Illustration1999 FORD 3L DUO CAM ENGINE. THEIR IS NO APPARENT ENGINE BRAKING FROM THIS ENGINE AT HIGHWAY SPEEDS. LOCKING OUT OVERDRIVE WILL HELP BUT CAUSES THE ENGINE TO REV EXCESSIVELY. CRUISE CONTROL SPEED WILL EXCEED THE SPEED LIMIT BY A LOT WHILE GOING DOWN HILL, EVEN SLIGHTLY. *TR
1999 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1999 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
6925–50K
8650–75K
7475–100K
64100–150K
22150K+
337 reports with mileage · 537 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports16 fire reports46 injury reports
What owners actually said
874 reportsTL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE LARGE PLASTIC COMPONENT NEAR THE INSTRUMENT PANEL SEPARATED AND WAS CURLING UPWARD. THE PLASTIC WAS OBSTRUCTING THE CONTACT'S VIEW OF THE WINDSHIELD. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE.…
Read full complaint
TL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE LARGE PLASTIC COMPONENT NEAR THE INSTRUMENT PANEL SEPARATED AND WAS CURLING UPWARD. THE PLASTIC WAS OBSTRUCTING THE CONTACT'S VIEW OF THE WINDSHIELD. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000 AND THE CURRENT MILEAGE WAS 144,607.
A 51 POINT INSPECTION DONE ON A 1999 FORD TAURUS I PURCHASED THAT HAD THE FOLLOWING SAFETY ISSUES: CRACKED BRAKES, LOOSE PINION ROD, TRANSMISSION, STEERING WHEEL OFF CENTER TO NAME A FEW ITEMS. REQUIRED A FLUSHING, OIL, ETC. I HAD TO PAY OUT OF POCKET TO HAVE MOST OF THESE ITEMS REPAIRED OR REPLACED. SOME OLD PARTS ARE AVAIL…
Read full complaint
A 51 POINT INSPECTION DONE ON A 1999 FORD TAURUS I PURCHASED THAT HAD THE FOLLOWING SAFETY ISSUES: CRACKED BRAKES, LOOSE PINION ROD, TRANSMISSION, STEERING WHEEL OFF CENTER TO NAME A FEW ITEMS. REQUIRED A FLUSHING, OIL, ETC. I HAD TO PAY OUT OF POCKET TO HAVE MOST OF THESE ITEMS REPAIRED OR REPLACED. SOME OLD PARTS ARE AVAILABLE, BUT I ALSO HAVE DOCUMENTATION TO SUPPORT MY COMPLAINT. I HAVE NOT HAD THE TRANSMISSION FIXED DUE TO FUNDS. THESE ITEMS ARE A SAFETY ISSUE AND COULD HAVE CAUSE A MAJOR ACCIDENT. *TR
TL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED SHORTLY AFTER PURCHASING THE VEHICLE, THE DEALER INFORMED HIM THAT THE FRONT STABILIZER BAR WAS FRACTURED AND THE REAR STABILIZER BAR WAS MISSING. THE DEALER ADVISED WHEN DRIVING IN WET OR ICY WEATHER A SAFETY HAZARD COULD EXIST. THE VEHICLE HAS NOT BEEN REPAIRED. THE F…
Read full complaint
TL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED SHORTLY AFTER PURCHASING THE VEHICLE, THE DEALER INFORMED HIM THAT THE FRONT STABILIZER BAR WAS FRACTURED AND THE REAR STABILIZER BAR WAS MISSING. THE DEALER ADVISED WHEN DRIVING IN WET OR ICY WEATHER A SAFETY HAZARD COULD EXIST. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 185,000.
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE OVERHEATED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THERE WAS CORROSION BUILD-UP THAT HAD TO BE FLUSHED AND DRAINED. THE REPAIR WAS DONE AT THAT TIME. A FEW MONTHS LATER, THE DEFROSTER BECAME DEFEC…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE OVERHEATED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP WHERE THE CONTACT WAS INFORMED THAT THERE WAS CORROSION BUILD-UP THAT HAD TO BE FLUSHED AND DRAINED. THE REPAIR WAS DONE AT THAT TIME. A FEW MONTHS LATER, THE DEFROSTER BECAME DEFECTIVE AND THE FAILURE OCCURRED AGAIN. THE CONTACT CALLED THE DEALERSHIP AND WAS INFORMED THAT SHE WOULD BE CHARGED FOR A DIAGNOSTIC TEST AS THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 30,000. THE CURRENT MILEAGE WAS APPROXIMATELY 54,000.
TL* THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE INVOLUNTARILY DECELERATED TO APPROXIMATE SPEEDS OF 10 MPH WITHOUT WARRANT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE…
Read full complaint
TL* THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE INVOLUNTARILY DECELERATED TO APPROXIMATE SPEEDS OF 10 MPH WITHOUT WARRANT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT A SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 128,000.
I HAVE A 1999 FORD TAURUS. THE FRONT SEAT PASSENGER SEAT BELT HAS RECENTLY LOCKED AND IS UNFUNCTIONAL. I LOOKED UP ON YOUR RECALL LIST TO SEARCH AND FOUND THAT THERE WAS A RECALL ID 99V250000. I CONTACTED FORD MOTOR COMPANY AT THE NUMBER YOU PROVIDED 1-800-392-3573. I WAS TOLD THAT YOUR SITE GENERALIZES MAKES AND MODELS AND …
Read full complaint
I HAVE A 1999 FORD TAURUS. THE FRONT SEAT PASSENGER SEAT BELT HAS RECENTLY LOCKED AND IS UNFUNCTIONAL. I LOOKED UP ON YOUR RECALL LIST TO SEARCH AND FOUND THAT THERE WAS A RECALL ID 99V250000. I CONTACTED FORD MOTOR COMPANY AT THE NUMBER YOU PROVIDED 1-800-392-3573. I WAS TOLD THAT YOUR SITE GENERALIZES MAKES AND MODELS AND THAT MY CAR WAS NOT PART OF THE RECALL. THEY OPENED A CASE UNDER #401980970 ; HOWEVER, SAID THEY WOULD NOT FIX MY CAR. *TR
MY 1999 FORD TAURUS HAS POWER STEERING RACK AND PINION ISSUSES. THE CAR MAKES WHINING NOISES WHEN TURNING, THE STEERING GETS TIGHT AFTER A FEW MINUTES OF DRIVING. THE FLUID OZZES OUT OF PUMP OUT OF CAP.CAN CAUSE A CRASH IT JERKS THE WHEEL A LITTLE BIT ALSO. IVE LOOKED THIS PROBLEM UP ON INTERNET AND THERES ALOT OF THE SAME ISSUE…
Read full complaint
MY 1999 FORD TAURUS HAS POWER STEERING RACK AND PINION ISSUSES. THE CAR MAKES WHINING NOISES WHEN TURNING, THE STEERING GETS TIGHT AFTER A FEW MINUTES OF DRIVING. THE FLUID OZZES OUT OF PUMP OUT OF CAP.CAN CAUSE A CRASH IT JERKS THE WHEEL A LITTLE BIT ALSO. IVE LOOKED THIS PROBLEM UP ON INTERNET AND THERES ALOT OF THE SAME ISSUE WITH THEIR CARS.THERE SHOULD BE A RECALL NOTICE FOR SO MANY OF THE SAME ISSUES
I PURCHASED A VEHICLE FROM SOME [XXX] AND I HAVEN'T HAD THE CAR FOR 30 DAYS AND THE VEHICLES IS UNSAFE HAS HAD ME ALMOST IN SOME ACCIDENT DUE TO THE UNSAFE OF THE CAR. I TOOK THE CAR BACK TO THE PLACE WHERE I PURCHASED IT AND THEY KEEP ON TELLING ME ITS MY FAULT THE CAR IS GIVING ME PROBLEMS. I ASKED THEM IF I CAN JUST GET MY MO…
Read full complaint
I PURCHASED A VEHICLE FROM SOME [XXX] AND I HAVEN'T HAD THE CAR FOR 30 DAYS AND THE VEHICLES IS UNSAFE HAS HAD ME ALMOST IN SOME ACCIDENT DUE TO THE UNSAFE OF THE CAR. I TOOK THE CAR BACK TO THE PLACE WHERE I PURCHASED IT AND THEY KEEP ON TELLING ME ITS MY FAULT THE CAR IS GIVING ME PROBLEMS. I ASKED THEM IF I CAN JUST GET MY MONEY BACK AND WHEN I ADVISE THEM OF THAT THEY TALK IN THEIR LANGUAGE TO ME WHERE I DON'T UNDERSTAND. I HAVE TWO CHILDREN THAT ARE 10 AND 4 ; THE CAR IS NOT SAFE. THE INCIDENT THAT WENT WRONG WITH THE CAR IS IT OVER HEATED CUT OFF ON THE HIGHWAY WHILE I HAD THE CHILDREN IN THE CAR,ALSO AFTER I TOOK IT BACK TO THEM THEY FIXED IT RAN FINE THEN THE FOLLOWING WEEK AFTER THAT THE BELT THAT I HAD INITIALLY TOLD THEM ABOUT THE FIRST TIME CAME OFFTHE NEXT WEEK WHICH COULD SPARK A FUSE WHILE IM DRIVING AND CATCH ON FIRE SO THEY ADVISE ME TO HAVE IT TOWED WHICH THEY HAD ADVISE ME TO DO AND THEY TOOK ON THAT RESPONSIBILITY BUT THE CAR ENGINE LIGHT IS ON IT HAS BECAME A HARDSHIP WITH ME AND MY FAMILY AND IT NOW SOUNDS LIKE THE BRAKES IS GOING WRONG NOW I JUST WANT MY MONEY BACK SO I CAN PURCHASE ANOTHER RELIABLE TRANSPORTATION FOR ME AND MY FAMILY. *TR
I OWN A 99 FORD TAURUS. IT IS LEAKING WATER INTO THE PASSENGER COMPARTMENT. THIS LEAK HAS CAUSED THE HEATER BLOWER MOTOR AND RESISTER TO SHORT OUT AS A RESULT I HAVE NO HEAT AND IT IS WINTER IN MINNESOTA. I CANNOT AFFORD THE OVER $200 REPAIR AND WITH THE LEAK STILL PRESENT IT WILL SHORT OUT AGAIN. THERE IS AT LEAST ONE SIMIL…
Read full complaint
I OWN A 99 FORD TAURUS. IT IS LEAKING WATER INTO THE PASSENGER COMPARTMENT. THIS LEAK HAS CAUSED THE HEATER BLOWER MOTOR AND RESISTER TO SHORT OUT AS A RESULT I HAVE NO HEAT AND IT IS WINTER IN MINNESOTA. I CANNOT AFFORD THE OVER $200 REPAIR AND WITH THE LEAK STILL PRESENT IT WILL SHORT OUT AGAIN. THERE IS AT LEAST ONE SIMILAR COMPLAINT THAT I KNOW OF, IT IS 10184014. I BELIEVE THIS IS A SAFETY ISSUE BECAUSE MY WINDOWS WILL NOT DEFROST AND IT IMPAIRS MY VISION. THE BLOWER MOTOR WOULD NOT HAVE FAILED IF THE LEAK DID NOT EXIST. *TR
Official recalls
504V332000 · Suspension:front:springs:coil Springs
Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
99V250000 · Seat Belts:front:anchorage
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
98V288000 · Power Train:automatic Transmission:cooling Unit And Lines
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
98V204000 · Vehicle Speed Control
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
98V198000 · Seat Belts:front:anchorage
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.