I PURCHASED A 2002 RANGER EDGE 4X4 , IT HAD 4 MILES ON IT. I HAVE SINCE REPLACED THE AIRBAG SENSOR, ABS SENSOR, FRONT END HAD TOBE REALIGNED DUE TO A BAD ALIGNMENT AT THE FACTORY,THE TIRES IN THE FRONT HAD TO BE REPLACED AT 4500 MILES. NOW AT 38000 MILES THE 4X4 DRIVETRAIN WAS LEAKING AT THE FRONT COVER. THE BREATHING TUBE WAS…
Read full complaint
I PURCHASED A 2002 RANGER EDGE 4X4 , IT HAD 4 MILES ON IT. I HAVE SINCE REPLACED THE AIRBAG SENSOR, ABS SENSOR, FRONT END HAD TOBE REALIGNED DUE TO A BAD ALIGNMENT AT THE FACTORY,THE TIRES IN THE FRONT HAD TO BE REPLACED AT 4500 MILES. NOW AT 38000 MILES THE 4X4 DRIVETRAIN WAS LEAKING AT THE FRONT COVER. THE BREATHING TUBE WAS THROWING OIL OUT ONTO THE ENGINE . I WAS TOLD BY FORD COMPANY AND A FORD TECH. THAT THIS WAS A E4NGINNERING PROBLEM. IT WAS REPLACED AT MY COST OF 796.00. THE COVER WAS REPLACED WITH A PART THAT WAS USED PREVIOUS TO 1995, PART NUMBER IS FOF6TZ-4033-BA. MY COMPLAINT IS WHY IS THIS NOT A RECALL AND CAN I EXPECT FUTURE PROBLEMS. *JB
NHTSA ODI #10056218
55,000 miles · Oct 22, 2003
Suspension
WHILE DRIVING AT 35 - 40 MPH RIGHT REAR END COMPLETELY SEPARATED AND FELL OFF THE TRUCK. WHEN THIS OCCURRED DRIVER LOST CONTROL OF THE TRUCK, BUT DIDN'T HAVE AN ACCIDENT. DEALERSHIP INDICATED THAT A PIN INSIDE THE REAR AXLE ASSEMBLY SHEARED OFF.*AK PLEASE PROVIDE DETAILS
NHTSA ODI #10044464
Mileage unknown · Jul 29, 2003
Suspension
CONSUMER STATES TIRES ARE WEARING PREMATURELY DUE TO FRONT END SUSPENSION. DEALER NOTIFIED.*AK
NHTSA ODI #10031397
600 miles · Nov 15, 2002
Suspension
VEHICLE HAS A SLIGHT VIBRATION AT 65 MPH THAT INCREASES IN SEVERITY AS SPEED INCREASES. AT 85 MPH IT HAS A VERY PRONOUNCED VIBRATION THAT MUST BE CONSIDERED DANGEROUS. VEHICLE WAS RETURNED TO DEALER FOUR TIMES. THE DEALER ESSENTIALLY TOLD CUSTOMER THAT FORD WOULD NOT WARRANTY A VEHICLE OVER THE LEGAL SPEED LIMIT. THIS WAS THE FI…
Read full complaint
VEHICLE HAS A SLIGHT VIBRATION AT 65 MPH THAT INCREASES IN SEVERITY AS SPEED INCREASES. AT 85 MPH IT HAS A VERY PRONOUNCED VIBRATION THAT MUST BE CONSIDERED DANGEROUS. VEHICLE WAS RETURNED TO DEALER FOUR TIMES. THE DEALER ESSENTIALLY TOLD CUSTOMER THAT FORD WOULD NOT WARRANTY A VEHICLE OVER THE LEGAL SPEED LIMIT. THIS WAS THE FINAL ANSWER AFTER SEVERAL ATTEMPTS WERE MADE TO CONVINCE THE CUSTOMER OF OTHER CAUSES, MOST OF WHICH WERE ESSENTIALLY RIDICULOUS. (THE CUSTOMER WAS IN THE AUTO REPAIR BUSINESS FOR 17 YEARS.) THE CUSTOMER TOOK THE TECHNICIAN FOR A TEST DRIVE TO DEMONSTRATE THE SEVERE VIBRATION. THE TECHNICIAN PROPOSED THE POSSIBILITY OF A DEFECTIVE REAR DRIVE LINE. THE TECHNICIAN'S SUPERVISOR THEN DROVE THE VEHICLE HIMSELF THEN STATED THE VEHICLE DEFINITELY HAD A PRONOUNCED VIBRATION, BUT FORD WOULD NOT WARRANTY THE PROBLEM. SINCE THE VIBRATION WAS DISCOVERED WHILE PASSING AN OBVIOUSLY INTOXICATED DRIVER (FOR SAFETY REASONS), THE CUSTOMER DEFINITELY CONSIDERS THIS A SAFETY HAZARD. AFTER VIEWING SEVERAL OTHER COMPLAINTS AT THE NHTSA SITE, IT IS ALL TO OBVIOUS THAT THIS ANSWER/REFUSAL IS BECOMING A VERY COMMON PRACTICE AMONG FORD DEALERS. *PH *NLM **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**769763
NHTSA ODI #10006936
Mileage unknown · Aug 30, 2002
Power TrainSuspension
WHEN PULLING UP TO A STOP TRUCK RATTLES WITH AN AWKWARD SOUND. DEALERSHIP HAS MADE SEVERAL ATTEMPTS TO CORRECT, BUT WITH NO SUCCESS. FORD HAS SENT OUT A TSB ON THIS, BUT EVEN THAT HAS NOT CORRECTED THE PROBLEM. A FACTORY REPRESENTATIVE SPOKE WITH THE OWNER AND BASICALLY TOLD HIM THAT THE TRUCK WAS LIKE THAT. THE ENGINE IS 3…
Read full complaint
WHEN PULLING UP TO A STOP TRUCK RATTLES WITH AN AWKWARD SOUND. DEALERSHIP HAS MADE SEVERAL ATTEMPTS TO CORRECT, BUT WITH NO SUCCESS. FORD HAS SENT OUT A TSB ON THIS, BUT EVEN THAT HAS NOT CORRECTED THE PROBLEM. A FACTORY REPRESENTATIVE SPOKE WITH THE OWNER AND BASICALLY TOLD HIM THAT THE TRUCK WAS LIKE THAT. THE ENGINE IS 3.0 LITRE W/5 SPEED TRANSMISSION, EDGE SERIES MODEL PICKUP. PLEASE DESCRIBE DETAILS. *AK
NHTSA ODI #8017688
Mileage unknown · Mar 12, 2002
Suspension
REAR SHOCK ABSORBERS BLEW OUT. DEALER HAS REPAIRED VEHICLE. *AK
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration