IllustrationI RECENTLY CHECK THE UNDERSIDE OF THE VEHICLE AND FOUND OUT A MISSING SPARETIRE AND ALSO A VERY LOOSE REAR BUMPER AND THE CAUSE OF IT IS RUST, VERY BAD RUSTING ON THE FRAME, MOSTLY ON THE REAR END. *TR
2002 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 2002 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
4925–50K
3750–75K
2875–100K
36100–150K
19150K+
220 reports with mileage · 126 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports12 fire reports25 injury reports
Structure complaints
49 reportsTHIS TRUCK IS RUSTING FROM FRONT TO BACK.THE MAIN FRAME AND ALL CONNECTING PARTS. I HAVE HAD TO REPLACE NUMEROUS METAL PARTS. THERE HAS TO BE SOME KIND OF DEFECT EITHER IN THE METAL OR THIS TRUCK WAS NEVER UNDERCOATED. IT HAS 84000 MILES AND I HAVE BEEN REPLACING PARTS SINCE 75000 MILES. *TR
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH OVER A ROAD BUMP, THE REAR FRAME BECAME DETACHED ALONG WITH THE CROSS MEMBER, CAUSING THE SPARE TIRE TO FRACTURE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE TWO CROSS MEMBERS, THE FRAME BEDDING AND THE REAR FRAME WAS…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 30 MPH OVER A ROAD BUMP, THE REAR FRAME BECAME DETACHED ALONG WITH THE CROSS MEMBER, CAUSING THE SPARE TIRE TO FRACTURE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE TWO CROSS MEMBERS, THE FRAME BEDDING AND THE REAR FRAME WAS RUSTED AND CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.
I TOOK MY 2002 FORD RANGER TRUCK IN FOR INSPECTION AND I WAS TOLD MY TRUCK WAS UNINSPECTABLE BECAUSE MY FRAME,CROSSMEMBER, FRONT AARMS ARE RUSTED THIN. IT ONLY HAS 80 SOME K ON IT I ONLY HAVE IT FOR 2YEARS I DON'T DRIVE VERY FAR I BOUGHT IT WITH 74K. *TR
I PURCHASED THIS TRUCK 1 YR AGO . I TOOK IT IN FOR INSPECTION AND FOUND THAT IT HAD SEVERE RUST PROBLEMS . THE SHACKLES FOR THE LEAF SPRING HAD COMPLETELY ROTTED AWAY CAUSING THE SPRING TO REST UPON THE BOX. THE RESTRAINT FOR THE GAS TANK WAS ROTTED TO THE POINT THAT TANK WAS ABOUT TO FALL OFF. THERE WAS SEVERE RUSTING OF THE…
Read full complaint
I PURCHASED THIS TRUCK 1 YR AGO . I TOOK IT IN FOR INSPECTION AND FOUND THAT IT HAD SEVERE RUST PROBLEMS . THE SHACKLES FOR THE LEAF SPRING HAD COMPLETELY ROTTED AWAY CAUSING THE SPRING TO REST UPON THE BOX. THE RESTRAINT FOR THE GAS TANK WAS ROTTED TO THE POINT THAT TANK WAS ABOUT TO FALL OFF. THERE WAS SEVERE RUSTING OF THE FRAME , ESPECIALLY IN THE REAR .OBVIOUSLY, THE TRUCK FAILED INSPECTION. *TR
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE APPROACHING A STOP LIGHT, HE ERRONEOUSLY DEPRESSED BOTH THE BRAKE PEDAL AND THE ACCELERATOR PEDAL AND PROCEEDED THROUGH THE LIGHT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE F…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE APPROACHING A STOP LIGHT, HE ERRONEOUSLY DEPRESSED BOTH THE BRAKE PEDAL AND THE ACCELERATOR PEDAL AND PROCEEDED THROUGH THE LIGHT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 20,000. THE VIN WAS NOT AVAILABLE.
YESTERDAY I HAD SOMETHING GO WRONG WITH MY FORD RANGER AND I NEEDED TO HAVE IT TOWED HOME. THIS PROBLEM WILL BE THE END OF MY WONDERFUL TRUCKS LIFE BECAUSE THE INSPECTION IS ALSO DUE AND I HAVE BEEN TOLD THAT DUE TO EXTENSIVE RUST AND A CRACKED REAR FRAME, MY TRUCK WILL NEVER BE ABLE TO PASS INSPECTION. THE BODY, INTERIOR AND EN…
Read full complaint
YESTERDAY I HAD SOMETHING GO WRONG WITH MY FORD RANGER AND I NEEDED TO HAVE IT TOWED HOME. THIS PROBLEM WILL BE THE END OF MY WONDERFUL TRUCKS LIFE BECAUSE THE INSPECTION IS ALSO DUE AND I HAVE BEEN TOLD THAT DUE TO EXTENSIVE RUST AND A CRACKED REAR FRAME, MY TRUCK WILL NEVER BE ABLE TO PASS INSPECTION. THE BODY, INTERIOR AND ENGINE ARE ALL IN GREAT SHAPE. THE SPARE TIRE SUPPORT IS ALMOST COMPLETELY EATEN AWAY AND THE GAS TANK SUPPORTS ROTTED AWAY YEARS AGO. MY MECHANIC HAD TO RIG A WIRE HANGER FOR THE GAS TANK. WHILE MY TRUCK WAS ON THE FLAT BED, THE MECHANIC MENTIONED THAT RANGERS ARE KNOW FOR THE FRAMES BEING EATEN AWAY. I HAVE BEEN DOING RESEARCH AND UNDERSTAND NOW HOW COMMON THIS PROBLEM IS. WHY HAS FORD NOT RECALLED THIS POORLY MADE FRAME JUST LIKE TOYOTA DID? IS IT BECAUSE NOT ENOUGH PEOPLE HAVE DIED FROM IT??? *TR
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE SUB FRAME WAS CORRODED AND CAUSED THE FUEL TANK STRAP TO FRACTURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000 AND THE CURRENT MILEAGE WAS 92,000, UPDATED 02/11/14*LJ THE CONSUMER STATED THE FRAM…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE SUB FRAME WAS CORRODED AND CAUSED THE FUEL TANK STRAP TO FRACTURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000 AND THE CURRENT MILEAGE WAS 92,000, UPDATED 02/11/14*LJ THE CONSUMER STATED THE FRAME ROTTED WHERE THE FUEL TANK STRAP FAILED, CAUSING THE TANK TO HANG LOWER THAN IT SHOULD. IT WAS HOLDING BY ONE STRAP. THERE WAS A CRACK IN THE FRAME. UPDATED 02/12/14
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE SPARE TIRE HOLDER FRACTURED, CAUSING THE TIRE TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT THE SPARE TIRE BED WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE SPARE TIRE HOLDER FRACTURED, CAUSING THE TIRE TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT THE SPARE TIRE BED WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.
WHEN PULLING INTO A DRIVEWAY, I HEARD A LOUD CRACK FROM THE REAR OF THE TRUCK. AFTER INSPECTION, THE REAR FRAME HAD RUSTED TO THE POINT WHERE THE LEAF SPRING MOUNT DETACHED FROM THE FRAME. IF THIS WOULD HAVE HAPPENED WHILE HAULING A LOAD, OR PULLING A TRAILER AT HIGHWAY SPEEDS, IT COULD HAVE LED TO A CRASH. *TR
Official recalls
309V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
07V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
02V035000 · Power Train:driveline:differential Unit
Feb 4, 2002
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.