IllustrationWHEN DRIVING 35 MPH OR ABOVE AND LIGHTLY APPLYING BRAKES STEERING WHEEL WILL SHAKE TO LEFT AND TO RIGHT. CONSUMER REPACED TIRES, BUT DID NOT SOLVE DEFECT.*AK
1999 Ford Taurus
Owner reports · Recalls · Investigations
More warning signs than most Taurus years
Owner complaints for the 1999 Ford Taurus are substantially higher than the model-year median of 318.
About this comparison →How this year compares
Owner complaints by model year
Compare all Taurus years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
6925–50K
8650–75K
7475–100K
64100–150K
22150K+
337 reports with mileage · 537 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 180 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 109 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 106 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
61 crash reports16 fire reports46 injury reports
Suspension complaints
180 reportsFRONT SWAY BAR IS WORN CAUSING CONSUMER TO HEAR A POPPING NOISE IN THE FRONT END ON TURNS INTO DRIVEWAY, ONCE THE SWAY BAR WAS FIXED THE PROBLEM STILL PERSIST, THIS WAS THE SECOND ATTEMPT AT FIXING THE PROBLEM. NLM
THE VEHICLE EXPERIENCE COLD START, DEALER REPLACED THE CATALYTIC CONVERTER. *SLC
1. TRANSMISSION GEAR WAS IN REVERSE WHEN VEHICLE ACCELERATED BACKWARDS, HTTING A POLE. 2. VEHICLE WILL LUNGE FORWARD MOSTLY AT THE FIRST START OF THE DAY. *AK THE VEHICLE HAD TWO SERIOUS VIBRATIONS WHEN BRAKES WERE APPLIED. THE VIBRATION CAUSED THE HEAT SHIELD OVER CONVERTER TO BREAK AND EXHAUST SYSTEM TO SEPARATE AND LEAK. …
Read full complaint
1. TRANSMISSION GEAR WAS IN REVERSE WHEN VEHICLE ACCELERATED BACKWARDS, HTTING A POLE. 2. VEHICLE WILL LUNGE FORWARD MOSTLY AT THE FIRST START OF THE DAY. *AK THE VEHICLE HAD TWO SERIOUS VIBRATIONS WHEN BRAKES WERE APPLIED. THE VIBRATION CAUSED THE HEAT SHIELD OVER CONVERTER TO BREAK AND EXHAUST SYSTEM TO SEPARATE AND LEAK. *YH
VEHICLE WOULD PULL TO RIGHT WHILE DRIVING AT ANY SPEED, AND AT THE SAME TIME THERE WAS A LOUD RAMBLING NOISE. CUSTOMER SERIVCE ENGINEERING FOR FORD(MEMPHIS REGINAL OFFICE) DEEMED VEHICLE DEFECTIVE . PLEASE PROVIDE FURTHER INFORMATION.*AK
WHILE DRIVING VEHICLE, NOTICED A CLUNKING NOISE COMING FROM OF VEHICLE. TOOK VEHICLE TO DEALERSHIP, THEY COULDN;T LOCATE THE PROBLEM. CLUNKING NOISE CONTINUED. MY SON SAID I SHOULD TAKE THE CAR BACK TO THE DEALERSHIP. ON SECOND VISIT TO DEALERSHIP, HAD SERVIE MANAGER DRIVE VEHICLE. IN THEIR PARKING LOT, DROVE OVER A SPEED …
Read full complaint
WHILE DRIVING VEHICLE, NOTICED A CLUNKING NOISE COMING FROM OF VEHICLE. TOOK VEHICLE TO DEALERSHIP, THEY COULDN;T LOCATE THE PROBLEM. CLUNKING NOISE CONTINUED. MY SON SAID I SHOULD TAKE THE CAR BACK TO THE DEALERSHIP. ON SECOND VISIT TO DEALERSHIP, HAD SERVIE MANAGER DRIVE VEHICLE. IN THEIR PARKING LOT, DROVE OVER A SPEED BUMP, HEARD LOUD CLUNKING SOUND. THE CAR WAS PUT ON THE HOIST, THEY COULDN'T FIND ANY PROBLEM. A WEEK LATER, RECEIVED A PHONE CALL FROM CUSTOMER SERVICE. THE SERVICE REPRESENTATIVE WAS INFORMED THE VEHICLE STILLING MAKING CLUNKING NOISE. TOOK VEHICLE BACK TO DEALERSHIP AND HAD SERVICE MANAGER RIDE WITH ME. DROVE ON BUMPY SECTION OF INTERSTATE, CAR TAKEN BACK TO DEALERSHIP. THEY FOUND THE FRONT STABILIZER BAR HAD BROKEN AT THE RUBBER BUSHING CONNECTION. PARTS FOR THE STABILZER BAR HAVE BEEN ON NATIONAL BACK ORDER FOR OVER 2 1/2 MONTH. *AK
THE CAR FREE WHEELS.
CAR HAS HAD SHAKE IN STEERING WHEEL SINCE THE TEST DRIVE; WAS TOLD THAT IT WAS DUE TO CAR SITTING ON THE LOT AND THAT TURNING THE ROTORS WOULD FIX THE PROBLEM. THE SHAKE RETURNED SHORTLY AFTER PURCHASE AND HAS CONTINUED TO BE A PROBLEM SINCE. IT STARTS AS A SUBLTE VIBRATION IN THE STEERING WHEEL AND BECOMES A VIOLENT SHAKE AS …
Read full complaint
CAR HAS HAD SHAKE IN STEERING WHEEL SINCE THE TEST DRIVE; WAS TOLD THAT IT WAS DUE TO CAR SITTING ON THE LOT AND THAT TURNING THE ROTORS WOULD FIX THE PROBLEM. THE SHAKE RETURNED SHORTLY AFTER PURCHASE AND HAS CONTINUED TO BE A PROBLEM SINCE. IT STARTS AS A SUBLTE VIBRATION IN THE STEERING WHEEL AND BECOMES A VIOLENT SHAKE AS THE PROBLEM PROGRESSIVELY GETS WORSE. THE ROTORS HAVE BEEN TURNED, REPLACED 2X, DRUMS REPLACED, WHEEL CYLINDERS REPLACED. WE ASKED THEM THE LAST TIME TO ALSO CHECK PROPORTIONING VALVE, THEY SAID THEY WOULD BUT DIDN'T. IT HAS HAD A TOTAL OF 4 REPAIRS FOR THIS PROBLEM, INCLUDING THEM TURNING T HE ROTORS BEFORE PURCHASE. WE SENT A CERTIFIED LETTER TO FORD JUST BEFORE THE LAST REPAIR. THEY REPLIED WITH THE STATEMENT THAT A REGIONAL OFFICE OR THE SERVICE MANAGER FROM THE DEALERSHIP WOULD CONTACT US, AND IF NOT WE WERE TO CONTACT THE DEALERSHIP. NO ONE CONTACTED US, AND WE'VE BEEN IN CONTACT WITH THE DEALERSHIP FOR 10MONTHS WITH NO SUCCESS. THE SALESPERSON HAS TOLD US SHE'LL SPEAK TO HER GENERAL MANAGER. THE CERTIFIED LETTER WAS RECIEVED BY FORD ON 6/16/00, THE LAST REPAIR WAS DONE ON 6/24/00, AND THE SHAKE RETURNED ON 7/7/00. WE HAVE ALSO HAD A BIG PROBLEM WITH THEM GETTING PARTS TO DO REPAIRS, WITH IT TAKING WEEKS. ALSO WERE TOLD IN THE WINTER TO WAIT UNTIL SPRING FOR T HE REPAIR, THAT THE PROBLEM MIGHT JUST BE CAUSED BY SAND AND SALT, WHICH IT WASN'T.*AK
VEHICLE EXPERIENCING FRONT END VIBRATION AT HIGH SPEEDS OR WHEN APPLYING BRAKES WHEN GOING DOWN HILL, ALSO EXPERIENCING NOISES IN STEERING COLUMN, EIGHT REPAIR ATTEMPTS HOWEVER CONTINUES TO EXPERIENCE PROBLEMS. NLM
I JUST PURCHASES A NEW 1999 4-DOOR FORD TAURUS SE ON 5/3/99. I SENT THE CAR BACK TO BE REPAIRED TO THE MANUFACTURER 2 TIMES IN THE LAST MONTH TO HAVE THE PROBLEM CORRECTED. THE PROBLEM STILL EXISTS. I AM MEETING WITH THE GENERAL MANAGER STEPHEN DINGER SOMETIME THIS WEEK TO HAVE HIM COME ALONG FOR A TEST DRIVE TO WITNESS FIRS…
Read full complaint
I JUST PURCHASES A NEW 1999 4-DOOR FORD TAURUS SE ON 5/3/99. I SENT THE CAR BACK TO BE REPAIRED TO THE MANUFACTURER 2 TIMES IN THE LAST MONTH TO HAVE THE PROBLEM CORRECTED. THE PROBLEM STILL EXISTS. I AM MEETING WITH THE GENERAL MANAGER STEPHEN DINGER SOMETIME THIS WEEK TO HAVE HIM COME ALONG FOR A TEST DRIVE TO WITNESS FIRST HAND THE SHAKING OF THE FRONT END. WE HAVE BEEN TOLD THAT IT IS A TIRE PROBLEM, AND THAT THE TECHNICIANS HAVE REPAIRED THE PROBLEM, BUT THE FRONT END AND STEERING WHEEL STILL SHAKES QUITE SIGNIFICANTLY OVER 60MPH. CAN YOU HELP ME WITH ANY ADVISE ON HOW TO GO ABOUT GETTING OUT OF THE LEASE OR HAVING THE MANUGFACTURER SOMEHOW GIVE US A NEW VEHICLE SEEING THAT THIS PROBLEM DOES NOT APPEAR TO BE JUST A TIRE BALANCE PROBLEM. THANK YOU. *AK
Official recalls
504V332000 · Suspension:front:springs:coil Springs
Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
99V250000 · Seat Belts:front:anchorage
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
98V288000 · Power Train:automatic Transmission:cooling Unit And Lines
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
98V204000 · Vehicle Speed Control
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
98V198000 · Seat Belts:front:anchorage
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.