REAR FRAME HAS ROTTED OUT BY THE RIGHT REAR SPRING HANGER CAUSING SPRING TO GO TRU BED AND THE REAR AXLE TO BE DETACHED THE TRUCK AT THIS TIME IN IN OPERABLE DUE TO THIS WILL BE TRYING TO WELD AND REPLACE IT AS BEST AS CAN BE BUT THIS SEEMS TO BE A COMMON COMPLAINT IM READING ABOUT ONLINE SURE WISH FORD WOULD …
Read full complaint
REAR FRAME HAS ROTTED OUT BY THE RIGHT REAR SPRING HANGER CAUSING SPRING TO GO TRU BED AND THE REAR AXLE TO BE DETACHED THE TRUCK AT THIS TIME IN IN OPERABLE DUE TO THIS WILL BE TRYING TO WELD AND REPLACE IT AS BEST AS CAN BE BUT THIS SEEMS TO BE A COMMON COMPLAINT IM READING ABOUT ONLINE SURE WISH FORD WOULD STEP UP LIKE TOYOTA DID
NHTSA ODI #10495541
85,107 miles · Oct 20, 2012
SuspensionUnknown Or Other
SEVERELY RUSTED OUT REAR FRAME RAILS THAT WOULD NOT PASS PA. INSPECTION CODES. IN THE PAST 3 YEARS I HAVE REPLACED ALL THE REAR SPRING HANGERS AND MOUNTS. I UNDERSTAND THAT THIS IS A MAJOR PROBLEM WITH THE FORD RANGER LINE AND IS WHY IM SENDING THIS LETTER AND FORM.
NHTSA ODI #10481841
160,000 miles · Feb 20, 2011
Exterior LightingSeat BeltsUnknown Or Other
98' FORD RANGER: HAS A CRACKED FRAME ON THE REAR RIGHT SIDE. TRUCK MAKES LOUD NOISES WHEN DRIVING AND I AM AFRAID IT MAY BECOME WORSE OVER TIME OR COMPLETELY BREAK DOWN IN UNSAFE SPEEDS. I CAN NOT SELL IT, AS I WAS TRYING TO USE THE MONEY FOR A NEW VEHICLE DUE TO A NEW BABY IN OUR FAMILY. NO ONE WILL BUY SUCH A DEFECTIVE VEHI…
Read full complaint
98' FORD RANGER: HAS A CRACKED FRAME ON THE REAR RIGHT SIDE. TRUCK MAKES LOUD NOISES WHEN DRIVING AND I AM AFRAID IT MAY BECOME WORSE OVER TIME OR COMPLETELY BREAK DOWN IN UNSAFE SPEEDS. I CAN NOT SELL IT, AS I WAS TRYING TO USE THE MONEY FOR A NEW VEHICLE DUE TO A NEW BABY IN OUR FAMILY. NO ONE WILL BUY SUCH A DEFECTIVE VEHICLE. ALSO SEAT BELTS WILL NOT STAY LATCHED? ALSO THE INSIDE DOME LIGHT MELTS RIGHT THROUGH THE COVERING, WHERE TEMPERATURES MAKE THE PLASTIC COVER BUBBLE AND MELT.
NHTSA ODI #10383860
198,000 miles · Jan 29, 2011
Fuel System, GasolineUnknown Or OtherWheels
DISPITE PROPER MAINTENCE, I OBSERVED BODY RUST AND DECAY ON THE UNDERSIDE OF MY TRUCK FRAME. ALSO THE BRAKE LINES HAVE BEEN REPLACED DUE TO CORRUSION AND RUST INTO THE FRAME. SPARE TIRE BRACKETS HAVE RUSTED INTO AND THE TIRE FELL OFF. ALSO EVAP CANASTER BRACKET RUSTED INTO AND THE EVAP CANASTER FELL OFF.
