IllustrationThe contact owns a 2000 Ford Ranger. The contact stated that the entire subframe of the vehicle was corroded and was cracking and disintegrating. The dealer and the manufacturer were not notified of the failure. The vehicle was not diagnosed or repaired. The failure mileage was approximately 50,000.
2000 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 2000 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
180–25K
4725–50K
6250–75K
5175–100K
71100–150K
33150K+
282 reports with mileage · 388 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 139 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 105 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 72 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
86 crash reports12 fire reports64 injury reports
Structure complaints
105 reportsThe back end frame has completely rusted out, while the cab frame is in perfect condition. I have read about everyone that has a ranger from 1995-200 has had this issue. My truck only has 127k miles on it and has been kept in wonderful condition, and the bed frame has made it unsafe to drive.
TL* THE CONTACT OWNS A 2000 FORD RANGER. THE CONTACT NOTICED THAT THE SUBFRAME WAS CORRODED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 153,000.
FRAME HAS RUSTED TO THE POINT WHERE IT IS UNSAFE TO DRIVE.
BOTH THE BACK SEAT SMALL DOORS WERE LOCKED AND UNOPERABLE SINCE 2015 (THE DEALER REFUSED TO REPAIR WITHOUT PAYING FOR SERVICE- THEY SAID WILL COST $1,000.00 FOR EACH DOOR AND JUST TO EXAM COST. THAT WAS NOT THE REPAIR COST YET) 2020 IN AUGUST, PERHAPS, THE BACK GATE DOOR FOR THE TRUNK SUDDENLY COLLAPSED, FELLED OUT FROM THE R…
Read full complaint
BOTH THE BACK SEAT SMALL DOORS WERE LOCKED AND UNOPERABLE SINCE 2015 (THE DEALER REFUSED TO REPAIR WITHOUT PAYING FOR SERVICE- THEY SAID WILL COST $1,000.00 FOR EACH DOOR AND JUST TO EXAM COST. THAT WAS NOT THE REPAIR COST YET) 2020 IN AUGUST, PERHAPS, THE BACK GATE DOOR FOR THE TRUNK SUDDENLY COLLAPSED, FELLED OUT FROM THE ROLLER. THAT WAS THE PASSENGER SIDE OF THE BACK GATE TO THE BED OF THE TRUCK I HAD TO PUT BACK TO THE ROLLER. AND, IT IS NOT SURE THAT THE GATE IS STABLE CONDITION. UNDER THE DASHBOARD, THE CIGARETTE LIGHTER JUST TOUCHED AND COLLAPSED-BROKEN INSIDE UNDER THE DASHBOARD AND COULD NOT PULL IT OUT. SO, IT IS STILL INSIDE UNDER THE DASHBOARD (NOTICE: THAT FEATURE-THE CIGARETTE LIGHTER NOBODY USED SINCE BOUGHT THE VEHICLE- NON SMOKER OWNER). THE UNDER BODY VEHICLE COST A LOT TO REPAIR THROUGH THE YEARS. THE VEHICLE HAS ABOUT 120,000 MILES CURRENTLY.
FRAME IS ROTTED WITH ONLY 75,000 MILES ON VEHICLE. SEEMS AS TRUCK WILL BREAK IN HALF
TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING, A THUMPING NOISE WAS PRESENT COMING FROM THE VEHICLE. AFTER PARKING, IT WAS DISCOVERED THAT THE BED OF THE VEHICLE WAS DAMAGED AND MISALIGNED. ALSO, THE DRIVER AND PASSENGER SIDE FRAME BEHIND THE CAB WAS FRACTURED DUE TO RUST AND CORROSION. THE CAUSE OF THE FAILURES WAS NOT…
Read full complaint
TL* THE CONTACT OWNS A 2000 FORD RANGER. WHILE DRIVING, A THUMPING NOISE WAS PRESENT COMING FROM THE VEHICLE. AFTER PARKING, IT WAS DISCOVERED THAT THE BED OF THE VEHICLE WAS DAMAGED AND MISALIGNED. ALSO, THE DRIVER AND PASSENGER SIDE FRAME BEHIND THE CAB WAS FRACTURED DUE TO RUST AND CORROSION. THE CAUSE OF THE FAILURES WAS NOT DETERMINED. TODD JUDY FORD (7891 MACCORKLE AVE, CHARLESTON, WV) AND THE MANUFACTURER WERE BOTH NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 260,000. *TT*JB Broken frame
RUST ON FRAME, RADIATOR SUPPORT AND UNDER CARRIAGE.
MASSIVE AMOUNTS OF RUST ON FRAME, FRONT AND REAR BUMPER, LEAF SPRING SHACKLE BRACKETS, BRACKET HOLDING BODY TO FRAME., AND RADIATOR SUPPORT.
TAMARA RECALL MY PAINT IS BUBBLING AND CHIPPING
Official recalls
307V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
00V228001 · Seat Belts
Aug 18, 2000
VEHICLE DESCRIPTION: PASSENGER VEHICLES, LIGHT DUTY TRUCKS, SPORT UTILITY VEHICLES, AND MINI VANS EQUIPPED WITH TRW SEAT BELT BUCKLE ASSEMBLIES. THE BUCKLE BASE OF THESE SEAT BELT ASSEMBLIES WERE NOT PROPERLY HEAT TREATED AND THEREFORE DO NOT PASS THE LOAD BEARING REQUIREMENT OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES."
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, THE OCCUPANT MAY NOT BE PROPERLY RESTRAINED.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON CERTAIN SEAT BELT BUCKLES OF YOUR VEHICLE AND REPLACE ALL SEAT BELT BUCKLES THAT FALL WITHIN THE SUSPECT DATE CODE RANGE. OWNER NOTIFICATION BEGAN OCTOBER 26, 2000. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
00V094000 · Engine And Engine Cooling:cooling System
Mar 28, 2000
VEHICLE DESCRIPTION: PICKUP TRUCKS EQUIPPED WITH 2.5L OHC ENGINES. ENGINE COOLANT CIRCULATION THROUGH THE HEATER CIRCUIT IS PREVENTED BECAUSE OF A PLUGGED HEATER RETURN TUBE (WATER PUMP INLET TUBE) AT THE WATER PUMP. THESE VEHICLES DO NOT COMPLY WITH THE INTENT OF FMVSS NO. 103, "WINDSHIELD DEFROSTING AND DEFOGGING SYSTEMS."
Consequence & remedy
Consequence: AS A RESULT OF NO HEAT IN THE HEATER CIRCUIT, DEFROST PERFORMANCE IS COMPROMISED.
Remedy: DEALERS WILL REPLACE THE PLUGGED HEATER WATER RETURN TUBES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.