NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
156 reportsClear category filter59,630 miles · Jul 29, 2008
Electrical System
I BOUGHT MY 1993 FORD TAURUS 3 MONTHS AGO..IT HAS 59K ON IT...ONE WEEK AFTER BUYING IT CHECK ENGINE LIGHT CAME ON..WHEN I APPROACHED THE DEALERSHIP THERE COMMENT WAS.."WELL THINGS GO WRONG DAILY WITH USED CARS..I DRIVE THE CAR FOR ABOUT 10 MINUTES THEN THE LIGHT WILL COME ON. I HAVE CHANGED ALL THE SENSORS..HAD A TUNE UP..RADIAT…
Read full complaint
I BOUGHT MY 1993 FORD TAURUS 3 MONTHS AGO..IT HAS 59K ON IT...ONE WEEK AFTER BUYING IT CHECK ENGINE LIGHT CAME ON..WHEN I APPROACHED THE DEALERSHIP THERE COMMENT WAS.."WELL THINGS GO WRONG DAILY WITH USED CARS..I DRIVE THE CAR FOR ABOUT 10 MINUTES THEN THE LIGHT WILL COME ON. I HAVE CHANGED ALL THE SENSORS..HAD A TUNE UP..RADIATOR FLUSH..JUST TO MENTION A FEW THINGS...HAD NEW MOTOR MOUNTS PUT IN TOO..ALL OF WHICH HAS COST ME WELL OVER 700.00...I CALLED FORD WHEN I NOTICED THEY HAD A RECALL ON THE ELECTRICAL IN WHICH I WAS INFORMED THEY WOULDN'T DO A THING..I CAN ONLY DRIVE THIS CAR FOR SHORT PERIODS OF TIME BEFORE THE ENGINE STARTS SMELLING HOT..THOUGH WITH THE NEW THERMOSTAT IT NEVER REGISTERS ITS OVER HEATING..TOOK IT TO MY MECHANIC AND HAD A COMPUTER CHECK DONE..BUT WOULDN'T U KNOW LIGHT WOULDN'T COME ON SINCE IT WAS JUST SITTING. SEEMS IT ONLY COMES ON WHEN DRIVING DOWN THE ROAD..AGAIN TOLD THE DEALERSHIP...THEY KEEP SAYING MUST BE A CENSOR..WHICH SEEMS TO ME THEY KNEW THIS WHEN THE CAR WAS SOLD TO ME..YET DIDN'T DISCLOSE THAT PART..WHEN I PURCHASED IT. I WAS SOLD A LEMON..AND FORD WILL NOT HONOR THERE RECALLS ON IT..SO SEEMS IM DOOMED..IM ON DISABILITY AND CANT AFFORD ALL THESE REPAIRS BUT NO ONE SEEMS TO CARE.. *TR
NHTSA ODI #10236203
42,988 miles · Jun 4, 2008
Electrical SystemElectronic Stability Control (esc)Engine And Engine Cooling
THERE ARE ALOT OF RECALLS ON MY CAR AND NO ONE WILL HELP ME. *TR
NHTSA ODI #10229979
70,000 miles · Apr 26, 2007
Electrical SystemExterior Lighting
TL*THE CONTACT OWNS A 1993 FORD TAURUS. THE VEHICLE RECEIVEDE RECALL REGARDING THE CIRCUIT BREAKER OPENING. THE FAILURE CAUSED THE HEADLIGHTS TO DIM FOR SHORT PERIODS OF TIME. THE CONTACT'S VEHICLE HAD THE SAME FAILURE, BUT FORD STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 130,000, AND FA…
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD TAURUS. THE VEHICLE RECEIVEDE RECALL REGARDING THE CIRCUIT BREAKER OPENING. THE FAILURE CAUSED THE HEADLIGHTS TO DIM FOR SHORT PERIODS OF TIME. THE CONTACT'S VEHICLE HAD THE SAME FAILURE, BUT FORD STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE CURRENT MILEAGE IS 130,000, AND FAILURE MILEAGE WAS 70,000.*AK
NHTSA ODI #10188946
Mileage unknown · Jun 17, 2005
Electrical SystemFire
I RECENTLY READ AN ARTICLE ABOUT SPONTANEOUS FIRES IN FORD MODELS ON CNN. I USED TO HAVE A FORD TAURUS WHICH CAUGHT ON FIRE. LUCKILY WE PUT IT OUT BEFORE IT GOT VERY LARGE BUT THE ENTIRE WIRING HARNESS BURNT AND IT WAS UNREPAIRABLE.
NHTSA ODI #10125574
Mileage unknown · Mar 23, 2005
Electrical SystemFire
WHILE BEING PARKED FOR APPROXIMATELY 6-8 HOURS VEHICLE CAUGHT ON FIRE. THE CAUSE OF THE FIRE WAS UNDETERMINED.*AK
NHTSA ODI #10115711
Mileage unknown · Oct 18, 2004
Electrical SystemEngine And Engine CoolingSuspension
NUMEROUS COMPLAINTS CONCERNING LEAKING HEAD GASKETS. *BF THE VEHICLE HAS HAD NUMEROUS PROBLEM WITH THE VEHICLE WHICH INCLUDE THE INTAKE MANIFOLD, COOLING FAN, IGNITION WIRING, COIL SPRING FAILURE, CHECK ENGINE LIGHT ILLUMINATED, ALTERNATOR, HEAD GASKET AND MUFFLER. WHILE RESEARCHING THE VEHICLE ON NHTSA SITE THE CONSUMER DISC…
Read full complaint
NUMEROUS COMPLAINTS CONCERNING LEAKING HEAD GASKETS. *BF THE VEHICLE HAS HAD NUMEROUS PROBLEM WITH THE VEHICLE WHICH INCLUDE THE INTAKE MANIFOLD, COOLING FAN, IGNITION WIRING, COIL SPRING FAILURE, CHECK ENGINE LIGHT ILLUMINATED, ALTERNATOR, HEAD GASKET AND MUFFLER. WHILE RESEARCHING THE VEHICLE ON NHTSA SITE THE CONSUMER DISCOVERED SEVERAL RECALLS ON THE VEHICLE RELATED THE FAILURES HIS VEHICLE EXPERIENCED. *NM
NHTSA ODI #10097379
Mileage unknown · Mar 8, 2004
Air BagsElectrical SystemVehicle Speed Control
THE HORN NOR THE CRUISE CONTROL BUTTONS WORKED IN THE STEERING WHEEL HUB. *PH CONSUMER FELT THAT THERE'S NO NEED TO FIX THE PROBLEM AT ONCE EVEN THOUGH IT WAS SUCH AN INCONVENIENCE ON HIS BEHALF. AFTER TEN MONTHS OF OWNERSHIP OF VEHICLE PURCHASED FROM E-BAY, VEHICLE WAS TAKEN TO REPAIR FACILITY TO HAVE STEERING CONTROLS FIXED…
Read full complaint
THE HORN NOR THE CRUISE CONTROL BUTTONS WORKED IN THE STEERING WHEEL HUB. *PH CONSUMER FELT THAT THERE'S NO NEED TO FIX THE PROBLEM AT ONCE EVEN THOUGH IT WAS SUCH AN INCONVENIENCE ON HIS BEHALF. AFTER TEN MONTHS OF OWNERSHIP OF VEHICLE PURCHASED FROM E-BAY, VEHICLE WAS TAKEN TO REPAIR FACILITY TO HAVE STEERING CONTROLS FIXED. MECHANIC CALLED CONSUMER AND WAS INFORMED THAT AIR BAG HAD BEEN REMOVED FROM STEERING WHEEL HUB AND REPLACED WITH FOAM TO SIMULATE THE SHAPE OF THE AIR BAG. CONSUMER WAS ABLE TO HAVE AIR BAG INSTALLED INTO STEERING WHEEL HUB ALONG WITH THE REPAIRS ON HORN AND CRUISE CONTROL. CONSUMER NOW ASKING IF IT'S AGAINST FLORIDA OR FEDERAL LAW TO SELL A CAR WITH THE AIR BAG EITHER UNIONIZATION OR INOPERATIVE AND NOT INFORM THE BUYER. *LA
NHTSA ODI #10062882
Mileage unknown · Jan 23, 2004
Electrical SystemSteering
THE VEHICLE'S HEADLIGHT SWITCH AND WIRE HARNESS, STEERING COLUMN COVERS, TURN SIGNAL/WIPER SWITCH WERE REPLACED. *PH *NM
NHTSA ODI #10057183
188,632 miles · Nov 12, 2003
Electrical SystemVehicle Speed ControlFireInjury
CHUCK'S CLEAN & USED CARS OF PEMBROKE SOLD ME A 1993 FORD TAURUS VIN [XXX] WITH A KNOWN RECALL ON IT. THERE WAS A FIRE WITH THE IGNITION SYSTEM WAS TOTALLY DESTROYED. *LA INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10046770
Mileage unknown · Mar 19, 2003
Electrical System
THE REAR PASSENGER POWER DOOR UNLOCKED WHICH CAUSED THE DOOR TO OPEN WHEN A TURN WAS MADE. *JB
NHTSA ODI #10012115
Official recalls
6Dec 16, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN CONNECTICUT, DELAWARE, DISTRICT OF COLUMBIA, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGNIA, AND WISCONSIN. THE REAR LOWER SUBFRAME MOUNT PLATE NUT CAN EXPERIENCE STRESS CORROSION CRACKING IF SUBJECTED TO LONG TERM EXPOSURE TO ROAD SALTS. THIS CAN RESULT IN FRACTURE AND LOSS OF THE STRUCTURAL INTEGRITY OF THE SUBFRAME MOUNT ATTACHMENT. DETACHMENT OF THE BODY MOUNTS AT THE REAR CORNERS OF THE SUBFRAME, WHICH SUPPORTS THE ENGINE AND TRANSMISSION, ALLOWS THE REAR CORNERS OF THE SUBFRAME TO DROP.
Consequence & remedy
Consequence: IF BOTH REAR CORNERS DROP, STEERING WOULD BECOME SUDDENLY VERY DIFFICULT, AFFECTING VEHICLE CONTROL AND INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL SUBFRAME REAR MOUNT BOLTS, REINFORCEMENT PLATES, AND PLATE NUTS.
May 6, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE STATES OF NEW YORK, MICHIGAN, OHIO, ILLINOIS, WISCONSIN, PENNSYLVANIA, MASSACHUSETTS, INDIANA, NEW JERSEY, MAINE, CONNECTICUT, NEW HAMPSHIRE, RHODE ISLAND, VERMONT, MINNESOTA, IOWA, MISSOURI, KENTUCKY, MARYLAND, DELAWARE, AND WEST VIRGINIA. THE FRONT COIL SPRINGS CAN FRACTURE AS A RESULT OF CORROSION IN COMBINATION WITH SMALL CRACKS IN THE SPRINGS.
Consequence & remedy
Consequence: THE FRONT TIRE COULD DEFLATE DUE TO A BROKEN FRONT COIL SPRING CONTACTING THE TIRE, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSTALL A SPRING CATCHER BRACKET WHICH WILL PREVENT A FRACTURED SPRING FROM CONTACTING A TIRE.
Jan 21, 1998
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
Feb 26, 1997
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH 3.8L ENGINES AND ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, IOWA, IDAHO, ILLINOIS, INDIANA, KANSAS, MASSACHUSETTS, MAINE, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NORTH DAKOTA, NEBRASKA, NEW HAMPSHIRE, NEW YORK, OHIO, PENNSYLVANIA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WATER CAN ACCUMULATE WITHIN THE SPEED CONTROL CABLE CONDUIT. IF ENOUGH WATER ACCUMULATES, IT COULD FREEZE WITHIN A LOW AREA OF THE CABLE ROUTING WHEN EXPOSED TO A LONG TERM COLD SOAK AT TEMPERATURES AT LEAST SEVERAL DEGREES BELOW FREEZING.
Consequence & remedy
Consequence: DRIVER CONTROL OF VEHICLE SPEED USING THE SPEED CONTROL SYSTEM OR THE ACCELERATOR CONTROL SYSTEM WOULD BE DIMINISHED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL ADD A BOOT TO THE SPEED CONTROL CABLE.
Feb 25, 1997
THESE VEHICLES ARE ORIGINALLY SOLD OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, IOWA, MINNESOTA, NEBRASKA, NORTH DAKOTA, AND SOUTH DAKOTA. THE VEHICLES INVOLVED ARE 1992-1994 TEMPO/TOPAZ VEHICLES WITH 3.0L ENGINES; 1994 TEMPO/TOPAZ WITH 2.3L ENGINES; 1992-1995 TAURUS/SABLE WITH 3.8L ENGINES; 1994-1995 TAURUS/SABLE WITH 3.0L ENGINES AND 1992-1994 LINCOLN CONTINENTAL VEHICLES WITH 3.8L ENGINES. DURING HIGH WINDS, HEAVY, BLOWING AND DRIFTING SNOW, AND LOW TEMPERATURES, THE ENGINE COOLING FAN CAN BECOME BLOCKED OR FROZEN WITH SNOW. THE FAN MOTOR MAY NOT ROTATE AND COULD OVERHEAT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE SMOKE OR FLAMES FROM THE FAN AND/OR SHROUD, THE FAN ELECTRICAL WIRING, OR THE FAN MOTOR RESULTING IN A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL AN ELECTRICAL JUMPER HARNESS CONTAINING AN AUTOMATIC RESETTING CIRCUIT BREAKER TO PROTECT THE FAN MOTOR LOW SPEED CIRCUITRY FROM OVERHEATING.
Jan 4, 1993
ANTI-LOCK BRAKE SYSTEM CONTROLLERS DESIGNED FOR REAR WHEEL DRIVE CARS MAY HAVE BEEN INSTALLED ON THESE FRONT WHEEL DRIVE CARS..
Consequence & remedy
Consequence: THIS COULD RESULT IN REDUCED BRAKING ABILITY AND POSSIBLEVEHICLE ACCIDENT.
Remedy: REPLACE THE REAR WHEEL DRIVE ABS CONTROLLER WITH A FRONT WHEEL DRIVE ABS CONTROLLER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
13RQ99017 · Front Suspension Spring
Opened Aug 9, 1999 · Closed Feb 16, 2000
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA99023 · Windshield Wiper
Opened Aug 6, 1999 · Closed Jun 12, 2001
Status: closed (inferred from source dates) · Visibility
ODI has received 50 additional complaiints on MY 1993 Ford Taurus and Mercury Sable vehicles alleging malfunction of the windshield wiper system including; intermittent or complete stoppage of wiper sweeping; inadequate sweep speed; and other general complaints of poor performace.In some cases, the owner alleges havingto leave the roadway or roll down the window and manually restart the sweeping motion of the wiper arms.Other complaints allege that the wiper sweeps too slowly at the maximum speed setting resulting in inadequate vision during heavy precipition.Some complaints allge repeated wiper system malfunctions despirt having their vehicles serviced at Ford dealerships of replacement of the multi-function switch and/or wiper motor.Ford provided its response to an Information Request Letter indicating that the same wiper motor is used on the MY 1987-1993 Taurus and Sable; however, warranty and complaint data show that the MY 1993 is over represented and may warrant particular attention.An Engineering Ananlysis is necessary to determine if a potential safety defect exists.
PE99015 · Windshield Wiper
Opened Feb 24, 1999 · Closed Aug 6, 1999
Status: closed (inferred from source dates) · Visibility
ALLEGED THAT THE WINDSHIELD WIPERS FAIL WITHOUT WARNING
EA97026 · Front Suspension Coil Spring Failure
Opened Nov 26, 1997 · Closed May 13, 1998
Status: closed (inferred from source dates) · Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Additional source detail variants (2)
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
Suspension
ALLEGED THE FRONT SUSPENSION COIL SPRINGS MAY FRACTURE, PERMITTING SUSPENSION COLLAPSE, POSSIBLE TIRE PUNCTURE AND THE POTENTIAL FOR COMPROMISE TO VEHICLE SAFETY
PE97035 · Front Suspension Coil Spring Failure
Opened Jul 22, 1997 · Closed Nov 26, 1997
Status: closed (inferred from source dates) · Suspension:front:springs:coil Springs
Front Suspension coil springs may fracture with the vehicle in motion, posing a potential compromise to the driver's ability to control the vehicle.
EA96024 · Engine Cooling Fan Fires
Opened Sep 30, 1996 · Closed Apr 15, 1997
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
PE96033 · Engine Cooling Fan Fires
Opened May 2, 1996 · Closed Sep 30, 1996
Status: closed (inferred from source dates) · Engine And Engine Cooling
IN DECEMBER 1995, FORD RECALLED 119,313 VEHICLES IN CANADA TO REMEDY THE SUBJECT CONDITION IN CERTAIN 1992-95 TAURUS, SABLE, TEMPO, TOPAZ AND CONTINENTAL VEHICLES.FORD IS AWARE OF SIMILAR INCIDENTS OCCURRING IN NORTHERN REGIONS OF THE UNITED STATES, BUT MAINTAINS THAT THE FREQUENCIES DO NOT WARRANT A FINDING OF AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY.
PE96018 · Headlights Failure
Opened Mar 5, 1996 · Closed Jul 31, 1996
Status: closed (inferred from source dates) · Exterior Lighting:headlights
There is no summary currently available
DP95004 · Alleged Defective Tie Rods
Opened Aug 8, 1995 · Closed Aug 30, 1995
Status: closed (inferred from source dates) · Unknown Or Other
ALLEGED DEFECTIVE TIE RODS
EA94008 · Broken Tie Rods
Opened Feb 16, 1994 · Closed Feb 27, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE93100 · Polycast Road Wheel Cracks
Opened Dec 2, 1993 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE93058 · Broken Tie Rods
Opened Jun 15, 1993 · Closed Feb 16, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
Illustration