NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
99 reportsClear category filter119,000 miles · Sep 5, 2007
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 30 MPH, THE BRAKE WARNING LIGHT ILLUMINATED AND THE STOPPING DISTANCE INCREASED. THE CONTACT NOTICED RUST ON THE REAR BRAKE LINE AS WELL AS BRAKE FLUID LEAKING. AS OF SEPTEMBER 5, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 119,00…
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 30 MPH, THE BRAKE WARNING LIGHT ILLUMINATED AND THE STOPPING DISTANCE INCREASED. THE CONTACT NOTICED RUST ON THE REAR BRAKE LINE AS WELL AS BRAKE FLUID LEAKING. AS OF SEPTEMBER 5, 2007, THE DEALER HAD NOT INSPECTED THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE 119,000.
NHTSA ODI #10201899
108,000 miles · Aug 8, 2007
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 15 MPH THE CONSUMERS DAUGHTER DEPRESSED THE BRAKES AND THE VEHICLE FAILED TO STOP. SHE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE MECHANIC AND HE STATED THAT THE BRAKE LINES WERE RUSTED. THE FAILURE AND CURRENT MILEAGES WERE 118,000. …
Read full complaint
TL*THE CONTACT OWNS A 1999 FORD TAURUS. WHILE DRIVING 15 MPH THE CONSUMERS DAUGHTER DEPRESSED THE BRAKES AND THE VEHICLE FAILED TO STOP. SHE HAD TO USE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE MECHANIC AND HE STATED THAT THE BRAKE LINES WERE RUSTED. THE FAILURE AND CURRENT MILEAGES WERE 118,000. UPDATED 02-01-08. *KB THE CONSUMER STATED THE BRAKE LINES HAD RUSTED. UPDATED
NHTSA ODI #10198873
Mileage unknown · Jul 19, 2007
Service Brakes, Hydraulic
MY 1999 FORD TAURUS BRAKE LINE CORRODED AND FELL INTO PIECES. THIS METAL LINE SHOULD NOT HAVE HAD THIS PROBLEM. THE METAL ALLOY IN THIS LINE IS AT FAULT AND SHOULD BE RECALLED OR WARRANTY DUE TO THE SEVERELY DANGEROUS OUTCOME. MY 16 YEAR OLD PULLED THE CAR INTO THE DRIVEWAY WHEN THE LINE LITERALLY BLEW AND ALL OF THE FLUID BL…
Read full complaint
MY 1999 FORD TAURUS BRAKE LINE CORRODED AND FELL INTO PIECES. THIS METAL LINE SHOULD NOT HAVE HAD THIS PROBLEM. THE METAL ALLOY IN THIS LINE IS AT FAULT AND SHOULD BE RECALLED OR WARRANTY DUE TO THE SEVERELY DANGEROUS OUTCOME. MY 16 YEAR OLD PULLED THE CAR INTO THE DRIVEWAY WHEN THE LINE LITERALLY BLEW AND ALL OF THE FLUID BLEW OUT. IT WAS A MIRACLE THAT THIS DID NOT OCCUR ANY OTHER TIME WHILE DRIVING BECAUSE THERE IS NO PEDAL BRAKING AT ALL! *TR
NHTSA ODI #10196796
97,000 miles · Mar 7, 2007
Service Brakes, HydraulicVehicle Speed Control
TL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WAS IDLING HIGH. THIS CONFIRMED THAT THE CRUISE CONTROL WAS OFF. THE CONTACT ENGAGED THE BRAKES. HOWEVER, THE HIGH IDLE CONTINUED TO OCCUR. WHEN THE CONTACT ATTEMPTED TO STOP THE VEHICLE STALLED AND THE BRAKES FAILED. THE CURRENT AND FAILURE MILEA…
Read full complaint
TL* THE CONTACT OWNS A 1999 FORD TAURUS. THE CONTACT STATED THAT THE VEHICLE WAS IDLING HIGH. THIS CONFIRMED THAT THE CRUISE CONTROL WAS OFF. THE CONTACT ENGAGED THE BRAKES. HOWEVER, THE HIGH IDLE CONTINUED TO OCCUR. WHEN THE CONTACT ATTEMPTED TO STOP THE VEHICLE STALLED AND THE BRAKES FAILED. THE CURRENT AND FAILURE MILEAGE WAS 97,000 MILES. *AK
NHTSA ODI #10184454
114,000 miles · Feb 11, 2007
Service Brakes, Hydraulic
WE HAD A TOTAL BRAKE FAILURE ON OUR 1999 FORD TAURUS, WE DROVE OUT OF OUR DRIVE WAY GOING TO THE MAIL BOX AND WHEN WE HIT THE BRAKES THE BRAKE FAILURE LIGHT CAME ON AS THE BRAKES WENT TO THE FLOOR AND THE CAR COASTED TO A STOP. IF WE HAD BEEN GOING FASTER IT WOULD HAVE BEEN VERY SERIOUS. THE PROBLEM WAS THAT THE BRAKE LINE TO T…
Read full complaint
WE HAD A TOTAL BRAKE FAILURE ON OUR 1999 FORD TAURUS, WE DROVE OUT OF OUR DRIVE WAY GOING TO THE MAIL BOX AND WHEN WE HIT THE BRAKES THE BRAKE FAILURE LIGHT CAME ON AS THE BRAKES WENT TO THE FLOOR AND THE CAR COASTED TO A STOP. IF WE HAD BEEN GOING FASTER IT WOULD HAVE BEEN VERY SERIOUS. THE PROBLEM WAS THAT THE BRAKE LINE TO THE BACK BRAKES SPLIT AND LEAKED ALL THE FLUID WHICH LED TO THE FAILURE, ARE THESE CARS SUPPOSED TO HAVE A BACK UP SYSTEMS?*JB
NHTSA ODI #10182252
46,200 miles · Jan 21, 2007
Service Brakes, Hydraulic
MY WIFE RECENTLY EXPERIENCED A TOTAL BRAKE FAILURE ON MY 99 TAURUS WAGON (46K MILES). SHE WAS STARTING OUT OF HER PARKING SPACE SO THERE WAS NO COLLISION. THIS SHOULD NOT HAVE HAPPENED AS THIS VEHICLE HAS A DUAL DIAGONAL SYSTEM FOR SAFETY. UNFORTUNATELY THE DIAGONAL PART IS WHAT DID IT IN AS THE TWO LINES RUNNING TO THE REAR…
Read full complaint
MY WIFE RECENTLY EXPERIENCED A TOTAL BRAKE FAILURE ON MY 99 TAURUS WAGON (46K MILES). SHE WAS STARTING OUT OF HER PARKING SPACE SO THERE WAS NO COLLISION. THIS SHOULD NOT HAVE HAPPENED AS THIS VEHICLE HAS A DUAL DIAGONAL SYSTEM FOR SAFETY. UNFORTUNATELY THE DIAGONAL PART IS WHAT DID IT IN AS THE TWO LINES RUNNING TO THE REAR WHEELS WERE RUN TOGETHER AND BOTH ROTTED OUT SIMULTANEOUSLY. *NM
NHTSA ODI #10179280
65,472 miles · Nov 23, 2006
Service Brakes, Hydraulic
MY WIFE WAS PULLING UP TO PICK UP FOR HER PRESCRIPTION WHEN SHE APPLIED THE BRAKE IT FAILED. STEEL BRAKE LINE FAILURE. 18 FOOT OF STEEL BRAKE LINE WAS REPLACED. *JB
NHTSA ODI #10174120
128,000 miles · Aug 29, 2006
Service Brakes, Hydraulic
CONSUMER FELT A POP IN THE BRAKES ON HIS 1999 FORD TAURUS. UPON INSPECTION MECHANIC DETERMINED THAT THE BRAKE LINE HAD FAILED DUE TO CORROSION AND THE PASSENGER SIDE ALSO NEEDED REPLACEMENT. *KB *JB
NHTSA ODI #10168003
120,000 miles · Jun 5, 2006
Service Brakes, Hydraulic
TOTAL BRAKE SYSTEM FAILURE I WAS DRIVING THE VEHICLE AT MEDIUM SPEED, AND PRESSED THE BRAKES TO SLOW DOWN AT THE CURVE. TO MY HORROR THE BRAKE PEDAL WENT DOWN ALL THE WAY WITHOUT SLOWING THE CAR AT ALL. THERE WAS NO BRAKE WARNING LIGHT. THE BRAKES CAME BACK BRIEFLY AFTER PRESSING A FEW TIMES, BUT WENT OFF AGAIN AT THE NEXT STOP…
Read full complaint
TOTAL BRAKE SYSTEM FAILURE I WAS DRIVING THE VEHICLE AT MEDIUM SPEED, AND PRESSED THE BRAKES TO SLOW DOWN AT THE CURVE. TO MY HORROR THE BRAKE PEDAL WENT DOWN ALL THE WAY WITHOUT SLOWING THE CAR AT ALL. THERE WAS NO BRAKE WARNING LIGHT. THE BRAKES CAME BACK BRIEFLY AFTER PRESSING A FEW TIMES, BUT WENT OFF AGAIN AT THE NEXT STOP LIGHT. THE CAR RAN THROUGH A RED LIGHT, BUT FORTUNATELY THERE WAS NO CROSS TRAFFIC. I PULLED OVER SLOWING IT DOWN AND PUT IT INTO PARK. WE GOT THE CAR TOWED TO THE NEAREST BRAKES REPAIR SHOP. THE MECHANIC HAS INFORMED US THAT THE CAUSE IS AN "INTERNAL LEAK IN THE MASTER CYLINDER". *JB
NHTSA ODI #10159043
60,001 miles · Dec 16, 2005
Service Brakes, Hydraulic
ON DEC. 14, 2005, WITH 60,001 MILES, THE VEHICLES SERVICE (HYDRAULIC) BRAKE SYSTEM FAILED. FULLERTON FORD OF SOMERVILLE, NJ EVALUATED THE VEHICLE, AND FOUND THAT A BADLY RUSTED STEEL BRAKE FLUID TUBE (WHICH FEEDS FLUID TO THE REAR BRAKES) HAD RUPTURED. GIVEN THE CARS LOW MILEAGE, RELATIVELY YOUNG AGE AND THE FACT THAT THIS TY…
Read full complaint
ON DEC. 14, 2005, WITH 60,001 MILES, THE VEHICLES SERVICE (HYDRAULIC) BRAKE SYSTEM FAILED. FULLERTON FORD OF SOMERVILLE, NJ EVALUATED THE VEHICLE, AND FOUND THAT A BADLY RUSTED STEEL BRAKE FLUID TUBE (WHICH FEEDS FLUID TO THE REAR BRAKES) HAD RUPTURED. GIVEN THE CARS LOW MILEAGE, RELATIVELY YOUNG AGE AND THE FACT THAT THIS TYPE OF FAILURE COULD LEAD TO A CATASTROPHIC ACCIDENT, I FEEL IT INDICATES SUBSTANDARD MATERIALS USED IN THE CARS MANUFACTURE AND SHOULD REQUIRE A RECALL AND PARTS REPLACEMENT AT FORD'S EXPENSE. *JB
NHTSA ODI #10145455
Official recalls
5Jul 15, 2004
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Sep 20, 1999
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
Nov 9, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
Sep 1, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
Aug 25, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Illustration