NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
1,557 reportsMileage unknown · Dec 26, 1999
Engine And Engine Cooling
ENGINE HEAD GASKET BLEW AT 78,000. OUR MECHANIC TOLD US THIS SEEMS TO BE A CHRONIC PROBLEM ON 1993 AND 1994 3.8 L FORD TAURUS ENGINES. SEVERAL PEOPLE WE KNOW HAVE STATED THE SAME PROBLEMS WITH THIS ENGINE. THIS LEADS US TO BELIEVE THIS IS A DESIGN DEFECT. WHEN WE CONTACTED FORD CUSTOMER SERVICE, WE WERE INFORMED NO RECALL OR…
Read full complaint
ENGINE HEAD GASKET BLEW AT 78,000. OUR MECHANIC TOLD US THIS SEEMS TO BE A CHRONIC PROBLEM ON 1993 AND 1994 3.8 L FORD TAURUS ENGINES. SEVERAL PEOPLE WE KNOW HAVE STATED THE SAME PROBLEMS WITH THIS ENGINE. THIS LEADS US TO BELIEVE THIS IS A DESIGN DEFECT. WHEN WE CONTACTED FORD CUSTOMER SERVICE, WE WERE INFORMED NO RECALL OR EXTENDED SERVICE IS AVAIALABLE TO CORRECT THIS PROBLEM EVENTHOUGH THEY SAID IT IS NOT UNCOMMON. FORD CUSTOMER SERVICE STAFF DID TELL US IT IS UNUSUAL FOR A HEAD GASKET TO GO AT 78,000. FORD CUSTOMER SERVICE STAFF ALSO TOLD US THEIR EXTENDED WARRANTY PROGRAM OF 5 YEARS OR 60,000 MILES ONLY APPLIES TO 1995 VERSIONS OF THE 3.8 L ENGINE. OUR SECOND PROBLEM IS THAT OF THE RACK AND PINION. THE FRONT OF END OF THIS VEHICLE HAS HAD MANY PROBLEMS IN THE LAST TWO YEARS. THE FRONT COIL SPRINGS BROKE AND WERE EVENTUALLY COVERED UNDER A RECALL. HOWEVER, WE HAVE HAD TO REPLACE THE FRONT STRUTS, BALL JOINTS, TIE ROD ENDS, AND RACK AND PINION ON SEPERATE OCCASSIONS THROUGH 1998 (THE VEHICLE HAD ROUGHLY 65,000 MILES AT THIS TIME). WHILE WE WERE IN FOR THE LAST RECALL ON THE VEHICLE, THE FORD SERVICE DEPARTMENT ALSO TOLD US OUR ENGINE MOUNTS WERE RUSTING OUT AND WOULD NEED TO BE REPLACED. IT APPEARS THAT THE 1993 FORD TAURUS HAS A PROBLEM WITH THE DURABILITY OF THE FRONT END COMPONTS. *AK
NHTSA ODI #716463
Mileage unknown · Dec 21, 1999
Engine And Engine Cooling
WHILE DRIVING ON HIGHWAY ENGINE DIED/ LOST POWER STEERING AND BRAKES. PUTS CAR IN NEUTRAL, IT ALLOWED IT TO RESTART. THIS HAS HAPPENED SEVERAL TIMES A DAY. CONTACTED DEALER. HAS BEEN VERY COOPERATIVE, BUT NOT ABLE TO FIND THE CAUSE OF THE PROBLEM. *AK
NHTSA ODI #853228
Mileage unknown · Dec 21, 1999
Engine And Engine Cooling
FLYWHEEL ASSEMBLY AND FRONT COVER GASKETS FAILED. *SLC
NHTSA ODI #784368
Mileage unknown · Dec 16, 1999
Visibility
EA99023; WINDSHIELD WIPERS WORK INTERMITTENTLY, CAUSING POOR VISIBILITY IN BAD WEATHER CONDITIONS. DEALER CORRECTED PROBLEM. *YC
NHTSA ODI #852374
Mileage unknown · Dec 14, 1999
Engine And Engine CoolingPower TrainService Brakes, Hydraulic
RECALL (98V-323)REPAIR FOR THE ENGINE MOUNT WERE REPAIRED BUT ARE CURRENTLY FAILING AGAIN. *NLM
NHTSA ODI #549934
Mileage unknown · Dec 11, 1999
Service Brakes, Hydraulic
AFTER 30-45 MINUTES OF HIGHWAY DRIVING, THE BRAKE BOOSTER "STICKS" CAUSING THE BRAKE ROTORS TO WARP AND THE CAR TO VIBRATE SEVERELY, RESULTING IN A REDUCTION OF STEERING AND BRAKING EFFECTIVENESS. *AK
NHTSA ODI #715934
Mileage unknown · Dec 9, 1999
Suspension
LEFT FRONT SPRINGS FAILURE CAUSED THE WHEEL TO LOCK, RECALL ON THE SPRING (98V-094) HOWEVER VEHICLE DENIED DUE TO VIN #. YH
NHTSA ODI #549898
Mileage unknown · Dec 8, 1999
Visibility
WINDSHIELD WIPERS FAIL TO RETURN TO THEIR NORMAL RESTING PLACE, CAUSING OBSTRUCTION OF VIEW AND INAPPROPRIATE DRIVING CONDITION. THE VARIABLE SWITCH MECHANISM SEEMS TO BE INACCURATE AS WELL. THE INABILITY TO HAVE THE WIPERS RETURN TO THEIR RESTING POSITION WHICH IS BELOW SIGHT LEVEL ON THE WINDSHIELD POSES A SIGNIFICANT HAZARD…
Read full complaint
WINDSHIELD WIPERS FAIL TO RETURN TO THEIR NORMAL RESTING PLACE, CAUSING OBSTRUCTION OF VIEW AND INAPPROPRIATE DRIVING CONDITION. THE VARIABLE SWITCH MECHANISM SEEMS TO BE INACCURATE AS WELL. THE INABILITY TO HAVE THE WIPERS RETURN TO THEIR RESTING POSITION WHICH IS BELOW SIGHT LEVEL ON THE WINDSHIELD POSES A SIGNIFICANT HAZARD TO DRIVING AND POTENTIAL ACCIDENT SITUATION. *AK
NHTSA ODI #715798
Mileage unknown · Dec 6, 1999
Engine And Engine Cooling
I HAVE BEEN TOLD BY TWO DIFFERENT MECHANICS THAT A BLOWN HEAD GASKET ON A TAURUS IS A COMMON OCCURENCE. I WOULD APPRECIATE ANY INFORMATION YOU HAVE ON THIS MATTER. I WAS TOLD THAT THERE WAS A RECALL OR A WARRANTY, BUT THE DEALERS ARE TELLING ME I AM OUT OF WARRANTY. THE CAR ONLY HAS 27000 MI. ON IT. THANK YOU FOR ANY INFO YO…
Read full complaint
I HAVE BEEN TOLD BY TWO DIFFERENT MECHANICS THAT A BLOWN HEAD GASKET ON A TAURUS IS A COMMON OCCURENCE. I WOULD APPRECIATE ANY INFORMATION YOU HAVE ON THIS MATTER. I WAS TOLD THAT THERE WAS A RECALL OR A WARRANTY, BUT THE DEALERS ARE TELLING ME I AM OUT OF WARRANTY. THE CAR ONLY HAS 27000 MI. ON IT. THANK YOU FOR ANY INFO YOU CAN PROVIDE.
NHTSA ODI #715673
Mileage unknown · Dec 1, 1999
Engine And Engine Cooling
THE ENGINE PROBLEM IS A DESIGN PROBLEM AND SHOULD HAVE A RECALL FROM FORD MOTOR COMPANY. THERE ARE MANY, MANY MORE 3.8LITER ENGINES WITH THIS SAME PROBLEM, THE CONSUMER SHOULD NOT HAVE TO PAY FOR A DESIGN PROBLEM. *AK
NHTSA ODI #715477
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA97026 · Front Suspension Coil Spring Failure
Opened Nov 26, 1997 · Closed May 13, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Additional source detail variants (2)
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
PE97035 · Front Suspension Coil Spring Failure
Opened Jul 22, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration