PASSENGER SAFETY BELT, IN BACK SEAT WILL NOT RETRACT. WENT TO MY FORD DEALER TO HAVE THEM REPLACE IT UNDER MY EXTENDED WARRANTY, BUT THEY SAID "NORMAL". THIS BELT NEVER RETRACTS LIKE THE OTHERS AND OFTEN THE DOOR GETS SHUT ON IT. DISCOVERED LATER THAT THERE WAS A RECALL FOR THESE BACK SEAT BELTS, BUT THE BELT'S DATE OF MANUFA…
Read full complaint
PASSENGER SAFETY BELT, IN BACK SEAT WILL NOT RETRACT. WENT TO MY FORD DEALER TO HAVE THEM REPLACE IT UNDER MY EXTENDED WARRANTY, BUT THEY SAID "NORMAL". THIS BELT NEVER RETRACTS LIKE THE OTHERS AND OFTEN THE DOOR GETS SHUT ON IT. DISCOVERED LATER THAT THERE WAS A RECALL FOR THESE BACK SEAT BELTS, BUT THE BELT'S DATE OF MANUFACTURE NOT IN THE RANGE FOR THE RECALL. *AK
NHTSA ODI #10093011
2,200 miles · May 6, 2004
Seat Belts
SEAT BELTS WERE NOT WORKING PROPERLY. CONSUMER REPLACED THREE SEAT BELTS DUE TO MALFUNCTIONED RETRACTOR.*AK
NHTSA ODI #10072231
Mileage unknown · Apr 29, 2004
Seat Belts
SEATBELT PROBLEMS WITH 1999 FORD TAURUS. (NAR) *MR THE DRIVERS SEATBELT HAD BECOME UNLATCHED WHILE THE VEHICLE WAS IN MOTION. THE CONSUMER NOTICED THAT WHEN THE MALE SECTION WAS PLACED INTO THE BUCKLE SECTION, NO CLICKING AND OR LOCKING SOUND OCCURRED. *SC *JB *CB
NHTSA ODI #10073373
48,254 miles · Jan 15, 2004
Seat Belts
IN A 1999 FORD TAURUS SE, MY 6 YEAR OLD SON BECAME TRAPPED IN A SEAT BELT THAT WAS NOT EVEN BUCKLED. AFTER ARRIVING HOME AT 9 P.M. MY SON HAD JUST UNBUCKLED HIS SEAT BELT WHEN SOMEHOW HE PULLED THE SEAT BELT OVER HIM AND THE SEAT BELT WRAPPED AROUND HIM AND IT WAS AROUND HIS WAIST AND BACK. THE SEAT BELT JUST KEPT GETTING TIGHTE…
Read full complaint
IN A 1999 FORD TAURUS SE, MY 6 YEAR OLD SON BECAME TRAPPED IN A SEAT BELT THAT WAS NOT EVEN BUCKLED. AFTER ARRIVING HOME AT 9 P.M. MY SON HAD JUST UNBUCKLED HIS SEAT BELT WHEN SOMEHOW HE PULLED THE SEAT BELT OVER HIM AND THE SEAT BELT WRAPPED AROUND HIM AND IT WAS AROUND HIS WAIST AND BACK. THE SEAT BELT JUST KEPT GETTING TIGHTER ON HIM AND WOULD NOT RELEASE JUST LIKE A COWBOYS LASOE. ANY SLACK I COULD GET WAS GOING UP IN THE SHOULDER RESTAINT. THE BELT WOULD NOT GIVE ME ANY SLACK. THIS WAS IN THE REAR SEAT ON THE DRIVERS SIDE. AFTER IT GOT SO TIGHT THAT MY SON WAS CRYING IN PAIN AND PANIC, I FINALLY HAD TO CUT THE SEAT BELT TO FREE MY SON. MY COMPLAINT IS THAT THIS SHOULD HAVE NEVER HAPPENED. WHY IS THERE NO SLACK GIVEN ON THE SEAT BELT ESPECIALLY IN A PARKED CAR. THE BELT SHOULD NOT KEEP LOCKING AND TAKING UP SLACK. THIS IS AN UNSEEN DANGER LURKING THAT COULD ENTRAP A CHILD. THE BELT WILL ENTRAP A CHILD WITHOUT BEING SECURED IN THE BUCKLE. BEWARE!!
NHTSA ODI #10070629
48,254 miles · Aug 10, 2003
Seat Belts
IN A 1999 FORD TAURUS SE, MY 6 YEAR OLD SON BECAME TRAPPED IN A SEAT BELT THAT WAS NOT EVEN BUCKLED. AFTER ARRIVING HOME AT 9 P.M. MY SON HAD JUST UNBUCKLED HIS SEAT BELT WHEN SOMEHOW HE PULLED THE SEAT BELT OVER HIM AND THE SEAT BELT WRAPPED AROUND HIM AND IT WAS AROUND HIS WAIST AND BACK. THE SEAT BELT JUST KEPT GETTING TIGHT…
Read full complaint
IN A 1999 FORD TAURUS SE, MY 6 YEAR OLD SON BECAME TRAPPED IN A SEAT BELT THAT WAS NOT EVEN BUCKLED. AFTER ARRIVING HOME AT 9 P.M. MY SON HAD JUST UNBUCKLED HIS SEAT BELT WHEN SOMEHOW HE PULLED THE SEAT BELT OVER HIM AND THE SEAT BELT WRAPPED AROUND HIM AND IT WAS AROUND HIS WAIST AND BACK. THE SEAT BELT JUST KEPT GETTING TIGHTER ON HIM AND WOULD NOT RELEASE JUST LIKE A COWBOYS LASOE. ANY SLACK I COULD GET WAS GOING UP IN THE SHOULDER RESTRAINT. THE BELT WOULD NOT GIVE ME ANY SLACK. THIS WAS IN THE REAR SEAT ON THE DRIVERS SIDE. AFTER IT GOT SO TIGHT THAT MY SON WAS CRYING IN PAIN AND PANIC, I FINALLY HAD TO CUT THE SEAT BELT TO FREE MY SON. MY COMPLAINT IS THAT THIS SHOULD HAVE NEVER HAPPENED. WHY IS THERE NO SLACK GIVEN ON THE SEAT BELT ESPECIALLY IN A PARKED CAR. THE BELT SHOULD NOT KEEP LOCKING AND TAKING UP SLACK. THIS IS AN UNSEEN DANGER LURKING THAT COULD ENTRAP A CHILD. THE BELT WILL ENTRAP A CHILD WITHOUT BEING SECURED IN THE BUCKLE. BEWARE!! *NLM
NHTSA ODI #10031188
50,000 miles · Jul 30, 2003
Seat Belts
VEHICLE'S REAR SEAT BELTS ARE INOPERATIVE, THEY WOULD RETRACT OR PULL OUT.
NHTSA ODI #10031608
23,561 miles · Apr 7, 2003
Seat Belts
THE SEAT BELT DID NOT RETRACT PROPERLY. THE DEALER WAS NOTIFIED.*NLM THE SEAT BELT AND RETRACTOR WAS REPLACED ON APRIL 19, 2001, HOWEVER IT FAILED, AT 59986 THE SEAT BELT AND RETRACTOR FAILED AGAIN. THE DEALER INFORMED CONSUMER THE RETRACTOR COULD BREAK EASILY IF THE SEAT BELT WAS PULLED TOO FAST. *JB
NHTSA ODI #10015349
50,000 miles · Feb 19, 2003
Seat Belts
REAR SEATBELT DIFFICULT TO LATCH WTIH CHILD SEAT / BOOSTER SEAT PRESENT. WHEN USING A CHILD SAFETY SEAT WITH BUILD IN STRAPS IN COMBINATION WITH THE CENTER REAR SEAT LAPBELT WITH OPTIONAL STUD MOUNTED ON STRAP FOR SHOULDER BELT ATTACHMENT, THIS FLAW IS NOT THAT EVIDENT. ALTHOUGH, AS THE CHILD PROGRESSES INTO THE BOOSTER SE…
Read full complaint
REAR SEATBELT DIFFICULT TO LATCH WTIH CHILD SEAT / BOOSTER SEAT PRESENT. WHEN USING A CHILD SAFETY SEAT WITH BUILD IN STRAPS IN COMBINATION WITH THE CENTER REAR SEAT LAPBELT WITH OPTIONAL STUD MOUNTED ON STRAP FOR SHOULDER BELT ATTACHMENT, THIS FLAW IS NOT THAT EVIDENT. ALTHOUGH, AS THE CHILD PROGRESSES INTO THE BOOSTER SEAT STAGE AND HAS OUTGROWN THE WEIGHT OF THE CHILD SEAT SAFETY STAPS, THE USE OF A BOOSTER SEAT IN THE CENTER REAR WITH COMBINATION LAP BELT BECOMES VERY DIFFICULT TO LATCH. THE ACT OF LATCHING THE SEATBELT CAN RANGE FROM FIRST TRY TO 20 OR 30 ATTEMPTS BEFORE IT LATCHES. MULTIPLE FEMALE SEAT BELT RECEPTICLES WHERE USED, SAME EFFECT ON ALL. IT APPEARS THAT THE DEATCHABLE SHOULD BELT ASSEMBLY HAS A RATHER LARGE METAL BUCKLE THAT HAS SUCH A LARGE AREA THAT IT PREVENTS THE ENTIRE ASSEMBLE FROM ALLOWING ENOUGH OF THE SEAT BELT SLOT TO ENTER THE RECEPTIBLE FOR THE EVIDENT CLICK. IF CAR IS NOT TAKEN, THE CAR SEAT MAY INADVERTANTLY BE LEFT UNBELTED IF THE CLICK IS NOT HEARD. ONCE THE BUCKLE DOES PERFORM THE "CLICK" IT APPEARS TO BE SECURE, BUT AS A DRIVER I CONSTANTLY WORRY ABOUT THE INTEGRITY OF THAT BELT ASSEMBLY. THIS PROBLEM APPEAR TO SHOW MORE OFTEN DURING COLDER WINTER MONTHS. 40F AND BELOW.
NHTSA ODI #10007775
69,434 miles · Feb 11, 2003
Seat Belts
THE SEAT BELTS WERE INOPERATIVE. *JB THE FRONT SEAT BELTS DID NOT RETRACT. THEY WERE WORN OUT AND REPLACED. SCC
NHTSA ODI #10006960
Mileage unknown · Jan 22, 2003
Seat Belts
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE SEAT BELTS. DEALER AND MANUFACTURE WAS CONTACTED AND STATED THAT NO WARRANTY COVER THE SEAT BELTS AT ALL. TS
ON CERTAIN PASSENGER VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, THE FRONT COIL SPRINGS COULD FRACTURE DUE TO CORROSION ASSOCIATED WITH SALT USED ON THE ROADWAYS DURING THE WINTER. A FRACTURED SPRING COULD MOVE PAST THE SPRING SEAT AND CONTACT A FRONT TIRE.
Consequence & remedy
Consequence: IF THIS OCCURS, THE TIRE MAY RUPTURE RESULTING IN A RAPID AIR LOSS, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSTALL PROTECTIVE SPRING SHIELDS. IN ADDITION, FORD IS EXTENDING THE WARRANTY COVERAGE OF THE FRONT COIL SPRINGS IN ALL OTHER STATES, FOR FRACTURE ONLY, UP TO 10 YEARS OF SERVICE OR 150,000 MILES, WHICHEVER OCCURS FIRST. IF THE VEHICLE HAS ALREADY ACCUMULATED MORE THAN 150,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2005. IF EITHER FRONT COIL SPRING FRACTURES, DEALERS WILL REPLACE BOTH FRONT SPRINGS AT NO CHARGE TO THE OWNER. AN INTERIM NOTICE WAS SENT TO OWNERS ON AUGUST 2, 2004. PARTS ARE NOW AVAILABLE FOR THE 2000-2001 MY VEHICLES AND OWNERS WERE SENT A LETTER ON JANUARY 10, 2005, ADVISING THEM TO BRING IN THEIR VEHICLES FOR REPAIR PARTS ARE EXPECTED TO BE AVAILABLE FOR THE 1999 MY VEHICLES BY THE END OF FEBRUARY 2005 AND OWNERS OF THESE VEHICLES WILL BE NOTIFIED THEN. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SEAT BELT RETRACTOR MAY HAVE A PIN SHAFT IN THE SWITCHABLE ELR/ALR MECHANISM THAT IS INCORRECTLY FORMED. IN SOME CIRCUMSTANCES, THE SWITCHING MECHANISM COULD BECOME NONFUNCTIONAL, PREVENTING THE SEAT BELT WEBBING FROM BEING EXTRACTED FROM THE RETRACTOR. IT IS ALSO POSSIBLE THAT MALFUNCTION OF THE MECHANISM COULD PREVENT THE BELT FROM BEING SWITCHED INTO THE ALR MODE. THE ELR MECHANISM IS NOT AFFECTED BY THIS CONDITION.
Consequence & remedy
Consequence: IF THE MECHANISM MALFUNCTIONS AND DOES NOT ALLOW THE WEBBING TO BE EXTRACTED, THE LAP AND SHOULDER BELT COULD NOT BE WORN BY A VEHICLE OCCUPANT. IN THE EVENT THAT THE MECHANISM DOES NOT ALLOW THE ALR MODE TO BE ENGAGED, THE OPERATOR MAY BE UNABLE TO PROPERLY INSTALL A CHILD SEAT IN THAT SEATING POSITION.
Remedy: DEALERS WILL INSPECT THE LAP AND SHOULDER BELT ASSEMBLIES. ASSEMBLIES WITH JULIAN DATE CODES OF 200 THROUGH 223 ARE SUSPECT AND WILL BE REPLACED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUPPED WITH THE "CALIFORNIA" EMISSIONS PACKAGE. AN INCORRECT TRANSMISSION OIL COOLER LINE WAS INSTALLED. THE LINE CONTACTS THE ANTI-LOCK BRAKING SYSTEM MODULE SUPPORT BRACKET AND OVER TIME, CAN WEAR AND DEVELOP A LEAK.
Consequence & remedy
Consequence: TRANSMISSION FLUID LEAKAGE ONTO THE EXHAUST MANIFOLD OR CATALYTIC CONVERTER CAN RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL THE APPROPRIATE TRANSMISSION OIL COOLER LINE.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. A DASH INSULATOR RETAINER CLIP WAS NOT FULLY ASSEMBLED TO THE ACCELERATOR CABLE DASH FITTING. THE CLIP CAN DISENGAGE FROM THE ACCELERATOR CABLE AND FALL INTO THE ACCELERATOR PEDAL ARM PIVOT AREA.
Consequence & remedy
Consequence: IF THIS CONDITION OCCURS, THE ENGINE MAY NOT FULLY RETURN TO IDLE. ALSO, THE INSULATOR MAY NOT STAY IN THE INTENDED LOCATION AND COULD INTERFERE WITH THE ACCELERATOR CABLE.
Remedy: DEALERS WILL INSPECT THESE VEHICLES TO ENSURE PROPER INSTALLATION OF THE ACCELERATOR CABLE CLIP, AND RE-INSTALL IF NEEDED.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL SEAT TRACKS. THE FRONT SEAT BELT BUCKLE ATTACHING STUD MAY HAVE BEEN IMPROPERLY HEAT TREATED. THIS HEAT TREATMENT MAY HAVE RESULTED IN CRACKS DEVELOPING IN THE STUD.
Consequence & remedy
Consequence: IF THE STUD IS CRACKED, IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE SEAT BELT BUCKLE MOUNTING BRACKET AND STUD ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
PE04044 · Front Suspension Coil Spring Fracture
Opened May 24, 2004 · Closed Aug 16, 2004
Status: closed (inferred from source dates) · Suspension:front; Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Additional source detail variants (2)
Suspension:front
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
Suspension:front:springs:coil Springs
ODI POSSESSES 130 VEHICLE OWNERS QUESTIONNAIRES (VOQ) ALLEGING FRONT SUSPENSION COIL SPRING FAILURE IN THE SUBJECT (MODEL YEAR 1999-2000) VEHICLES.AN ADDITIONAL 11 VOQS CONCERNING MY 2001 VEHICLES HAVE BEEN FOUND, BRINGING THE TOTAL TO 141.MORE THAN 75% OF THESE REPORTS ALLEGE THAT THE BROKEN SPRING DAMAGED OR PUNCTURED THE ADJACENT TIRE.ALL OF THESE REPORTS ORIGINATED IN THE SALT BELT STATES LOCATED IN THE NORTHEAST QUADRANT OF THE UNITED STATES AND CANADA.FORD WILL CONDUCT A SAFETY RECALL (04V-332) COVERING VEHICLES SOLDOR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, TO INSTALL SPRING SHIELDS IN MY 1999-2001 TAURUS/SABLE VEHICLES TO PREVENT A FRACTURED SPRING FROM DAMAGING THE NEARBY TIRE.FORD WILL ADDITIONALLY NOTIFY OWNERS OF ALL MY 1999-2001 TAURUS/SABLE VEHICLES THAT WARRANTY COVERAGE FOR SPRING FRACTURES HAS BEEN EXTENDED TO 10 YEARS OF AGE OR 150,000 MILES.ODI ANALYZED FORD?S WARRANTY AND COMPLAINT DATA AND FOUND THAT 99% OF THE SPRING FRACTURES OCCURRED IN THE STATES COVERED BY THE RECALL.THE OTHER INCIDENTS OCCURRED IN THE STATES OF FLORIDA, NORTH CAROLINA, TEXAS, ALABAMA, AND GEORGIA.IN VIEW OF THE COVERAGE OF THE SPRING FAILURES BY THE RECALL CAMPAIGN, ODI IS CLOSING THE PRELIMINARY EVALUATION.ODI WILL CONTINUE TO MONITOR THE PERFORMANCE OF THE SUBJECT VEHICLES THROUGHOUT THE REMAINDER OF THE COUNTRY.
PE02080 · Front Suspension Coil Spring Fracture
Opened Oct 22, 2002 · Closed Apr 29, 2003
Status: closed (inferred from source dates) · Suspension; Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Additional source detail variants (2)
Suspension
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
Suspension:front:springs:coil Springs
A TOTAL OF 161 FRONT SUSPENSION SPRING FAILURES ARE KNOWN TO ODI AND FORD FROM ALL SOURCES, 59 OF THESE LEADING TO TIRE DAMAGE.THESE FAILURES ARE CONCENTRATED IN THE CORROSION STATES, WHERE 253,814 SUBJECT VEHICLES WERE SOLD.WARRANTY AND CONSUMER COMPLAINT DATA SHOW THAT THE SUBJECT FLEET EXPERIENCED A SPRING FRACTURE RATE OF 0.009% AT 30,000 MILES AND 0.03% AT 60,000 MILES.THESE RATES ARE VERY LOW WHEN COMPARED TO PREVIOUS INVESTIGATIONS OF COIL SPRING FRACTURE:RECALLED '93 TAURUS (EA97-026): 0.1% AT 30,000 MILES AND 0.34% AT 60,000 MILES; AND RECALLED '98 WINDSTAR (EA00-027): 0.11% AT 30,000 MILES AND 1.25% AT 60,000 MILES.THE SUBJECT VEHICLES ALSO EXPERIENCED FAILURE RATES SUBSTANTIALLY LOWER THAN THOSE OF COMPARABLE-AGED NON-RECALLED WINDSTARS SUBJECT TO EA00-027 (MY '95-'97).GIVEN THESE CIRCUMSTANCES, FURTHER EXPENDITURE OF AGENCY RESOURCES IS NOT JUSTIFIED IN THIS MATTER.THE PRELIMINARY EVALUATION IS THEREFORE CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY WILL TAKE FURTHER ACTION IN THE FUTURE IF CIRCUMSTANCES WARRANT.
1999 Ford Taurus Problems, Complaints & Recalls | Skip That Year
Illustration