IllustrationFRAME ROT FROM RUST CREWMEMBERS ARE RUSTED THROUGH FUEL TANK STRAPS ARE RUSTED THROUGH BUMPER MOUNTS ARE BAD REAR FRAME IS ROTED OUT
1998 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 1998 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 576 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports29 fire reports34 injury reports
What owners actually said
576 reportsEXTREMELY RUSTED CAR FRAME
TL* THE CONTACT OWNS A 1998 FORD RANGER. WHILE DRIVING VARIOUS SPEEDS, A KNOCKING TYPE NOISE WAS PRESENT COMING FROM THE BED OF THE VEHICLE WHEN THE BRAKES WERE APPLIED. THE CONTACT INDICATED THAT THE VEHICLE FAILED INSPECTION DUE TO RUSTING AND CORROSION OF THE SUBFRAME AND CROSS MEMBERS. THE CAUSE OF THE FAILURES WAS NOT DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 1998 FORD RANGER. WHILE DRIVING VARIOUS SPEEDS, A KNOCKING TYPE NOISE WAS PRESENT COMING FROM THE BED OF THE VEHICLE WHEN THE BRAKES WERE APPLIED. THE CONTACT INDICATED THAT THE VEHICLE FAILED INSPECTION DUE TO RUSTING AND CORROSION OF THE SUBFRAME AND CROSS MEMBERS. THE CAUSE OF THE FAILURES WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 169,000.
THE TRUCK IS BURNING FUEL AND IDALING I CHANGED ALL THE COMPONENTS THAT THE MANUAL SAID AND THE ENGINE IS FINE IT HAVE TO BE A RECALL SOME WERE ITS WITH ALL FORD RANGERS EVERYONE IS HAVING THIS PROBLEM.
THE REAR FRAME OF THE TRUCK HAS ROTTED AWAY. THE REAR SUSPENSION AND BUMPER ARE ABOUT TO FALL OFF. THE BODY ITSELF IS IN EXCELLENT CONDITION. I DIDN'T FIND OUT UNTIL I STEPPED ON THE REAR BUMPER AND IT BEGAN SAGGING DOWN AND THEN REALIZED THAT A LARGE MAJORITY OF THE FRAMES CROSS MEMBERS WERE ALREADY GONE!
FRAME IS RUSTING OUT EVEN THOUGH THE REST OF THE TRUCK LOOKS GREAT . THE TRUCK HAS NOT BEEN DRIVEN IN WINTER BECAUSE I HAVE A WORK CAR WITH FRONT WHEEL DRIVE THAT I USE FOR THIS AND THE FRAME ON THAT VEHICLE IS IN BETTER CONDITION THAN MY RANGER. WE HAVE OWNED THE TRUCK SINCE 2002 AND IT'S A 1998 MODEL.
THE REAR FRAME COMPLETELY RUSTED OFF BETWEEN THE REAR SPRING SHACKLES AND REAR BUMPER, THE SPARE TIRE MOUNT IF ALMOST COMPLETELY RUSTED AWAY, AND THE GAS TANK CROSS MEMBER IS ALSO NEARLY RUSTED AWAY,1/2 IS MISSING ON THE PASSENGER SIDE. THE REAR SPRINGS DETACHED WHEN THE SHACKLED RUSTED AWAY. THE VEHICLE WAS STATIONARY
1998 XLT 4X4. BODY IN GREAT SHAPE. FRAME HAS RUST SO BAD REAR BUMBER AND SPARE TIRE CARRIER HAVE FALLEN OFF. BROKE BY THE LEAF SHACKLES ALSO. FRAME WAS COATED. UNABLE TO REPAIR. I AM BEYOND UPSET THAT FORD DOES NOT HAVE TO REPLACE THE FRAME, SOMETHING I AM UNABLE TO AFFORD.
THE REAR FRAME OF THE TRUCK FELL APART RUSTED AWAY
TL* THE CONTACT OWNS A 1998 FORD RANGER. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKES FAILED WHILE DEPRESSING THE PEDAL MULTIPLE TIMES. THE VEHICLE FINALLY CAME TO A STOP. THE FAILURE RECURRED AND THE VEHICLE CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR…
Read full complaint
TL* THE CONTACT OWNS A 1998 FORD RANGER. WHILE DRIVING AT APPROXIMATELY 30 MPH, THE BRAKES FAILED WHILE DEPRESSING THE PEDAL MULTIPLE TIMES. THE VEHICLE FINALLY CAME TO A STOP. THE FAILURE RECURRED AND THE VEHICLE CRASHED INTO ANOTHER VEHICLE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 214,299.
Official recalls
507V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
99V204000 · Power Train:automatic Transmission
Jul 28, 1999
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
99V062001 · Vehicle Speed Control
Mar 30, 1999
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
98V021000 · Equipment:other:labels
Feb 2, 1998
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
97V186001 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Oct 28, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE99045 · Steering Knuckle Separations
Opened Jul 6, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available