BOTH DRIVERS AND PASSENGER SEAT BELTS CAME UNLATCHED WHILE DRIVING. I HAVE INFORMED FORD MOTOR COMPANY CUSTOMER SERVICE AND THEY INDICATED THAT THERE WAS A RECALL ON THIS ISSUE, HOWEVER THEY HAD REPLACED THE BELTS WITH DEFECTIVE ONES THAT SPORADICALLY COME UNDONE WHILE DRIVING. CUSTOMER SERVICE INDICATED THAT THEY ARE NOT UNDER …
Read full complaint
BOTH DRIVERS AND PASSENGER SEAT BELTS CAME UNLATCHED WHILE DRIVING. I HAVE INFORMED FORD MOTOR COMPANY CUSTOMER SERVICE AND THEY INDICATED THAT THERE WAS A RECALL ON THIS ISSUE, HOWEVER THEY HAD REPLACED THE BELTS WITH DEFECTIVE ONES THAT SPORADICALLY COME UNDONE WHILE DRIVING. CUSTOMER SERVICE INDICATED THAT THEY ARE NOT UNDER WARRANTY, AT THIS TIME. WHY ARE THEY NOT RESPONSIBLE TO REPLACE WITH ONES THAT WORK. IF I BUY NEW ONES, WILL THEY BE DEFECTIVE. CUSTOMER SERVICE COULD NOT RESPOND WITH AN ANSWER AND IS AVOIDING ANSWERING. *TR
NHTSA ODI #10660364
104,000 miles · Nov 21, 2014
Air BagsSeat Belts
AIRBAGS PARTIALLY DEPLOYED WHEN I STOPPED QUICKLY. THERE WAS NO CONTACT OR EXTERIOR DAMAGE TO VEHICLE. *TR
NHTSA ODI #10660004
15,000 miles · Apr 3, 2014
Seat Belts
TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BUCKLE COULD NOT BE SAFELY SECURED WITHOUT MAKING AN ADJUSTMENT EACH TIME THE SEAT BELT WAS USED. THE INSTRUMENT PANEL WOULD ILLUMINATE WHEN THE SEAT BELT WAS NOT SECURED AND ONCE THE ADJUSTMENT WAS MADE MANUALLY BY THE CONTACT THE WARN…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SEAT BUCKLE COULD NOT BE SAFELY SECURED WITHOUT MAKING AN ADJUSTMENT EACH TIME THE SEAT BELT WAS USED. THE INSTRUMENT PANEL WOULD ILLUMINATE WHEN THE SEAT BELT WAS NOT SECURED AND ONCE THE ADJUSTMENT WAS MADE MANUALLY BY THE CONTACT THE WARNING SENSOR WOULD GO OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE FRONT DRIVER'S SIDE SEATBELT BUCKLE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15000.
NHTSA ODI #10577198
98,627 miles · Dec 11, 2013
Seat Belts
DRIVER SIDE SEAT BELT RETRACTING MECHANISM CAME APART AND MADE SEAT BELT INOPERATIVE. I BOUGHT A NEW SEAT BELT AND REPLACED IT. REPLACEMENT SEAT BELT DID SAME THING 9 MONTHS LATER. DEALER REPLACED IT FREE OF CHARGE. 3 MONTHS LATER SAME THING HAPPENED AGAIN. DEALER REPLACED IT AGAIN. 3 MONTHS LATER IT BROKE AGAIN. WARRANTY …
Read full complaint
DRIVER SIDE SEAT BELT RETRACTING MECHANISM CAME APART AND MADE SEAT BELT INOPERATIVE. I BOUGHT A NEW SEAT BELT AND REPLACED IT. REPLACEMENT SEAT BELT DID SAME THING 9 MONTHS LATER. DEALER REPLACED IT FREE OF CHARGE. 3 MONTHS LATER SAME THING HAPPENED AGAIN. DEALER REPLACED IT AGAIN. 3 MONTHS LATER IT BROKE AGAIN. WARRANTY ON PARTS IS FOR 1 YEAR SO I AM LIABLE TO REPLACE IT. I AM CONCERNED IF THEY ARE MADE THIS POORLY, WILL I BE PROTECTED IN CASE OF A COLLISION. THE MECHANISM IS HELD TOGETHER WITH SMALL PLASTIC TABS THAT BREAKOFF AND CAUSE THE SEAT BELT MECHANISM TO COME APART AND NOT RETRACT. *TR
NHTSA ODI #10555765
Mileage unknown · May 31, 2013
Seat Belts
PASSENGER SIDE SEAT BELT RECEIVER UNLATCHES SEEMINGLY AT RANDOM WHILE VEHICLE IS IN MOTION. THE RED BUTTON DOES NOT FULLY RETURN TO THE TOP OF THE UNIT WHICH MAY CAUSE THE UNLATCHING. BODILY INJURY COULD OCCUR IN THE EVENT OF A CRASH. THERE IS A NHTSA RECALL ON SOME 2001 FORD RANGERS FOR THE SAFETY BELT BUT THE SERVICE MANAGER O…
Read full complaint
PASSENGER SIDE SEAT BELT RECEIVER UNLATCHES SEEMINGLY AT RANDOM WHILE VEHICLE IS IN MOTION. THE RED BUTTON DOES NOT FULLY RETURN TO THE TOP OF THE UNIT WHICH MAY CAUSE THE UNLATCHING. BODILY INJURY COULD OCCUR IN THE EVENT OF A CRASH. THERE IS A NHTSA RECALL ON SOME 2001 FORD RANGERS FOR THE SAFETY BELT BUT THE SERVICE MANAGER OF THE LOCAL FORD DEALERSHIP CLAIMS THERE IS NO OUTSTANDING RECALL OR PROGRAMS ON THIS UNIT. *TR
I WAS DRIVING ON A RESIDENTIAL ROAD, COMING UP TO A THIRD SPEED BUMP. I STEPPED ON THE BRAKES TO SLOW DOWN A LITTLE BIT AND MY ENGINE REVVED AND STARTED GOING FASTER. I HIT THE BRAKES AND MY TRUCK SPUN OUT, OFF THE ROAD AND STOPPED. THE SEAT BELT HARNESS DID NOT LOCK UP; THE SHOULDER STRAP STAYED LOOSE, AND MY HEAD WAS BEING …
Read full complaint
I WAS DRIVING ON A RESIDENTIAL ROAD, COMING UP TO A THIRD SPEED BUMP. I STEPPED ON THE BRAKES TO SLOW DOWN A LITTLE BIT AND MY ENGINE REVVED AND STARTED GOING FASTER. I HIT THE BRAKES AND MY TRUCK SPUN OUT, OFF THE ROAD AND STOPPED. THE SEAT BELT HARNESS DID NOT LOCK UP; THE SHOULDER STRAP STAYED LOOSE, AND MY HEAD WAS BEING HIT AGAINST THE STEERING WHEEL. THEN, SOMEHOW I FELL OUT OF THE TRUCK. THIS HAS NEVER HAPPENED BEFORE. 05/17/13 I TOOK MY TRUCK IN TO GET THE RECALL FIXED, AND GET EVERYTHING CHECKED OUT. *TR
NHTSA ODI #10514258
104,000 miles · May 3, 2012
Seat Belts
TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THE DRIVERS SIDE SEAT BELT DID NOT LOCK IN PLACE AND OPENED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE FAILURE WAS NOT COVERED UNDER NHTSA CAMPAIGN ID NUMBER 01V227001(SEAT BELTS: FRONT: BUCKLE ASSEMBLY), SINCE IT WAS CLOSED. THE DEALER ADVI…
Read full complaint
TL* THE CONTACT OWNS A 2001 FORD RANGER. THE CONTACT STATED THE DRIVERS SIDE SEAT BELT DID NOT LOCK IN PLACE AND OPENED WHILE DRIVING. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT THE FAILURE WAS NOT COVERED UNDER NHTSA CAMPAIGN ID NUMBER 01V227001(SEAT BELTS: FRONT: BUCKLE ASSEMBLY), SINCE IT WAS CLOSED. THE DEALER ADVISED THE CONTACT THAT THE SEAT BELT COULD BE REPLACED FOR $600. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 104,000.
NHTSA ODI #10457245
135,000 miles · Dec 22, 2011
Seat Belts
SEAT BELT COMES UNLATCHED AT LOW SPEEDS UPON HITTING BUMPS. *TR
NHTSA ODI #10440978
82,000 miles · Jan 12, 2009
Air BagsSeat BeltsCrashInjury
TL*THE CONTACT OWNS A 2001 FORD RANGER. WHILE DRIVING 55 MPH, THE VEHICLE SLID ON A PATCH OF SNOW. THE REAR WHEELS LOST TRACTION AND THE VEHICLE FLIPPED OVER TWICE BEFORE CRASHING INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE STRUCK A TREE. THE DRIVER SUFFERED BRUISED RIBS ON THE LEFT SIDE AND A STIFF NECK. THE PA…
Read full complaint
TL*THE CONTACT OWNS A 2001 FORD RANGER. WHILE DRIVING 55 MPH, THE VEHICLE SLID ON A PATCH OF SNOW. THE REAR WHEELS LOST TRACTION AND THE VEHICLE FLIPPED OVER TWICE BEFORE CRASHING INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE STRUCK A TREE. THE DRIVER SUFFERED BRUISED RIBS ON THE LEFT SIDE AND A STIFF NECK. THE PASSENGER SUSTAINED MAJOR BRUISES EVERYWHERE INCLUDING HER BACK, LEGS, AND WRISTS. SHE ALSO SUSTAINED A SEVERE BUMP ON HER BACK AND MINOR CUTS. THE VEHICLE WAS TOWED AND IS CURRENTLY PARKED IN THE CONTACT'S DRIVEWAY. THE VEHICLE HAS NOT YET BEEN INSPECTED BY A MECHANIC OR DEALER. THE CONTACT IS ASSUMING THAT THE VEHICLE IS DESTROYED. HE WILL WAIT UNTIL THE SPRING TO CHECK THE FRAME ON THE VEHICLE; HOWEVER, HE BELIEVES THAT THE PASSENGER SHOULD NOT HAVE SUSTAINED THAT MUCH BRUISING AND INJURIES. THE CONTACT ALSO BELIEVES THAT THERE IS A DEFECT WITH THE PASSENGER SIDE SEAT BELT. DURING THE CRASH, THE SEAT BELT DID NOT TIGHTEN UP, WHICH ALLOWED THE PASSENGER'S BODY TO JERK AROUND AND BECOME BRUISED. A POLICE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 82,000. UPDATED 02/05/09 *BF UPDATED 02/09/09. *JB
NHTSA ODI #10254681
Mileage unknown · Mar 4, 2008
Seat BeltsService Brakes, HydraulicVehicle Speed Control
2001 FORD RANGER WITH SPEED CONTROL RECALL. CONSUMER STATES THAT HE WAS INFORMED THAT NO REPLACEMENT HARNESS WAS AVAILABLE. WHEN THE HARNESS WAS AVAILABLE AFTER THE REPAIR THE ABS AND AIRBAG WARNING LIGHTS ILLUMINATED. *KB THE CONSUMER STATED THE BRAKES HAVE STARTED TO GRAB ON INITIAL BRAKE APPLICATION. WHICH CAUSED THE VEHICL…
Read full complaint
2001 FORD RANGER WITH SPEED CONTROL RECALL. CONSUMER STATES THAT HE WAS INFORMED THAT NO REPLACEMENT HARNESS WAS AVAILABLE. WHEN THE HARNESS WAS AVAILABLE AFTER THE REPAIR THE ABS AND AIRBAG WARNING LIGHTS ILLUMINATED. *KB THE CONSUMER STATED THE BRAKES HAVE STARTED TO GRAB ON INITIAL BRAKE APPLICATION. WHICH CAUSED THE VEHICLE TO JOLT TO A STOP. THE CONSUMER WAS INFORMED THE HARNESS DISCONNECTION HAD NOTHING TO DO WITH THE WARNING LIGHTS ILLUMINATING. THE DEALER STATED THE AIR BAG PROBLEM WAS DUE TO A SEAT BELT PROBLEM. *JB
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER AND SPORT UTILITY VEHICLES, PICKUP TRUCKS, AND MINIVANS. EQUIPPED WITH SEAT BELTS SUPPLIED BY TRW. IT IS POSSIBLE THAT THE DRIVER'S AND/OR FRONT PASSENGER'S OUTBOARD SEAT BELT BUCKLE MAY NOT FULLY LATCH. FORD CROWN VICTORIA BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01 MERCURY GRAND MARQUIS BUILT AT ST. THOMAS ASSEMBLY PLANT FROM 4/17/00 - 5/29/01. LINCOLN TOWN CARS BUILT AT WIXOM ASSEMBLY PLANT FROM 3/27/00 - 5/30/01. LINCOLN NAVIGATORS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01. FORD WINDSTARS BUILT AT OAKVILLE ASSEMBLY PLANT FROM 3/23/00 - 5/30/01. FORD RANGERS BUILT AT TWIN CITIES PLANT FROM 3/28/00 - 5/30/01, AND ALSO AT THE EDISON PLANT FROM 3/13/00 - 5/25/01. FORD F-150 TRUCK BUILT AT NORFOLK PLANT FROM 4/18/00 - 5/25/00; AT ONTARIO PLANT FROM 5/10/00 - 5/28/01; AT KANSAS CITY PLANT FROM 9/11/99 - 5/25/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/9/01. FORD SUPER DUTY F-250, F-350, F-450, AND F-550 TRUCKS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 5/27/01; AND AT CUAUTITLAN PLANT FROM 5/16/00 - 6/19/01. FORD EXCURSIONS BUILT AT KENTUCKY PLANT FROM 4/17/00 - 10/2/00. FORD EXPEDITIONS BUILT AT MICHIGAN TRUCK PLANT FROM 4/11/00 - 5/31/01.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE RESTRAINT SYSTEM MAY NOT PROVIDE ADEQUATE OCCUPANT PROTECTION, INCREASING THE RISK OF PERSONAL INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL INSPECT THE FRONT OUTBOARD SEAT BELT BUCKLES AND IF THE BUCKLE FAILS THE INSPECTION PROCESS, IT WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 25, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLES WITH STEEL HOODS AND CERTAIN PICKUP TRUCKS EQUIPPED WITH SHEET MOLDING COMPOUND HOODS. A WIRE FORMED HOOD STRIKER COULD BE SUSCEPTIBLE TO FATIGUE FRACTURES. IF THE HOOD STRIKER FRACTURES, THE HOOD COULD FLY OPEN WHILE THE VEHICLE IS BEING DRIVEN.
Consequence & remedy
Consequence: A HOOD FLY-UP WHILE THE VEHICLE IS BEING OPERATED COULD RESULT IN REDUCED DRIVER VISIBILITY.
Remedy: DEALERS WILL REPLACE THE HOOD STRIKER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Seat Belts
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Seat Belts:front:buckle Assembly
DURING THE INITIAL RECALL CAMPAIGN IN 2001, THE SUBJECT VEHICLES WERE INSPECTED BY FORD DEALERSHIPS USING A TEST TOOL THAT WOULD DETECT A DEFECTIVE FRONT SEAT OUTBOARD SEAT BELT BUCKLE ASSEMBLY.APPROXIMATELY ONE MILLION VEHICLES PASSED THE INSPECTION TEST FOR ONE OR BOTH FRONT BUCKLES.SUBSEQUENT TO THE RECALL SERVICE ACTION, ODI RECEIVED 15 CONSUMER REPORTS ALLEGING THAT A PASSED INSPECTION BUCKLE SUBSEQUENTLY FAILED TO LATCH OR INADVERTENTLY UNLATCHED DURING USE.IN ADDITION, FORD HAS IDENTIFIED 543 OWNER AND FIELD REPORTS ALLEGING BUCKLE FAILURE SUBSEQUENT TO PASSING THE INSPECTION TEST.FORD TESTED AND EXAMINED OVER 100 WARRANTY-RETURNED BUCKLES AND FOUND THAT 44% OF THE BUCKLES HAD NO PROBLEM OR A CONDITION NOT RELATED TO THE RECALL INSPECTION (NON-LATCH RELATED BUCKLE DAMAGE OR FOREIGN CONTAMINATION).WARRANTY CLAIMS WERE HIGHEST DURING THE 18-MONTH PERIOD AFTER THE START OF THE RECALL (JULY 2001) AND HAVE BEEN DECLINING DURING THE PAST 24 MONTHS.OVER THE PAST 12 MONTHS, FORD HAS RECEIVED APPROXIMATELY 12 WARRANTY CLAIMS PER MONTH OUT OF A VEHICLE POPULATION OF ABOUT ONE MILLION.COMPLAINTS COUNTS ARE ALSO DECREASING.DURING THE PAST SEVEN MONTHS, ODI HAS RECEIVED ONLY TWO COMPLAINTS. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
RQ04011 · Front Seat Belt Buckle Assembly
Opened Oct 22, 2004 · Closed Feb 17, 2005
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
UNDER RECALL CAMPAIGN (01V227), FORD RECALLED APPROXIMATELY 1.3 MILLION VEHICLES TO INSPECT AND IF NECESSARY REPLACE THE FRONT DRIVER AND/OR PASSENGER SEAT BELT BUCKLE.APPROXIMATELY 1.1 MILLION OWNERS RESPONDED BY TAKING THEIR VEHICLES TO A DEALER FOR INSPECTION OF THE BUCKLE USING A SPECIALIZED BUCKLE TEST TOOL.FORD REPORTED THAT 829,927 VEHICLES HAD BOTH BUCKLES PASS THE TOOL TEST AND ANOTHER 167,336 VEHICLES HAD ONE BUCKLE PASS.ODI AND FORD RECEIVED COMPLAINTS ALLEGING SEAT BELT BUCKLE FAILURE SHORTLY AFTER PASSING THE ORIGINAL RECALL INSPECTION SERVICE.COMPLAINANTS ALLEGED THAT THE BUCKLE FAILED BY EITHER NOT LATCHING OR FALSE-LATCHING (PARTIAL ENGAGEMENT OF THE LATCH TO THE LATCH PLATE).A FALSE-LATCHED BUCKLE MAY RELEASE WITH MINOR MOVEMENT OR IMPACT AGAINST THE BUCKLE HOUSING INCLUDING INADVERTENT RELEASE WHILE THE VEHICLE IS IN MOTION.ODI IS UPGRADING THIS RECALL QUERY TO AN ENGINEERING ANALYSIS (EA05-004) TO FURTHER ANALYZE THE FIELD PERFORMANCE OF THOSE VEHICLES THAT FORD DEALERS PASSED (ONE OR BOTH BUCKLES) USING FORD'S INSPECTION TEST (997,263 VEHICLES).
2001 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration