IllustrationFRAME HAS EXTENSIVE ROT RESULTING IN AN UNSTABLE HANDLING FEEL TO THE TRUCK WHILE DRIVING. ALSO THE LEAF SPRING MOUNTS ARE RUSTED THROUGH AND ABOUT TO FALL APART, I FEEL THE TRUCK IS NO LONGER SAFE TO DRIVE.
2002 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 2002 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
510–25K
4925–50K
3750–75K
2875–100K
36100–150K
19150K+
220 reports with mileage · 126 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 51 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 49 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
43 crash reports12 fire reports25 injury reports
Structure complaints
49 reportsEXCESSIVE RUST UNDERNEATH. LEAF SPRING HANGERS FAILED AT 11 YEARS/120K MILES. SPARE TIRE WINCH SEPARATED FROM TRUCK AT 14 YEARS/155K MILES. . AN EXHAUST MOUNT HAS RUSTED AWAY LEAVING THE EXHAUST SYSTEM MARGINALLY SUPPORTED - UNCERTAIN OF WHEN THIS HAPPENED. LOGGING THIS COMPLAINT DUE TO THE GAS TANK STRAP FAILURE. ONE G…
Read full complaint
EXCESSIVE RUST UNDERNEATH. LEAF SPRING HANGERS FAILED AT 11 YEARS/120K MILES. SPARE TIRE WINCH SEPARATED FROM TRUCK AT 14 YEARS/155K MILES. . AN EXHAUST MOUNT HAS RUSTED AWAY LEAVING THE EXHAUST SYSTEM MARGINALLY SUPPORTED - UNCERTAIN OF WHEN THIS HAPPENED. LOGGING THIS COMPLAINT DUE TO THE GAS TANK STRAP FAILURE. ONE GAS TANK STRAP SEPARATED FROM UNDERNEATH THE TRUCK BED APPROXIMATELY ONE MONTH AGO - AGE 14.5 YEARS, ~160K MILES. WITH THE SPARE TIRE, I NOTICED IT HANGING LOW (3 OF 4 FASTENERS HAD PULLED AWAY FROM THEIR MOUNTS), AND WITH LITTLE EFFORT, WAS ABLE TO HAVE IT FALL OFF. HAD THE REMAINING FASTENER FAILED ON THE HIGHWAY, OBVIOUSLY BAD THINGS COULD HAVE HAPPENED. WITH THE GAS TANK STRAP, LUCKILY IT SEPARATED FROM UNDERNEATH THE BED RATHER THAN FROM THE FRAME, AND I COULD HEAR IT RUBBING AGAINST THE DRIVE SHAFT. THE OTHER STRAP WAS ABLE TO CARRY THE ENTIRE WEIGHT UNTIL I WAS ABLE TO SECURE THE GAS TANK.
DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, …
Read full complaint
DOOR AJAR LIGHT STAYS ON AFTER CAR IS STARTED AND INTERIOR LIGHTS STAY ON FOR ABOUT TEN MINUTES AFTER VEHICLE IS STOPPED BEFORE GOING OUT. DOES NOT HAPPEN IF VERY COLD 20 DEGREES F, OR LESS. ALSO DRIVERS DOOR WILL PARTIALLY OPEN OCCASIONALLY WHEN DRIVING TO THE SAFETY CATCH POSITION. DOOR OPENING IS NORMALLY AT LOWER SPEEDS, LESS THAN 30 MPH AND MOSTLY WHEN GOING AROUND TURNS. STARTED ALMOST A YEAR AGO.
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICL…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT WHILE STATIONARY DURING AN OIL CHANGE, THE VEHICLE'S FRAME BEDDING WAS DISCOVERED TO BE SEVERELY CORRODED. UNDERNEATH THE VEHICLE, THERE WAS A NOISE COMING FROM UNDERNEATH THE VEHICLE AND THE FRAME ENCOUNTERED THE BEDDING CAUSING THE FAILURE TO PROGRESS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 123,546.
THE TRUCK FRAME HAS MULTIPLE SPOTS OF SEVERE RUST THAT CAUSED IT TO SNAP IN 2 MAKING THE TRUCK UNSAFE TO DRIVE. ONE OF THE AREAS IS NEXT TO THE GAS TANK (WHERE IT SNAPPED) AND THE RUST DOES NOT AFFECT ANY OTHER SPOT AROUND THE FRAME IN THIS AREA. I WAS MAKING A WIDE RIGHT HAND TURN ON A HIGHWAY ON RAMP AND IT SNAPPED.
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE HAD NOT PASSED INSPECTION DUE TO RUSTING ON THE AXLE AND THE SUBFRAME ON THE FRONT DRIVER SIDE. THE CONTACT STATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT FRAME WAS UNABLE TO BE REPAIRED. THE…
Read full complaint
TL* THE CONTACT OWNS A 2002 FORD RANGER. THE CONTACT STATED THAT THE VEHICLE HAD NOT PASSED INSPECTION DUE TO RUSTING ON THE AXLE AND THE SUBFRAME ON THE FRONT DRIVER SIDE. THE CONTACT STATED THAT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FRONT FRAME WAS UNABLE TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 56,000. THE VIN WAS NOT AVAILABLE.
I BOUGHT THIS TRUCK FROM A DEALERSHIP IN JAN 2010. TRUCK WAS IN GOOD SHAPE, HAD FRAME CHECK OUT BEFORE I BOUGHT IT AND LOOKED VERY GOOD. TRUCK HAD ONLY 48000 MILES ON IT. IN JAN OF 2015 THE TRUCK BED SAT A LITTLE CROOKED CHECK FRAME AND SEEN A CRACK ON FRAME 3' LONG BY FRONT SHACKLE. AT THAT TIME TRUCK ONLY HAS 94000 MILES ON IT…
Read full complaint
I BOUGHT THIS TRUCK FROM A DEALERSHIP IN JAN 2010. TRUCK WAS IN GOOD SHAPE, HAD FRAME CHECK OUT BEFORE I BOUGHT IT AND LOOKED VERY GOOD. TRUCK HAD ONLY 48000 MILES ON IT. IN JAN OF 2015 THE TRUCK BED SAT A LITTLE CROOKED CHECK FRAME AND SEEN A CRACK ON FRAME 3' LONG BY FRONT SHACKLE. AT THAT TIME TRUCK ONLY HAS 94000 MILES ON IT. TOOK BED OFF AND FOUND MORE AREAS THAT WOULD NEED ADRESSING SOON. I TRIED TO KEEP TRUCK UNDER SIDE CLEAN DURING THE WINTER, I GUESS THE STUFF THE STATE USES ON THE ROAD WAS TO MUCH FOR THE TRUCK.
REAR LEAF SHACKLES REPLACED, ROTTED FROM FRAME, LAST AUG 2014 TO PASS INSPECTION. THIS WINTER 2014-2015, THE SPARE TIRE CARRIER FRAME ROTTED AND FELL FROM THE VEHICLE, INCLUDING THE SPARE TIRE. NOW, UPON INSPECTION OF THE BED APPEARING CROOKED, THE DRIVERS SIDE FRAME IN FRONT OF THE DRIVERS SIDE FRONT LEAF SPRING MOUNT IS TOTA…
Read full complaint
REAR LEAF SHACKLES REPLACED, ROTTED FROM FRAME, LAST AUG 2014 TO PASS INSPECTION. THIS WINTER 2014-2015, THE SPARE TIRE CARRIER FRAME ROTTED AND FELL FROM THE VEHICLE, INCLUDING THE SPARE TIRE. NOW, UPON INSPECTION OF THE BED APPEARING CROOKED, THE DRIVERS SIDE FRAME IN FRONT OF THE DRIVERS SIDE FRONT LEAF SPRING MOUNT IS TOTALLY ROTTED. THIS HAS CAUSED THE GAS TANK MOUNTS TO THE FRAME TO BREAK. IT HAS ALSO CAUSED THE BED TO TWIST AND THE ENTIRE REAR END OF THIS VEHICLE IS NOW ONLY SUPPORTED BY THE PASSENGER SIDE FRAME.
FRAME IS RUSTED AND ROTTING AWAY, BOUGHT IT FROM DEALER 1/21/2015. FOUND OUT TRUCK WAS IN BAD SHAPE 1/23/2015 AFTER GETTING OIL CHANGE FROM LOCAL SHOP. *TR
BRACKET FOR SPARE TIRE ROTTED, TIRE DROPPED OFF, NO CAR IN BACK OF ME, DIDN'T KNOW WHAT HAPPEN AT THE TIME, THAT HAPPENED 6 MONTH AFTER I BOUGHT IT, THE OTHER DAY THE FRAME CRACKED IN HALF. CAR DEALER SHIP SOLD TRUCK TO ME ROUGHLY 15 MONTH AGO TRUCK IS TOTALED. INSURANCE ADJUSTER SAID WHOLE FRAME AND UNDER CARRIAGE IS ROTTED? H…
Read full complaint
BRACKET FOR SPARE TIRE ROTTED, TIRE DROPPED OFF, NO CAR IN BACK OF ME, DIDN'T KNOW WHAT HAPPEN AT THE TIME, THAT HAPPENED 6 MONTH AFTER I BOUGHT IT, THE OTHER DAY THE FRAME CRACKED IN HALF. CAR DEALER SHIP SOLD TRUCK TO ME ROUGHLY 15 MONTH AGO TRUCK IS TOTALED. INSURANCE ADJUSTER SAID WHOLE FRAME AND UNDER CARRIAGE IS ROTTED? HELP. EXTERIOR OF TRUCK LOOKS BRAND NEW? HELP *TR
Official recalls
309V399000 · Vehicle Speed Control
Oct 13, 2009
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
07V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
02V035000 · Power Train:driveline:differential Unit
Feb 4, 2002
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.