NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
156 reportsClear category filterMileage unknown · Nov 8, 2002
Electrical SystemEngine And Engine CoolingUnknown Or Other
I HAVE HAD NOTHING BUT PROBLEMS WITH THIS CAR. I HAVE ONLY OWNED IT FOR A YEAR AND 1/2, AND HAVE ALREADY PUT MORE MONEY IN TO IT THAN I WILL EVER GET OUT OF IT. I DO NOT RECOMMEND THIS CAR TO ANYONE! I WENT THROUGH IN A FOUR WEEK SPAN HAVING THE BRAKES GO OUT, THE MUFFLER FELL OFF. THE HEAD GASKETS BLEW, THE WATER PUMP BROKE …
Read full complaint
I HAVE HAD NOTHING BUT PROBLEMS WITH THIS CAR. I HAVE ONLY OWNED IT FOR A YEAR AND 1/2, AND HAVE ALREADY PUT MORE MONEY IN TO IT THAN I WILL EVER GET OUT OF IT. I DO NOT RECOMMEND THIS CAR TO ANYONE! I WENT THROUGH IN A FOUR WEEK SPAN HAVING THE BRAKES GO OUT, THE MUFFLER FELL OFF. THE HEAD GASKETS BLEW, THE WATER PUMP BROKE AND THE POWER STEERING PUMP WENT OUT. I HATE THIS CAR!! DT
NHTSA ODI #769468
Mileage unknown · Oct 4, 2002
Electrical System
CONSUMER STATES THAT WHILE DRIVING VEHICLE WILL SUDDENLY SHUT DOWN. PLEASEA PROVIDE ANY FURTHER INFORMATION. *MR
NHTSA ODI #8020228
Mileage unknown · Jul 26, 2002
Air BagsElectrical SystemVehicle Speed Control
WHILE TRAVELING ON HIGHWAY CONSUMER NOTICED THAT CRUISE CONTROL/ HORN AND AIRBAG WERE NOT OPERABLE. DEALERSHIP WAS AWARE OF PROBLEM.*AK
NHTSA ODI #8014913
Mileage unknown · Jul 25, 2002
Electrical SystemEngine And Engine CoolingExterior Lighting
HEADLIGHT WENT OUT WHILE DRIVING AT NIGHT, THEN CAME BACK ON. RECALL WAS DONE 2 YEARS AGO, DEALER REPLACED THE MULTI FUNCTION SWITCH.*JB CONSUMER ALSO STATED THE VEHICLE WOULD STALL, THE ELECTRICAL CONTROL BOX WAS REPLACED, AND THE CRUISE CONTROL HAS NOT WORKED FOR THE PAST 5 YEARS.*JB
NHTSA ODI #8014779
Mileage unknown · Jun 3, 2002
Electrical SystemEngine And Engine CoolingEquipment
VEHICLE STALLS OUT WHILE DRIVING. CONTACTED DEALER, HAD HEAD GASKET REPLACED. HOWEVER, PROBLEM REOCCURRED. HAD HEAD GASKET REPLACED AGAIN. *AK CONSUMER HAS BEEN ADVISED THAT THE ENTIRE ENGINE NEEDS TO BE REPLACED, THE PAN PLUG LEFT UNDONE CAUSING VEHICLE TO LOSE OIL, THE RADIATOR HAD TO BE REPLACED DUE TO OVER TORQUE BOLTS WH…
Read full complaint
VEHICLE STALLS OUT WHILE DRIVING. CONTACTED DEALER, HAD HEAD GASKET REPLACED. HOWEVER, PROBLEM REOCCURRED. HAD HEAD GASKET REPLACED AGAIN. *AK CONSUMER HAS BEEN ADVISED THAT THE ENTIRE ENGINE NEEDS TO BE REPLACED, THE PAN PLUG LEFT UNDONE CAUSING VEHICLE TO LOSE OIL, THE RADIATOR HAD TO BE REPLACED DUE TO OVER TORQUE BOLTS WHICH BURSTED AROUND THE CORE, THE ENGINE IS KNOCKING AND THE OIL LIGHT ILLUMINATED DUE TO LACK OF OIL. CONSUMER HAS LOST TRUST IN THE DEALERSHIP. HEAD LIGHTS FAILED, LIGHT SWITCH WAS REPLACED. THE WIPERS WERE NOISY, DEALER REPLACED THE MULTIFUNCTION SWITCH AND WIPER MOTOR. THERE IS A POPPING NOISE WHEN TURNING, THERE IS A RUBBING NOISE IN THE RIGHT FRONT ON TURNS AND WHEN BACKING UP. THE AIR CONDITIONER IS NOT BLOWING COLD AIR, SHRATER VALVE AND A/C REFRIGERANT WAS REPLACED. THE KEY SWITCH FAILED. THE FAULTY ANTENNA MOTOR FAILED. THE MASTER CYLINDER HAD TO BE REPLACED. TIE ROD WAS REPLACED. *TT
NHTSA ODI #8010926
Mileage unknown · May 28, 2002
Electrical SystemEngine And Engine Cooling
VEHICLE STALLS INTERMITTENTLY, MOSTLY BELOW 50 MPH. DEALER CANNOT FIND A CAUSE. *AK CONSUMER STATED THAT AFTER 12 MILES DRIVE, THE ENGINE BLEW AND A WHITE WHIPPED CRAM LIKE SUBSTANCE CAME OUT FROM UNDER THE HOOD. THE VEHICLE STALLS WHILE DRIVING AT LOW SPEEDS ALSO AT IDLE AND IT WAS HARD TO START DUE TO INTEGRATED CONTROL MODUL…
Read full complaint
VEHICLE STALLS INTERMITTENTLY, MOSTLY BELOW 50 MPH. DEALER CANNOT FIND A CAUSE. *AK CONSUMER STATED THAT AFTER 12 MILES DRIVE, THE ENGINE BLEW AND A WHITE WHIPPED CRAM LIKE SUBSTANCE CAME OUT FROM UNDER THE HOOD. THE VEHICLE STALLS WHILE DRIVING AT LOW SPEEDS ALSO AT IDLE AND IT WAS HARD TO START DUE TO INTEGRATED CONTROL MODULE RELAY FAILURE. THE CHECK ENGINE LIGHT CAME ON BECAUSE O2 SENSOR WAS DAMAGED FROM COOLANT CONTAMINATION. THE VEHICLE SMELLS OF COOLANT DUE TO RADIATOR LEAK. *YH
NHTSA ODI #8010568
Mileage unknown · Apr 25, 2002
Electrical System
VEHICLE STALLED AT 30 MPH, AND WOULD NOT RESTART FOR A FEW HOURS. DEALER REPLACED CONTROL MODULE. *AK
NHTSA ODI #8008623
Mileage unknown · Jan 27, 2002
Electrical System
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #757397
Mileage unknown · Jan 24, 2002
Electrical System
WHILE DRIVING 65 MPH AND WITHOUT ANY INDICATION VEHICLE STALLS, VEHICLE WAS SERVICED, AND IGNITION SWITCH WAS REPLACED. *AK CONSUMER STATES THAT WHEN VEHICLE STALLED THE STEERING WENT DEAD. *YD
NHTSA ODI #8002760
Mileage unknown · Dec 17, 2001
Electrical SystemSteeringFire
WIRING HARNESS CAUGHT ON FIRE, CAUSING ELECTRICAL SYSTEM TO MALFUNCTION. DEALER HAS YET TO BE CONTACTED. *AK CONSUMER STATED SHE AND DAUGHTER WERE TRAPPED INT HE VEHICLE, CONSUMER ALSO STATED THE STEERING LOCKED UP.*SLC
NHTSA ODI #8000796
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA97026 · Front Suspension Coil Spring Failure
Opened Nov 26, 1997 · Closed May 13, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Additional source detail variants (2)
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
PE97035 · Front Suspension Coil Spring Failure
Opened Jul 22, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration