2000 Ford Ranger

I RECENTLY REPLACED ROTTED PARTS OF THE UNDERSIDE OF MY FORD RANGE, SPRING SHACKLES, SCHOCKS AND SCHOCK MOUNT BRACKETS. I DID THIS REPAIR TO MAKE MU TRUCK SAFER, AFTER 3 WEEKS OF DRIVING WITH THE NEW REPAIRS THE FRAME BEGAN TO CRACK AND IS ABOUT TO SPLIT IN HALF... NOT SO SAFE. THE BODY IS IN GREAT SHAPE, BUT I CAN'T DRIVE THE TRUCK WITH THE FRAME IN ITS CURRENT CONDITION. BACK ROAD DRIVING 3 DAYS A WEEK.

I WAS DRIVING MY TRUCK DOWN A MAIN ROAD AND THERE WAS A SMALL POTHOLE.IT WAS ONLY ABOUT AN INCH DEEP BY ABOUT A FOOT AND ALL OF A SUDDEN MY TRUCK STARTED MAKING VERY LOUD NOISES GOING DOWN THE ROAD AND ALMOST SEEMING LIKE THE TRUCK DIDN'T WANT TO GO STRAIGHT. I PULLED OVER BECAUSE I WANTED TO CHECK IT AND HERE WAS A MASSIVE CRACK IN THE FRAME BEHIND THE SHACKLE MOUNT IN THE FRONT OF THE WHEEL WELL. THIS WAS CAUSED BY THE GAS TANK MOUNT THAT THE STRAP CONNECTS DO HOLDING DIRT AND MOISTURE BEHIND IT AND ROTTED OUT A HOLE IN THE FRAME. ALSO THE GAS TANK MOUNT ROTTED COMPLEATLY OUT AND IS NO LONGER THERE ON THE DRIVERS SIDE THE SAME PLACE THAT THE FRAME ROTTED OUT. THIS IS A BIG DEFECT BY FORD AS THERE IS NO WAY TO CLEAN IT OUT AND THE FRAME WILL JUST ROT EVEN THOUGH THE BODY OF THE TRUCK IS SPOTLESS AND RUST FREE BECAUSE I WASH THE UNDERCARRIAGE EVERY WEEK AS WELL AS THE WHOLE TRUCK. THIS IS EXTREMELY UNSAFE BECAUSE THE MOISTURE AND DIRT CONSISTAINTLY EAT AWAY AT THE FRAME. ALSO IT IS BAD ENOUGH THAT I POSSIBLY NEED TO TAKE THE TRUCK OFF THE ROAD EVEN THOUGH THE REST OF THE TRUCK IS PERFECT. IT IS VERY UNSAFE TO DRIVE AND I CAN'T BELIEVE FORD COULD HAVE OVER LOOKED THIS.

TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING 55 MPH, THE CONTACT HEARD A RATTLING NOISE UNDERNEATH THE VEHICLE. SUDDENLY, THE REAR DRIVER'S SIDE SHOCK DETACHED FROM THE VEHICLE. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE ENTIRE FRAME WAS ROTTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 177,000.

FRAME AND CROSSMEMBERS HAVE SEVERE FLAKING RUST AND FRAME ROT ON REAR SECTION OF FRAME BEHIND THE CAB. LEAF SPRING BRACKETS BROKE AND RIPPED OUT OF FRAME THIS SECTION HAS BEEN REPLACED APX 2 YEARS AGO. BACK SPARE TIRE REAR CROSSMEMBER HAS RUSTED COMPLETELY OUT AND IS IN THE PROCESS OF BEING REPLACED. BED SUPPORT CROSSMEMBERS ALL RUSTED ALMOST COMPLETELY OUT LEAVING BED WEAK. THIS IS IN THE PROCESS OF BEING REPLACED. GAS TANK CROSS MEMBER HAS RUSTED OUT AROUND BOTTOM OF MOUNT AND ALSO UP THE INSIDE OF THE FRAME RAILS. GAS TANK HOLDING STRAPS ARE IN PROCESS OF RUSTING OUT AND BREAKING. THESE ARE BEING REPLACED.

I RECENTLY BOUGHT THIS VEHICLE AND ONLY NOTICED HOW SEVERE THE RUST WAS AFTER THE PURCHASE. MY VEHICLE IS EXTREMELY RUSTED ON THE BOTTOM AND HAS SEVERAL RUST HOLES ON THE FRONT PASSENGER SIDE OF MY VEHICLE. KNOWING THAT AT ANY MOMENT ONE BUMP COULD FINISH THE JOB AND BLOW THE FRAME OFF IS NOT GREAT. A RECALL FOR THE EXTREME RUST DAMAGE WOULD BE GREATLY APPRECIATED SINCE I HAVE NO OTHER WAY TO FIX THIS.

WAS PULLING LAWN MOWER TRAILOR ON I-81 & CAR PULLED UP BESIDE ME, THEY WERE HISTERICLY TELLING ME TO PULL OVER, THAT MY BUMPER WAS COMING OFF, ALONG WITH TRAILER, MOWER & ALL. THIS COULD HAVE RESULTED IN MANY FATALITIES. THE FRAME OF MY TRUCK IS COMPLETELY RUSTED IN 1/2 ON DRIVER SIDE. NOT FAR FROM IT ON PASSENGER SIDE. GAS TANK STRAP RUSTED IN 1/2. NEEDLESS TO SAY, MY FORD TRUCK IS UNDRIVEABLE. THIS IS A GREAT INCONVENIENCE. PLEASE INVESTIGATE, & RECALL MY TRUCK FOR NEW FRAME. THANK U VERY MUCH....STILL A FORD MAN FOR NOW.