip at the Speed Control Cable collar in all vehicles. Figure 1 shows the location of the Speed Control Cable in the engine compartment and the proximity of the battery and air filter.The failure mode of the cable assembly is associated with the plastic collar used to secure the cable to a bracket near the throttle body (Figure 2).Damage to one or both retention tabs used to secure the cable ferrule within the collar may allow the ferrule to become disconnected from the collar when the throttle is opened during accelerator pedal application.Additional examples of Speed Control Cables with damaged collar retention tabs and partial ferrule displacement are shown in Figures 3 through 5.If the displacement pulls the ferrule completely out of the collar, the ferrule end may contact the face of the collar when the accelerator pedal is released and the throttle is returning to idle (Figure 6).This results in a throttle stuck at approximately 26-29% open.Testing conducted at NHTSA's Vehicle Research and Test Center found that brake booster vacuum may become depleted, resulting in reduced brake effectiveness, if the brake is applied repeatedly when the throttle is stuck at this position.Drivers who experienced this condition have reported being surprised that the engine speed did not drop as expected and in some cases misjudged the degree of braking required to slow the vehicle.Some drivers reported difficulty in braking the vehicle and responded by shifting to neutral or turning the engine off.One minor crash occurred when the vehicle contacted a roadside fence post after the driver responded to the stuck throttle by shifting the car to neutral, turning the engine off and coasting to the side of a roadway with no shoulder, resulting in approximately $400 damage to the vehicle.There were four crashes reported which were attributed to increased stopping distance caused by the increased engine power and/or reduced brake effectiveness, including two of the complaints to ODI.In one crash reported to ODI (VOQ 10516101), the subject vehicle allegedly hit the back end of a truck at approximately 40 mph causing about $2000 damage.In the other crash complaint to ODI (VOQ 10501834), the subject vehicle side-swiped a vehicle as the driver was unable to stop in time and attempted to maneuver around a line of vehicles stopped at a traffic light.When the tow truck driver subsequently started the incident vehicle, the engine was still racing and it was verified that the Speed Control Cable ferrule was stuck on the collar.After further investigation, ODI does not consider the crashes reported in VOQs 10456249 and 10159399 to be related to the Speed Control Cable problem.
EA06002 · Rear Coil Spring Fracture
Opened Jan 24, 2006 · Closed Feb 5, 2007
Status: closed (inferred from source dates) · Suspension:rear; Suspension:rear:springs; Suspension:rear:springs:coil Springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Suspension:rear
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Suspension:rear:springs:coil Springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Suspension:rear:springs
ODI'S ANALYSIS IDENTIFIED A HIGH COMPLAINT RATE FOR THE REAR COIL SPRINGS IN THE SALT BELT STATES (APPROXIMATELY 250 PER 100,000 VEHICLES).APPROXIMATELY 59 PERCENT OF THE COMPLAINTS ALLEGED THAT THE COIL SPRING FAILURE CAUSED DAMAGE TO THE ADJACENT REAR TIRE, WITH ABOUT HALF OF THESE (30 PERCENT OF TOTAL COMPLAINTS) ALLEGING THAT THE DAMAGE RESULTED IN AIR LOSS.BECAUSE AIR LOSS FROM A REAR TIRE CAN RESULT IN CHANGES IN VEHICLE HANDLING CHARACTERISTICS, ODI EXAMINED FIELD DATA, TEST DATA AND INTERVIEWED CONSUMERS TO ASSESS THE SAFETY CONSEQUENCES OF SUCH FAILURES IN THE SUBJECT VEHICLE POPULATION.ANALYSIS OF ALL AVAILABLE FIELD DATA DID NOT IDENTIFY ANY CRASHES OR INJURIES RESULTING FROM THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.VRTC TESTING CONDUCTED TO SIMULATE A COIL SPRING INDUCED REAR TIRE FAILURE DID NOT RESULT IN A LOSS OF VEHICLE CONTROL.WHEN INTERVIEWED BY ODI, NONE OF THE CONSUMERS WHO EXPERIENCED INCIDENTS OF TIRE AIR LOSS DUE TO THE ALLEGED DEFECT INDICATED THAT THE FAILURES CAUSED A LOSS OF VEHICLE CONTROL.TIRE DAMAGE RESULTING FROM THE ALLEGED DEFECT HAS INVOLVED RUBBING/ABRASIVE WEAR OF THE INNER TIRE SIDEWALL WITH THE POTENTIAL FOR AIR LOSS FROM PIN-HOLE SIZED LEAKS IN THE WEAR GROOVE.THERE IS NO EVIDENCE THAT THE ALLEGED DEFECT HAS CAUSED ANY SUDDEN, CATASTROPHIC TIRE FAILURES IN EITHER STRAIGHT OR TURNING MANEUVERS.A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL MONITOR THIS ISSUE AND RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
PE05054 · Rear Coil Spring Fracture
Opened Sep 27, 2005 · Closed Jan 24, 2006
Status: closed (inferred from source dates) · Suspension:rear:springs; Suspension:rear:springs:coil Springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
Additional source detail variants (2)
Suspension:rear:springs:coil Springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
Suspension:rear:springs
THE OFFICE OF DEFECT INVESTIGATION (ODI) OPENED PRELIMINARY EVALUATION, PE05-054, BASED ON 131 VEHICLE OWNER QUESTIONNAIRES RELATED TO ALLEGED REAR COIL SPRING FRACTURES.SINCE OPENING THE INVESTIGATION THERE HAVE BEEN AN ADDITIONAL SIXTY-THREE (63) COMPLAINTS ALLEGING REAR COIL SPRING FRACTURE.AN ANALYSIS OF THE VEHICLE OWNER QUESTIONNAIRES (VOQS) SUBMITTED TO ODI REVEALS THAT 42% OF THE COMPLAINANTS ALLEGE THAT THE ADJACENT TIRE WAS PUNCTURED AS RESULT OF A REAR COIL SPRING FRACTURE. ADDITIONALLY, AN ANALYSIS OF THE COMPLAINT DATA RECEIVED BY ODI FROM FORD REVEALS THE FOLLOWING: THERE WERE A TOTAL OF 553 UNIQUE VEHICLE COMPLAINTS OF COIL SPRING FRACTURE. 30% OF THE COMPLAINTS ALLEGE THAT THE REAR COIL SPRING FRACTURE RESULTED IN THE ADJACENT TIRE BEING PUNCTURED. AN ENGINEERING ANALYSIS (EA06-002) IS BEING OPENED TO FURTHER EXAMINE THE POTENTIAL SAFETY IMPLICATIONS OF THE REAR COIL SPRING FRACTURES AS RELATED TO TIRE PUNCTURES.
PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
RP03001 · Brake/accelerator Pedal Application
Opened Oct 31, 2003 · Closed Mar 23, 2004
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:pedals And Linkages
MS. RODMAN REPORTED THAT AFTER HER VEHICLE WAS INSPECTED FOR THE RECALL, HER MOTHER EXPERIENCED A SUDDEN ACCELERATION AND CRASHED THE SABLE INTO A LIGHT POLE.PREVIOUSLY NHTSA HAD CONDUCTED AN INVESTIGATION FOR THIS ISSUE (PE02-035) THAT RESULTED IN THE RECALL (02V-266) OF 369,000 MY 2000-2002 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE BRAKE AND ACCELERATOR PEDALS TO INSURE THAT THE SEPARATION BETWEEN THE PEDALS WAS AT LEAST 50MM..A REVIEW OF ODI'S DATABASE FOR COMPLAINTS REGARDING RECALL 02V-266 DID NOT IDENTIFY ANY RECALL REMEDY COMPLAINTS OTHER THAN THE PETITIONER'S.MS. RODMAN?S VEHICLE WAS INSPECTED BY ODI USING FORD?S SPECIAL TOOL AND HER VEHICLE WAS FOUND TO EXCEED 50MM.ALSO, THE LATERAL MOVEMENT OF THE PEDALS WAS FOUND NOT TO BE EXCESSIVE RELATIVE TO OTHER COMPARABLE TAURUS AND SABLE VEHICLES.THEREFORE, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER REQUIRING FORD TO PROVIDE A DIFFERENT REMEDY FOR THIS DEFECT.IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.FOR ADDITIONAL INFORMATION CONCERNING THIS ANALYSIS, PLEASE REFER TO THE FEDERAL REGISTER NOTICE DATED MARCH 23, 2004 (VOL 69, NO 56, PAGES 13619-13620).
RQ03008 · Brake Light Switch Failure
Opened Oct 23, 2003 · Closed Mar 5, 2004
Status: closed (inferred from source dates) · Exterior Lighting; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Additional source detail variants (5)
Exterior Lighting:brake Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:brake Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
Exterior Lighting:tail Lights:switch
FORD CONDUCTED A RECALL IN MARCH, 2001 TO CORRECT A DEFECT AFFECTING THE BRAKE LIGHT SWITCH IN MY 2000 THROUGH EARLY-2001 TAURUS AND SABLE VEHICLES EQUIPPED WITH POWER ADJUSTABLE PEDALS (RECALL 01V-078).RQ03-008 WAS OPENED TO INVESTIGATE COMPLAINTS CONCERNING THE REMEDY AND SCOPE OF 01V-078.ODI'S ANALYSIS IDENTIFIED CONCERNS WITH POST-REPAIR FAILURES IN RECALLED VEHICLES,FAILURES IN MY 2001-02 VEHICLES WITH ADJUSTABLE PEDALS THAT WERE NOT INCLUDED IN RECALL 01V-078, AND FAILURES IN MY 2000 VEHICLES WITH FIXED PEDALS.(NOTE: THE MANUFACTURER FAILURE DATA IN THIS RESUME INCLUDES ALL CRASHES AND INJURIES, BUT THE COMPLAINT INFORMATION IS LIMITED TO MY 2001-02 VEHICLES THAT WERE NOT INCLUDED IN THE SCOPE OF RECALL 01V-078.)ON MARCH 1, 2004, FORD NOTIFIED NHTSA OF A SAFETY DEFECT IN MY 2000 THROUGH EARLY-2003 TAURUS AND SABLE VEHICLES EQUIPPED WITH ADJUSTABLE PEDALS AND MY 2000 SUBJECT VEHICLES EQUIPPED WITH FIXED PEDALS (RECALL 04V-106).THE NOTIFICATION IDENTIFIED THREE FACTORS CONTRIBUTING TO BRAKE LIGHT CIRCUIT FAILURES:(1) CONTINUING GREASE CONTAMINATION ISSUES THAT PROMPTED 01V-078; (2) MISALIGNMENT OF THE BOOSTER ROD PIN AND THE BRAKE LIGHT SWITCH; AND (3) WIRE ASSEMBLY FATIGUE.THE FIRST TWO CONDITIONS WERE LIMITED TO VEHICLES WITH ADJUSTABLE PEDALS AND THE LATTER CONDITION AFFECTED VEHICLES WITH FIXED PEDALS.FORD WILL INSTRUCT OWNERS TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE BRAKE LIGHT SWITCH AND ASSOCIATED WIRING REPLACED WITH A RE-DESIGNED BRAKE LIGHT SWITCH AND WIRING ASSEMBLY.
EA03010 · Frontal Air Bag NON-DEPLOYMENT In Crash
Opened Jul 2, 2003 · Closed Jun 23, 2004
Status: closed (inferred from source dates) · Air Bags:frontal
THIS INVESTIGATION IDENTIFIED A TOTAL OF 427 REPORTS ALLEGING NON-DEPLOYMENT OF THE FRONTAL AIR BAGS.OF THE 427 REPORTS, TWO INCIDENTS (FATAL CRASHES) HAVE BEEN IDENTIFIED AS SEVERE FRONTAL CRASHES IN WHICH THE FRONTAL AIR BAGS DID NOT DEPLOY.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE ATTACHED SUMMARY REPORT.
PE03002 · Frontal Air Bag NON-DEPLOYMENT In Crash
Opened Jan 6, 2003 · Closed Jul 2, 2003
Status: closed (inferred from source dates) · Air Bags:frontal
FORD MOTOR COMPANY HAS IDENTIFIED 260 REPORTS ALLEGING FRONTAL AIR BAG NON-DEPLOYMENT FOR ANY (SEVERITY) FRONTAL OR NEAR-FRONTAL CRASH ON MODEL YEAR 2000-2001 FORD TAURUS AND MERCURY SABLE VEHICLES.ADDITIONAL CRASH REPORTS ARE CONTAINED IN NHTSA'S FATALITY ANALYSIS REPORTING SYSTEM (FARS) DATABASE.THE SINGLE ODI REPORT LISTED IN THE REPORT SUMMARY IS NHTSA'S SPECIAL CRASH INVESTIGATION'S CASE NO. CA00-020 THAT INVOLVED A HIGH-SPEED CRASH NON-DEPLOYMENT INVOLVING A DRIVER FATALITY AND FRONT PASSENGER INJURY.THIS PRELIMINARY EVALUATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA03-010) AND ODI WILL COLLECT ADDITIONAL INFORMATION ON CERTAIN CRASH REPORTS AND CONDUCT FURTHER STUDY OF THIS ISSUE.
PE02035 · Brake/accel Pedal Separation
Opened Mar 15, 2002 · Closed Oct 22, 2002
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
No summary supplied.
Illustration