NHTSA ODI #10380366
78,900 miles · Apr 20, 2006
Unknown Or Other
TWO WEEKS AGO WHEN LEAVING A PARKING LOT THE SPARE TIRE AFFIXED UNDER THE TRUCK BED OF MY 1998 FORD RANGER PICKUP WITH 79,000 MILES FELL OFF. WHEN I RETRIEVED THE TIRE AND METAL PIECE THAT HOLDS THE TIRE I OBSERVED THAT THE CABLE HAD APPARENTLY SNAPPED. HAD I BEEN ON AN INTERSTATE OR OTHER MAJOR HIGHWAY SOMEONE MIGHT HAVE BEEN K…
Read full complaint
TWO WEEKS AGO WHEN LEAVING A PARKING LOT THE SPARE TIRE AFFIXED UNDER THE TRUCK BED OF MY 1998 FORD RANGER PICKUP WITH 79,000 MILES FELL OFF. WHEN I RETRIEVED THE TIRE AND METAL PIECE THAT HOLDS THE TIRE I OBSERVED THAT THE CABLE HAD APPARENTLY SNAPPED. HAD I BEEN ON AN INTERSTATE OR OTHER MAJOR HIGHWAY SOMEONE MIGHT HAVE BEEN KILLED. WHEN I CONTACTED FORD THEY SAID THEY HAD NO OTHER REPORTS OF THIS TYPE FAILURE AND I WAS TO PAY A DEALER TO REPLACE THE DEVICE AND RECEIVE A 1 YEAR WARRANTY. ALTHOUGH THE VEHICLE IS OUT OF WARRANTY, I DO NOT FEEL THIS IS MY RESPONSIBILITY AS IT IS A SAFETY ISSUE AND THE MILEAGE AND AGE OF THE TRUCK INDICATE TO ME THAT THIS IS A SIGNIFICANT SAFETY ISSUE AND NOT JUST WEAR AND TEAR. I UNDERSTAND THAT THINGS HAPPEN, BUT A LIFE OR LIVES COULD HAVE BEEN LOST. I AM DEBATING AS HOW BEST TO SECURE MY SPARE AND CURRENTLY JUST CARRY IT IN MY TRUCK BED AND BRING IT INTO MY HOME AT NIGHT TO PREVENT THEFT. THE CABLE IS STILL IN THE TRUCK MECHANISM AND I HAVE THE METAL PIECE THAT HOLDS THE TIRE IN PLACE. THE DEALERSHIP WHERE I BOUGHT THE TRUCK RESPONDED WITH AN "OH WELL", FORD MOTOR COMPANY TOOK AN INTEREST, BUT AS NO ONE WAS INJURED AND THEY SAY NO OTHER COMPLAINTS OF THIS TYPE ARE IN THEIR RECORDS TOO BAD FOR ME. THEY REFERRED ME TO ANOTHER DEALERSHIP IN TOWN WHO WANTS $100 TO FIX IT. I WILL NOT PAY THEM OUT OF SPITE AND WILL TRY TO DETERMINE ANOTHER SAFE METHOD OF CARRYING MY TIRE. I DO NOT TRUST THEM. *JB
NHTSA ODI #10155761
Mileage unknown · Nov 15, 2000
Unknown Or OtherVisibility
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
NHTSA ODI #736366
Mileage unknown · Jul 5, 1999
Engine And Engine CoolingService Brakes, HydraulicUnknown Or Other
ON STARTING ENGINE HESITATED ,ALMOST STALLED THEN RACED WITH HIGH RPM,WHILE HUGE AMOUNTS OF WHITE THICK SMOKE AND HEAVY GASOLINE SMELL PRESENT.TRUCK STALLED.RESTARTED SAME PROBLEM WITH THE ADDITION OF A LARGE BLACK CLOUD OF SMOKE FROM TAIL PIPE ON PUSHING ACCELERATOR.THROTTLE STICKS CAUSING SURGING.DEALER REPLACED THROTTLE VALVE…
Read full complaint
ON STARTING ENGINE HESITATED ,ALMOST STALLED THEN RACED WITH HIGH RPM,WHILE HUGE AMOUNTS OF WHITE THICK SMOKE AND HEAVY GASOLINE SMELL PRESENT.TRUCK STALLED.RESTARTED SAME PROBLEM WITH THE ADDITION OF A LARGE BLACK CLOUD OF SMOKE FROM TAIL PIPE ON PUSHING ACCELERATOR.THROTTLE STICKS CAUSING SURGING.DEALER REPLACED THROTTLE VALVE.PROBELM PERSISTS. BRAKES MAKE GRINDING NOISE WHEN APPLIED,DEALER COULD NOT REPLICATE AFTER 4 VISITS THEY FINALLY ACKOWLEDGE PROBLEM AND HAD TO DO A COMPLETE BRAKE JOB.BRAKES ARE HARD NOW AND IT APPEARS THAT THE ANTI LOCKS DO NOT ENGAGE.REAR SLIDER LEAKS WATER INTO EXTRA CAB WHEN IT RAINS. VIBRATION HEARD FROM EX HAUST AREA,HAD TO HAVE THE HEAT SHIELD TIGHTENED. NOISE HAS RETURNED./
NHTSA ODI #708248
Mileage unknown · Jul 1, 1998
Unknown Or Other
WRONG WRENCH SUPPLIED WITH THE VEHICLE, USING IMPROPER TORQUE WRENCH TO TIGHTEN LUG NUTS COULD LEAD TO WARPING OF THE ROTOR/PADS IN THE FRONT WHEEL THUS RESULTING IN BRAKE FAILURE.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE99045 · Steering Knuckle Separations
Opened Jul 6, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1998 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration