NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
346 reports80,000 miles · Oct 4, 2016
Electrical SystemStructure
DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, …
Read full complaint
DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, LESS THAN 30 MPH AND MOSTLY WHEN GOING AROUND TURNS. STARTED ALMOST A YEAR AGO.
NHTSA ODI #10913677
127,000 miles · Aug 30, 2016
Air BagsCrashInjury
THE AIRBAGS FAILED TO DEPLOY IN A HEAD ON COLLISION TRAVELING 50 MPH
NHTSA ODI #10899432
250,000 miles · Aug 16, 2016
Electrical SystemEngineVehicle Speed ControlFire
MY WIFE AND I WERE DRIVING ON HWY 79FROM PALISTINE TX TO JACKSONVILLE TX THURSDAY 7/11/2016 WHEN WE NOTICED SMOKE COMING OUT FROM UNDER THE TRUCK WE PULLED OVER AND NOTICED FIRE UNDER THE HOOD I TRIED TO POOR WATER ON IT ALL IT DID WAS JUST GET WORSE AND OUR TRUCK ALL MY WORK TOOLS MY LIVELY HOOD BLEW UP.
NHTSA ODI #10896403
126,520 miles · Aug 10, 2016
SuspensionUnknown Or Other
WAS PULLING INTO FRIENDS DRIVEWAY WHEN I HEARD A CRACKING NOISE WHEN I CHECKED THE LEFT REAR SPRING HANGER PULLED OUT OF THE RUSTED FRAME. I PULLED OFF THE BED OF THE TRUCK AND FOUND SEVERAL AREAS WHICH WERE SEVERELY RUSTED INCLUDING THE SPARE TIRE CARRIER AND THE STRAPS WHICH HOLD UP THE GAS TANK. I AM THE ORIGINAL OWNER OF THE…
Read full complaint
WAS PULLING INTO FRIENDS DRIVEWAY WHEN I HEARD A CRACKING NOISE WHEN I CHECKED THE LEFT REAR SPRING HANGER PULLED OUT OF THE RUSTED FRAME. I PULLED OFF THE BED OF THE TRUCK AND FOUND SEVERAL AREAS WHICH WERE SEVERELY RUSTED INCLUDING THE SPARE TIRE CARRIER AND THE STRAPS WHICH HOLD UP THE GAS TANK. I AM THE ORIGINAL OWNER OF THE VEHICLE AND HAVE LIVED IN PENNSYLVANIA THE WHOLE TIME.
NHTSA ODI #10894702
123,546 miles · May 13, 2016
Structure
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,546.
NHTSA ODI #10864759
174,000 miles · May 2, 2016
Structure
THE TRUCK FRAME HAS MULTIPLE SPOTS OF SEVERE RUST THAT CAUSED IT TO SNAP IN 2 MAKING THE TRUCK UNSAFE TO DRIVE. ONE OF THE AREAS IS NEXT TO THE GAS TANK (WHERE IT SNAPPED) AND THE RUST DOES NOT AFFECT ANY OTHER SPOT AROUND THE FRAME IN THIS AREA. I WAS MAKING A WIDE RIGHT HAND TURN ON A HIGHWAY ON RAMP AND IT SNAPPED.
NHTSA ODI #10862461
105,000 miles · Mar 30, 2016
Electrical SystemExterior LightingFuel/propulsion System
CANT COTROL CAR WANT TO LUNGE FORWARD OR STALL HARD TO DRIVE LIKE THIS I AM TOLD IT IS THE (ETB) ALSO DOOR WILL NOT STOP CHIMING
NHTSA ODI #10852399
34,000 miles · Feb 25, 2016
Exterior LightingVehicle Speed Control
2002 FORD RANGER, CONSUMER STATED HIS ISSUE DEALS WITH THE CRUISE CONTROL, WHICH WORKED SPORADICALLY. *BF THE CONSUMER STATED WHEN HE PRESSED THE BUTTON FOR THE CRUISE CONTROL, THE GREEN LIGHT WOULD FLASH, BUT IT WOULD NOT ENGAGE. TWO MONTHS AGO, THE BRAKE LIGHTS STOPPED WORKING. *JB..UPDATED 03/16/16 *BF THE CONSUMER STATED…
Read full complaint
2002 FORD RANGER, CONSUMER STATED HIS ISSUE DEALS WITH THE CRUISE CONTROL, WHICH WORKED SPORADICALLY. *BF THE CONSUMER STATED WHEN HE PRESSED THE BUTTON FOR THE CRUISE CONTROL, THE GREEN LIGHT WOULD FLASH, BUT IT WOULD NOT ENGAGE. TWO MONTHS AGO, THE BRAKE LIGHTS STOPPED WORKING. *JB..UPDATED 03/16/16 *BF THE CONSUMER STATED THE CRUISE CONTROL WOULD ACTIVATE AND DEACTIVATE ON ITS OWN. IN FEB 2015, ALL THE BRAKE LIGHTS FAILED. HOWEVER, ALL THE BULB WERE STILL GOOD. THE DEALER INFORMED THE CONSUMER THE BRAKE LIGHT SWITCH NEEDED TO BE REPLACED. UPDATED 03/22/16.*JB
NHTSA ODI #10838435
179,000 miles · Jan 6, 2016
Engine
ENGINE ERROR CODE P303 DISPLAYED AND ENGINE MISSING ON THAT CYLINDER. FORD TSB 05-26-3 STATES HEAD REPLACEMENT NECESSARY TO CORRECT. THIS APPEARS TO BE A GENERIC ISSUE WITH THE 3.0 LITER VULCAN ENGINES,. CAR WILL NOT PASS EMISSIONS INSPECTION UNTIL THIS IS REPAIRED.
NHTSA ODI #10818378
100,000 miles · Dec 29, 2015
Vehicle Speed Control
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE CRUISE CONTROL SWITCH FAILED TO FUNCTION AND THE LIGHT ON THE FUNCTION BUTTON FAILED TO ILLUMINATE. THE VEHICLE WAS TO BE TAKEN TO A DEALER TO BE DIAGNOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10816866
Official recalls
3Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
Feb 4, 2002
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration