TL* THE CONTACT OWNS A 1999 FORD TAURUS EQUIPPED WITH GOODYEAR EAGLE LS TIRES, SIZE: P225/60R16. THE CONTACT STATED THAT ALL THE TIRES EXPERIENCED CRACKS AND LEAKS. THE DEALER FOUND NO FAILURE WITH THE TIRES. THE TIRES WERE NOT REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS …
Read full complaint
TL* THE CONTACT OWNS A 1999 FORD TAURUS EQUIPPED WITH GOODYEAR EAGLE LS TIRES, SIZE: P225/60R16. THE CONTACT STATED THAT ALL THE TIRES EXPERIENCED CRACKS AND LEAKS. THE DEALER FOUND NO FAILURE WITH THE TIRES. THE TIRES WERE NOT REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE CONTACT STATED THAT THE SAME FAILURE OCCURRED WITH THE GOODYEAR TIRES ON HIS 2000 MERCURY GRAND MARQUIS. THE APPROXIMATE VEHICLE FAILURE MILEAGE WAS 152,000 AND THE TIRE FAILURE MILEAGE WAS 20,000. THE DOT NUMBER AND VIN WERE UNKNOWN.
NHTSA ODI #10730987
78,100 miles · Jul 24, 2012
Tires
MICHELIN HYDROEDGE HAVE DEVELOPED CRACKS IN BOTTOM OF ALL TREADS WITH ONLY 37,000 MILES ON A 90,000 MILE RATED TIRE. THEY DO NOT HAVE SIDEWALL WEATHER-CHECKING SO IT IS NOT A WEATHER OR CHEMICAL ISSUE. MICHELIN WAS ASKED TO PAY FOR AT LEAST 50% OF REPLACEMENT COST BUT THEY REFUSED. THERE IS ONLY 40% OF THE MILES USED ON THIS S…
Read full complaint
MICHELIN HYDROEDGE HAVE DEVELOPED CRACKS IN BOTTOM OF ALL TREADS WITH ONLY 37,000 MILES ON A 90,000 MILE RATED TIRE. THEY DO NOT HAVE SIDEWALL WEATHER-CHECKING SO IT IS NOT A WEATHER OR CHEMICAL ISSUE. MICHELIN WAS ASKED TO PAY FOR AT LEAST 50% OF REPLACEMENT COST BUT THEY REFUSED. THERE IS ONLY 40% OF THE MILES USED ON THIS SET OF $600 SET OF TIRES. THE LOCAL DEALER SAID HE WOULD REPLACE WITH A DIFFERENT STYLE FOR $450, WHICH I DID. MICHELIN OWES ME $150. *TR
NHTSA ODI #10467266
Mileage unknown · Sep 22, 2010
Tires
1999 FORD TAURUS, WESTBOUND WHEN THE LEFT FRONT TIRE HAD THE TREAD SEPARATE. THE TREAD CAME OFF AND DAMAGED THE LEFT SIDE OF THE VEHICLE. *BF (OHIO TRAFFIC CRASH REPORT # 10-0521-90)*JB
NHTSA ODI #10357556
71,000 miles · Sep 10, 2007
Tires
ON SEPTEMBER 1, 2007, WHILE DRIVING ON THE INTERSTATE, A KELLY SPRINGFIELD TIRE (MOHAVE) SHREDDED. ALTHOUGH THE TIRES AND TREAD APPEARED IN EXCELLENT CONDITION, THE TREAD SEPARATED FROM THE TIRE (FROM STEEL BELT OUTWARD) WITHOUT WARNING. THE TIRE SKIN RETAINED AIR, BUT CAR UNDRIVABLE. THIS PREVIOUSLY OCCURRED EXACTLY AS WITH …
Read full complaint
ON SEPTEMBER 1, 2007, WHILE DRIVING ON THE INTERSTATE, A KELLY SPRINGFIELD TIRE (MOHAVE) SHREDDED. ALTHOUGH THE TIRES AND TREAD APPEARED IN EXCELLENT CONDITION, THE TREAD SEPARATED FROM THE TIRE (FROM STEEL BELT OUTWARD) WITHOUT WARNING. THE TIRE SKIN RETAINED AIR, BUT CAR UNDRIVABLE. THIS PREVIOUSLY OCCURRED EXACTLY AS WITH THIS TIRE IN JULY 2007 ON THE SAME VEHICLE. THE CAR WAS PURCHASED WITH "MOHAVE R/S" ALREADY INSTALLED. TIRES AT PURCHASE AND AT TIME OF FAILURE APPEARED IN EXCELLENT CONDITION. ALL FOUR TIRES ON VEHICLE WERE THE SAME AND NOW TWO HAVE FAILED CATASTROPHICALLY. *JB
NHTSA ODI #10202350
98,000 miles · May 22, 2006
TiresCrash
4/27/2006, I HAD A VIBRATION IN MY STEERING WHEEL NOTED PRIMARILY AT LOW SPEEDS. I HAD MY BRAKES DONE AND GENERAL MAINTENANCE BUT VIBRATION WAS STILL PRESENT. WENT TO TIRE SHOP WHO EVALUATED PASSENGER SIDE REAR TIRE WHICH WAS SEPARATING. I HAD COOPER TOURING TIRES ON THE VEHICLE APPROX 1 1/2 YEARS OLD. I HAD THE TIRE REPLACED…
Read full complaint
4/27/2006, I HAD A VIBRATION IN MY STEERING WHEEL NOTED PRIMARILY AT LOW SPEEDS. I HAD MY BRAKES DONE AND GENERAL MAINTENANCE BUT VIBRATION WAS STILL PRESENT. WENT TO TIRE SHOP WHO EVALUATED PASSENGER SIDE REAR TIRE WHICH WAS SEPARATING. I HAD COOPER TOURING TIRES ON THE VEHICLE APPROX 1 1/2 YEARS OLD. I HAD THE TIRE REPLACED AND THE OTHER TIRES INSPECTED AND BALANCED. VIBRATION WAS NO LONGER PRESENT. 5/21/06 DRIVING EAST ON I-10 BEGAN FEELING A STEERING VIBRATION. I WAS NEARING TUCSON AND PLANNED TO EXIT TO THE NEAREST TIRE SHOP, VIBRATION INCREASED. I TOOK INVENTORY OF VEHICLES AROUND ME NOTING A TRUCK PULLING A BOAT AND MADE A DECISION THAT I DID NOT WANT TO BE BY THE BOAT IF ANYTHING HAPPENED. I MADE LANE CHANGE AND SHORTLY AFTER TIRE MADE A BIG BANG AND I SPUN 360 DEGREES ON THE FREEWAY, SPINNING REARWARD INTO THE MEDIAN. I DID AVOID HITTING TREES, OTHER VEHICLES AND BEING STRUCK BY ON-COMING TRAFFIC. I AM A DRIVING INSTRUCTOR AND HAVE HAD SKID CAR TRAINING. THIS WAS THE MOST HORRENDOUS EVENT EVER IN MY DRIVING CAREER. VEHICLE DID SUSTAIN DAMAGE. POLICE ASSISTED IN GETTING ME OUT OF THE VEHICLE ( I USE A WHEELCHAIR AND DRIVE WITH HAND-CONTROLS) AND REMOVED THE TIRE AND PUT THE SPARE ON THE VEHICLE. I WAS ABLE TO DRIVE TO THE NEAREST TIRE REPAIR FACILITY - THE TIRE WAS REPLACED. THE TIRE COMPLETELY SEPARATED AND SHREDDED - I HAVE THE TIRE. THE VEHICLE BODY HAS NOT BEEN REPAIRED YET. TODAY WHEN DISCUSSING WITH CO-WORKERS WHAT HAPPENED - I WAS INFORMED OF A RECENT COOPER TIRE DEFECT STORY AND THAT IS HOW I GOT TO THIS SITE. TIRES ARE COOPER TOURING SLE I AM NOT SURE WHAT RATING DOT U9. *NM
NHTSA ODI #10158055
90,000 miles · Feb 13, 2006
Tires
DT*: THE CONTACT STATED WHILE DRIVING ON THE HIGHWAY THE DRIVER SIDE FRONT SPARE TIRE HAD TREAD SEPARATION. THE TREAD DAMAGED THE WIRING IN THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALERSHIP; HOWEVER, NO REPAIRS HAVE BEEN MADE.
NHTSA ODI #10150162
Mileage unknown · May 20, 2005
Tires
ON APRIL 23, 2005 AT APPROXIMATELY 2100 HOURS ON INTERSTATE 59 SOUTH IN RURAL ALABAMA MY DAUGHTER EXPERIENCED A TIRE MALFUNCTION IN MY FORD TAURUS. THE TIRES TREAD TOTALLY DISINTEGRATED CAUSING EXTENSIVE BODY DAMAGE TO THE VEHICLE (APPROX. $1800). MY OWN PERSONAL INVESTIGATION OF THE INCIDENT SITE AND TIRE ALONG WITH THE STATE…
Read full complaint
ON APRIL 23, 2005 AT APPROXIMATELY 2100 HOURS ON INTERSTATE 59 SOUTH IN RURAL ALABAMA MY DAUGHTER EXPERIENCED A TIRE MALFUNCTION IN MY FORD TAURUS. THE TIRES TREAD TOTALLY DISINTEGRATED CAUSING EXTENSIVE BODY DAMAGE TO THE VEHICLE (APPROX. $1800). MY OWN PERSONAL INVESTIGATION OF THE INCIDENT SITE AND TIRE ALONG WITH THE STATEMENTS OF THE WRECKER DRIVER AND BODY SHOP REPRESENTATIVE SHOW THAT THE TIRE WAS OBVIOUSLY DEFECTIVE. THE DAMAGE TO THE TIRE IS EERILY SIMILAR TO THE DEFECTIVE SUV TIRES RECALLED BY FIRESTONE A FEW YEARS AGO. I AM IN THE PROCESS OF CONTACTING THE TIRE MANUFACTURER TO INFORM THEM OF THIS PROBLEM AND TO SEEK REIMBURSEMENT FOR THE TOWING AND REPAIRS. TIRE INFORMATION: LEMANS TOURING P205/65R15 M+S DOT HYUR LT4 DO5L
NHTSA ODI #10121681
Mileage unknown · Mar 30, 2005
Tires
1999 FORD TAURUS EXPERIENCED TIRE BLOW OUT ON GENERAL UNIROYAL TIRE EQUIPMENT.*MR
NHTSA ODI #10117326
63,000 miles · Dec 15, 2004
Tires
I WAS TRAVELLING SOUTH ON I-15 AT 11:00 AT NIGHT GOING DOWN FROM THE EL CAJON SUMMIT WHEN I THOUGHT THERE WAS A STRANGE WOBBLING EVERY TIME I USED THE BRAKES. I HEARD A TERRIBLE THUD AND THOUGHT I SAW A PIECE OF TIRE FLY BY THE PASSENGER SIDE. I PULLED TO THE SHOULDER AND LOOKED AT ALL THE TIRES, BUT THEY WERE ALL STILL INFLA…
Read full complaint
I WAS TRAVELLING SOUTH ON I-15 AT 11:00 AT NIGHT GOING DOWN FROM THE EL CAJON SUMMIT WHEN I THOUGHT THERE WAS A STRANGE WOBBLING EVERY TIME I USED THE BRAKES. I HEARD A TERRIBLE THUD AND THOUGHT I SAW A PIECE OF TIRE FLY BY THE PASSENGER SIDE. I PULLED TO THE SHOULDER AND LOOKED AT ALL THE TIRES, BUT THEY WERE ALL STILL INFLATED SO I STARTED THE CAR AGAIN AND EASED DOWN THE SHOULDER, BUT THE NOISE WAS STILL THERE. UPON CLOSER EXAMINATION OF THE TIRES, I FOUND THAT THE TREAD SEPARATED COMPLETELY FROM THE TIRE, CAUSING EXTENSIVE DAMAGE TO THE WHEEL WELL. IT ALSO CAUSED A VACUUM HOSE TO COME APART FROM IT'S CONNECTION, WHICH I SUSPECT IS LINKED TO THE AC. AAA WAS CALLED TO CHANGE THE TIRE, AND I HAVE THE RECEIPT. THE NEXT DAY I HAD A NEW TIRE PUT ON AS WELL AS REPLACED ANOTHER TIRE THAT WAS IN NEED. THEY CHECKED THE REMAINING GENERAL TIRE AND SAID IT WAS IN GOOD CONDITION. THE NEXT MORNING I HEADED HOME AT 5:00 IN THE MORNING. I WAS EASTBOUND ON I-91 A MILE AND A HALF FROM THE I-15 CONNECTION WHEN THE EXACT SAME THING HAPPENED TO THE REAR DRIVER SIDE TIRE. AGAIN THE WHEEL WELL WAS COMPLETELY DESTROYED AND THE REAR FENDER TO MY CAR. AAA WAS AGAIN CALLED, AND A RECEIPT WAS OBTAINED. I HAVE BOTH TIRES IN MY POSESSION. THE FIRST INCIDENT HAPPENED ON FRIDAY, DECEMBER 10, AND THE SECOND INCIDENT HAPPENED ON SUNDAY, DECEMBER 12.*AK
NHTSA ODI #10103003
Mileage unknown · Aug 12, 2003
SuspensionTires
WHILE ATTEMPTING TO BACK OUT OF A PARKING SPACE BEHIND MY HOUSE, THE DRIVERS SIDE FRONT COIL SPRING BROKE. THIS CAUSED THE DRIVERS SIDE FRONT TIRE TO PUNCTURE AND INSTANTLY LOSE ALL PRESSURE. ABOUT ONE RING OF THE COIL BROKE OFF AND THE COIL REMAINING ON THE CAR HAD THE SHARP END THAT PIERCED THE TIRE.
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
1999 Ford Taurus Problems, Complaints & Recalls | Skip That Year
Illustration