WE ARE ORIGINAL OWNERS OF A 2002 FORD RANGER XLT NOW WITH 57,000 HIGHWAY MILES, ALWAYS GARAGED/WASHED/MAINTAINED, LITTLE DRIVING IN WINTER (MOSTLY IN SUMMER), ALWAYS FORD MAINTAINED/SERVICED AT SAME DEALERSHIP, BODY/ENGINE/TRANSMISSION IN GREAT SHAPE, WILL LIKELY FAIL INSPECTION THIS SPING BECAUSE FRAME AND FRAME COMPONENTS ARE …
Read full complaint
WE ARE ORIGINAL OWNERS OF A 2002 FORD RANGER XLT NOW WITH 57,000 HIGHWAY MILES, ALWAYS GARAGED/WASHED/MAINTAINED, LITTLE DRIVING IN WINTER (MOSTLY IN SUMMER), ALWAYS FORD MAINTAINED/SERVICED AT SAME DEALERSHIP, BODY/ENGINE/TRANSMISSION IN GREAT SHAPE, WILL LIKELY FAIL INSPECTION THIS SPING BECAUSE FRAME AND FRAME COMPONENTS ARE SEVERELY RUSTED OUT. - SEVERE RUST ON THE ENTIRE FRAME INCLUDING BOTH CROSS MEMBERS (ENGINE AND TRANSMISSION), ARM BOLT POINTS AND CONTROL ARMS. - FRAME ALSO HAS SEVERE RUST DOWN BOTH SIDES TO REAR BUMPER, REAR AXLE AND DIFFERENTAL, LEAF SPRINGS AND ALL MOUNTS. - THE PASSENGER SIDE STEARING KNUCKLE IS DELAMINATING. - ALL BRAKE LINES HAVE FAILED WHILE DRIVING: FIRST THE REAR BRAKES INCLUDING ALL AXLE COUPLINGS AND DRUM COUPLINGS; SECOND THE FRONT BRAKE LINES FAILED AT THE DISK BRAKES AND RUBBER COUPLINGS. ALL BRAKE TUBES HAD TO BE REPLACED FROM THE MASTER CYLINDER TO THE WHEELS. - SERVICE MANAGER IS WORRIED ABOUT FRONT CROSS MEMBER FAILING UNDER THE ENGINE, MIDDLE CROSS MEMBER FAILING UNDER THE TRANSMISSION AND THE GAS TANK BRACKETS/STRAPS. - THE FRAME AND MEMBERS AND MOUNTS MUST BE REPLACED; THE REST OF THE VEHICLE IS MECHANICALLY SOUND. SERVICE MANAGER SAID NO REPAIR WAS POSSIBLE TO FRAME RUST IS SO BAD PICTURES CAN BE PROVIDED AND/OR VEHICAL INSPECTED BY NHTSA IF DESIRED. ALL BRAKE LINES AND COUPLINGS PERFORMED AROUND AUGUST 29, 2019.
NHTSA ODI #11290615
140,000 miles · Jan 21, 2015
Air BagsService BrakesCrashFireInjury
MY SON WAS DRIVING HIS FORD RANGER XL 2002 WHEN DUE TO A PEDESTRIAN, THE CAR IN FRONT OF HIM SLAMMED ON THEIR BRAKES CAUSING MY SON TO REAR END THEM. SNOWY WEATHER WAS A FACTOR. THE BRAKES DIDN'T CATCH AS THEY SHOULD HAVE. HIS AIRBAGS BLEW UP, NOT DEPLOY- BLEW UP AND CAUGHT FIRE! THE STEERING WHEEL BLEW UP! EXTENSIVE DAMAGE OCC…
Read full complaint
MY SON WAS DRIVING HIS FORD RANGER XL 2002 WHEN DUE TO A PEDESTRIAN, THE CAR IN FRONT OF HIM SLAMMED ON THEIR BRAKES CAUSING MY SON TO REAR END THEM. SNOWY WEATHER WAS A FACTOR. THE BRAKES DIDN'T CATCH AS THEY SHOULD HAVE. HIS AIRBAGS BLEW UP, NOT DEPLOY- BLEW UP AND CAUGHT FIRE! THE STEERING WHEEL BLEW UP! EXTENSIVE DAMAGE OCCURRED TO THE STEERING COLUMN STEERING WHEEL AND DASHBOARD COMPONENTS. THE STARTER WENT OUT AND THE TRUCK WOULD NOT START. INSURANCE DEEMED THE TRUCK TOTALED. OBVIOUSLY THE AIRBAGS WERE DEFECTIVE!! WAS THERE A RECALL CONCERNING ANY OF THESE COMPONENTS THAT WE WERE NEVER INFORMED OF? WHAT COMPENSATION IS AVAILABLE TO US FOR THIS OBVIOUS MANUFACTURERS DEFECT?...UPDATED 02-03-15 *BF
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON SOME MANUAL TRANSMISSION TRUCKS EQUIPPED WITH THE FX4 PACKAGE, THE REAR AXLE DIFFERENTIAL CASE COULD FRACTURE UNDER A HIGH TORQUE EVENT SUCH AS WHEN CUSTOMERS ACCELERATE RAPIDLY FROM A STOP OR WHEN A SPINNING TIRE SUDDENLY GAINS TRACTION.
Consequence & remedy
Consequence: DIFFERENTIAL FRACTURES COULD POTENTIALLY RESULT IN WHEEL LOCK-UP.
Remedy: DEALERS WILL REPLACE THE REAR AXLE ASSEMBLY. OWNER NOTIFICATION BEGAN MARCH 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration