NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
174 reportsClear category filterMileage unknown · May 6, 1999
Engine And Engine CoolingPower Train
SPEEDOMETER SYSTEM MALFUNCTIONED, CAUSING A CLICKING NOISE AND WHEN VEHICLE IS OPERATED ABOVE 50 MPH. SPEEDOMETER NEEDLE WILL MOVE UP AND DOWN, AND OCCUPANT CANNOT TELL HOW FAST THE VEHICLE IS GOING. DEALER REPLACED SPEEDOMETER ONCE. NEEDS TO REPLACE IT AGAIN. ALSO, PROBLEMS WITH HEAD GASKET WHICH WAS PART OF IMPROVEMEN…
Read full complaint
SPEEDOMETER SYSTEM MALFUNCTIONED, CAUSING A CLICKING NOISE AND WHEN VEHICLE IS OPERATED ABOVE 50 MPH. SPEEDOMETER NEEDLE WILL MOVE UP AND DOWN, AND OCCUPANT CANNOT TELL HOW FAST THE VEHICLE IS GOING. DEALER REPLACED SPEEDOMETER ONCE. NEEDS TO REPLACE IT AGAIN. ALSO, PROBLEMS WITH HEAD GASKET WHICH WAS PART OF IMPROVEMENT CAMPAIGN OF 1994 & 1995'S. PLEASE PROVIDE FURTHER INFORMATION.
NHTSA ODI #837536
Mileage unknown · Mar 29, 1999
Power TrainSuspension
TRANSMISSION: TAKEN TO AAMCO 8 TO 10 TIMES, TOLD IT NEEDED TO BE REBUILT. IT WAS REBUILT AT LEAST 5 TIMES SINCE THEN. OTHER TIMES THEY REPLACED ELECTRICAL COMPONENTS AND FIXED LEAKS. JUST HAD ANOTHER LEAK FIXED TWO WEEKS AGO AT ROBKE FORD DEALER IN COV., KY. TRANSMISSION STILL JERKS WHEN SHIFTING. REAR NOISE: SOUNDS LIKE COIL …
Read full complaint
TRANSMISSION: TAKEN TO AAMCO 8 TO 10 TIMES, TOLD IT NEEDED TO BE REBUILT. IT WAS REBUILT AT LEAST 5 TIMES SINCE THEN. OTHER TIMES THEY REPLACED ELECTRICAL COMPONENTS AND FIXED LEAKS. JUST HAD ANOTHER LEAK FIXED TWO WEEKS AGO AT ROBKE FORD DEALER IN COV., KY. TRANSMISSION STILL JERKS WHEN SHIFTING. REAR NOISE: SOUNDS LIKE COIL SPRING. I HAVE HAD NOTHING BUT DISSAPOINTMENT IN THIS VEHICLE, WILL NEVER BUY A FORD AGAIN!!!! THANK YOU. *AK
NHTSA ODI #705068
Mileage unknown · Mar 24, 1999
Power Train
GOING INTO PARKING LOT HEARD CRUNCHING SOUND, PARKED, CASLLED AAA, WAS TOWED TO SERVICE STATION. TRANSMISSION EXPLODED. *AK
NHTSA ODI #835118
Mileage unknown · Mar 22, 1999
Power TrainStructure
TRANSMISSION FAILED WITH NO WARNING. STOPPED AT INTERSECTION AND COULD NOT PROCEED FORWARD OR BACKWARD. MOTOR MOUNTS HAVE BEEN REPLACED TWICE IN THE PAST TWO YEARS. I SUSPECT THAT THE FAULTY MOTOR MOUNTS ARE ALSO THE CAUSE FOR THE TRANSMISSION. *AK
NHTSA ODI #704752
Mileage unknown · Jan 30, 1999
Power Train
FOUND OUT TRANSMISSION WAS RECALLED ON SOME OF THE 1993 TAURUSES BUT TOLD THAT OURS WAS NOT RECALLED BY QUALITY FORD IN INDEPENDECE KS. *AK
NHTSA ODI #702737
Mileage unknown · Jan 26, 1999
Power Train
WHILE DRIVING, A CRACKED PISTON CAUSED THE TRANSMISISON TO SUDDENLY DROP OUT OF GEAR INTO NEUTRAL AND STOP.
NHTSA ODI #543516
Mileage unknown · Jan 16, 1999
Power Train
NO SUMMARY
NHTSA ODI #702280
Mileage unknown · Jan 13, 1999
Power Train
VEHICLE HAD 3 TRANSMISSION REPLACMENTS/TWO TIMES BY DEALER, AND THIRD BY INDEPENDENT REPAIR SHOP. CONSUMER BELIEVES THIS CONDITION IS NOT NORMAL. CAN SOMEONE HELP CONSUMER IN THIS MATTER? *AK *ML
NHTSA ODI #833522
Mileage unknown · Jan 12, 1999
Power Train
WHEN DRIVING ON FREEWAY OR AT HIGH SPEEDS THE VEHICLE DOWNSHIFTS OR SHUTS OFF. THIS HAS HAPPENED 3 TIMES. DEALER HAS NOT SEEN. *AK
NHTSA ODI #833442
Mileage unknown · Jan 11, 1999
Engine And Engine CoolingPower Train
PROBLEM 1--ENGINE LIGHT KEPT COMING ON; TOOK TO DEALER AND READ CODES--O2 SENSOR FAILING AND TRANSMISSION SLIPPAGE. RE TRANSMISSION SLIPPAGE, DEALER ADVISED THAT HE WITNESSED SLIPPAGE AND WAS CRACKED PISTON IN TRANSMISSION; ADVISED ME THAT PROBLEM WAS COMMON BECAUSE PISTON WAS ALUMINUM AND ARE BEING REPLACED WITH STEEL PISTONS;…
Read full complaint
PROBLEM 1--ENGINE LIGHT KEPT COMING ON; TOOK TO DEALER AND READ CODES--O2 SENSOR FAILING AND TRANSMISSION SLIPPAGE. RE TRANSMISSION SLIPPAGE, DEALER ADVISED THAT HE WITNESSED SLIPPAGE AND WAS CRACKED PISTON IN TRANSMISSION; ADVISED ME THAT PROBLEM WAS COMMON BECAUSE PISTON WAS ALUMINUM AND ARE BEING REPLACED WITH STEEL PISTONS; NOW HAVING SEVERE PROBLEMS WITH HARSH ENGAGEMENTS; WAS TOLD TO DRIVE IT TILL COULDN'T DRIVE ANYMORE BEFORE REPAIR--IF PISTON SHOULD BE STEEL AND NOT ALUMINUM THAT PISTON IS DEFECTIVE AND THAT FORD SHOULD REPAIR AT THEIR COSTS. RE: ENGINE BOLT, HAD TO HAVE ENGINE MOUNT REPAIRED AT COST OF $350--INFO AT THIS SITE SUGGESTS RECALLL WHICH I NEVER RECEIVED. I SHOULD BE REIMBURSED FOR COST OF DEFECTIVE BOLT.
NHTSA ODI #702133
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA97026 · Front Suspension Coil Spring Failure
Opened Nov 26, 1997 · Closed May 13, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Additional source detail variants (2)
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
PE97035 · Front Suspension Coil Spring Failure
Opened Jul 22, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration