I AM EXPERIENCING A LEAK (TWICE) IN MY 1999 FORD TAURUS LX THAT LEAVES MY PASSENGER SIDE FLOOR SOAKED AND HAS CAUSED ME TO REPLACE MY BLOWER MOTOR/RESISTOR(ONCE THUS FAR). I DO NOT SEE A SPECIFIC RECALL RELATED TO MY MAKE AND MODEL LISTED ON ANY FORD SITE BUT I HAVE BECOME AWARE THAT THIS IS AN EXTREMELY COMMON EXPERIENCE FOR …
Read full complaint
I AM EXPERIENCING A LEAK (TWICE) IN MY 1999 FORD TAURUS LX THAT LEAVES MY PASSENGER SIDE FLOOR SOAKED AND HAS CAUSED ME TO REPLACE MY BLOWER MOTOR/RESISTOR(ONCE THUS FAR). I DO NOT SEE A SPECIFIC RECALL RELATED TO MY MAKE AND MODEL LISTED ON ANY FORD SITE BUT I HAVE BECOME AWARE THAT THIS IS AN EXTREMELY COMMON EXPERIENCE FOR TAURUS OWNERS. THIS DEFECT IS BEING PASSED ON TO THE CONSUMER UNFAIRLY, A RECALL SHOULD BE ORDERED. I PAID LESS THAN US$200 FOR MY REPLACEMENT PARTS AND LABOR, BUT I HEAR THAT FORD CHARGES UPWARDS OF $500 TO FIX THE LEAK COMPLETELY. IF I DON'T HAVE THIS DONE, I WILL LIKELY BE REPLACING PARTS AGAIN AND/OR WILL BE EXPOSED TO MOLD. PLEASE ACT. I HAVE BEEN ABLE TO FIND OTHERS WITH THE SAME PROBLEM ONLINE SUCH AS A PREVIOUS COMPLAINT : 10184014 FILED CONCERNING RECALL 03V087000. *TR
NHTSA ODI #10211226
47,800 miles · Nov 21, 2004
Power TrainStructureInjury
THE CONSUMER REPLACED THE TRANSMISSION THREE TIMES. THE VEHICLE COULD NOT BE REGISTERED SINCE IT WILL NOT PASS EMISSION. *JB (11/29/05) THE FRAME WAS TWISTED AND THE TORQUE CONVERTER FAILED. THERE WAS ALSO A HIT AND RUN ACCIDENT. ON ANOTHER OCCASION A TIRE HAD BLOWN OUT. THE CONSUMER WAS DENIED REIMBURSEMENT FOR THE TFI …
Read full complaint
THE CONSUMER REPLACED THE TRANSMISSION THREE TIMES. THE VEHICLE COULD NOT BE REGISTERED SINCE IT WILL NOT PASS EMISSION. *JB (11/29/05) THE FRAME WAS TWISTED AND THE TORQUE CONVERTER FAILED. THERE WAS ALSO A HIT AND RUN ACCIDENT. ON ANOTHER OCCASION A TIRE HAD BLOWN OUT. THE CONSUMER WAS DENIED REIMBURSEMENT FOR THE TFI MODULE REPLACEMENTS. *SC
NHTSA ODI #10101533
Mileage unknown · Sep 17, 2004
Structure
1999 FORD TAURUS WARNING.*MR WHILE DRIVING THE WIND FROM OTHER VEHICLE'S MADE THE CONSUMER'S VEHICLE SHAKE VIOLENTLY ALMOST TO THE POINT OF LOSING CONTROL. *NM
NHTSA ODI #10092783
Mileage unknown · Aug 11, 2004
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
VARIOUS PROBLEMS INVOLVING 1999 FORD TAURUS STATION WAGON.*MR THE POWER STEERING MADE EXCESSIVE NOISE, DEALER REPLACED THE STEERING RACK. THE VEHICLE FRONT END WAS OUT OF ALIGNMENT. THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER REPLACED SEVERAL COMPONENTS TO CORRECT THIS OCCURRENCE. THE TECHNICIAN REMOVED AN…
Read full complaint
VARIOUS PROBLEMS INVOLVING 1999 FORD TAURUS STATION WAGON.*MR THE POWER STEERING MADE EXCESSIVE NOISE, DEALER REPLACED THE STEERING RACK. THE VEHICLE FRONT END WAS OUT OF ALIGNMENT. THE CHECK ENGINE LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER REPLACED SEVERAL COMPONENTS TO CORRECT THIS OCCURRENCE. THE TECHNICIAN REMOVED AND REPLACED #1 COIL, REPLACED THE SPARK PLUGS, CLEARED ALL THE CODES AND THEN THE VEHICLE RAN FINE. THE FRONT AND REAR BRAKES WERE REPLACED AND THE ROTORS MACHINED. THE TEMPERATURE GAUGE MALFUNCTIONED. THE TECHNICIAN REPLACED THE FREEZE OUT PLUG AND THERMOSTAT. WINDSHIELD WASHERS FAILED. THE VEHICLE STEERING WHEEL WAS LOOSE. THE TECHNICIAN INDICATED THAT THE VEHICLE NEEDED FRONT AND REAR STRUTS, SWAY BAR LINKS AND REAR SUBFRAME BUSHING. WHEN ACCELERATING THE VEHICLE'S TRANSMISSION SLIPPED AND ON COLD START REVERSE JERKS INTO GEAR, DEALER REPLACED THE TRANS UNIT. THE D/S DOOR RUBBER ON THE BOTTOM OF THE DOOR WAS COMING OFF. D/S SEAT BELT WOULD NOT RETRACT. ANTIFREEZE WAS LEAKING IN OUT THE REAR BLOCK. *NM
NHTSA ODI #10087685
27,430 miles · Nov 4, 2003
Electrical SystemEquipmentFuel System, Gasoline
1999 FORD TAURUS IS SUFFERING FROM ELECTRICAL PROBLEMS. *MR THE VEHICLE WOULD SHUT OFF WITH NO WARNING, THE LOCKS ON BOTH DOORS WERE OFF AND WOULD HAVE TO BE PLAYED WITH TO GET THEM TO OPEN AT TIMES, THE HEADLIGHTS WERE INOPERATIVE, ALSO THE DASH LIGHTS WERE INOPERATIVE BEHIND THE GAS GAUGE/RADIO/HEATING/AC/CLOCK/AND SPEEDOM…
Read full complaint
1999 FORD TAURUS IS SUFFERING FROM ELECTRICAL PROBLEMS. *MR THE VEHICLE WOULD SHUT OFF WITH NO WARNING, THE LOCKS ON BOTH DOORS WERE OFF AND WOULD HAVE TO BE PLAYED WITH TO GET THEM TO OPEN AT TIMES, THE HEADLIGHTS WERE INOPERATIVE, ALSO THE DASH LIGHTS WERE INOPERATIVE BEHIND THE GAS GAUGE/RADIO/HEATING/AC/CLOCK/AND SPEEDOMETER, THE RPM GAUGE WAS DELAYED AT START, THE PASSENGER DOOR MADE NOISES WHEN OPENED AND CLOSED, THE WIPERS WERE INTERMITTENT, THE TURN SIGNALS WERE INTERMITTENT, THE BRAKE LIGHT HAD COME ON, THE VEHICLE WOULD NOT START IN THE MORNING BUT WOULD START AT NIGHT, THE VEHICLE WAS SLUGGISH AND HAD POOR GAS MILEAGE. THE VEHICLE WAS TAKEN IN DUE TO DEFECTIVE RELAYS WHICH WERE REPLACED. THE VIN# ON THE VEHICLE AND THE VIN# ON THE STICKER WERE DIFFERENT. *SCC *JB
NHTSA ODI #10046672
Mileage unknown · Mar 15, 2002
Engine And Engine CoolingStructure
CONSUMER NOTICED GAS LEAKING FROM VEHICLE. TOOK VEHICLE TO DEALER WHO REPLACED CANISTER AND VENT SOLENOID ASSEMBLY. THIS WAS SECOND TIME THIS PROBLEM WAS REPAIRED.*AK CONSUMER STATES THAT VEHICLE HAD A TRUNK LEAK. *TT
NHTSA ODI #8005743
Mileage unknown · Aug 30, 2000
Electrical SystemStructureVisibility
MALFUNCTION OCCURRED WITHIN THE ELECTRICAL SYSTEM WHICH CAUSED POWER WINDOWS AND POWER LOCKS TO OPERATE ERRACTICALLY. PLEASE GIVE ANY FURTHER DETAILS.*AK
NHTSA ODI #869122
Mileage unknown · Jun 20, 2000
Air BagsSeat BeltsSeatsCrashInjury
CONSUMER HAD A FRONT END COLLISON AND AIR BAGS DID NOT DEPLOY. DRIVER/PASSENGER SUSTAINED INJURIES. *AK AT THE TIME OF FRONT END COLLISION THE HOOD CAME IN THROUGH WINDSHEILD ON RIGHT SIDE. SEAT BELT FAILED IN REAR WHICH IS HOLDING CHILD'S SEAT. BACK REST ON LEFT BACK SEAT CAME LOOSE. *YH
NHTSA ODI #863886
Mileage unknown · Mar 15, 2000
StructureVisibility
VEHICLE IS EMMITING A ODOR FROM THE HEATING/AIR CONDITIONING SYSTEM WHICH MAKES IT HARD FOR PASSENGERS TO BREATH. NLM
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
1999 Ford Taurus Problems, Complaints & Recalls | Skip That Year
Illustration