IllustrationAT 40,000 MILES AND NOW AT 81000 MILES I NEED THE BALL JOINTS REPLACED, I HAVE NEVER HAD TO REPLACE BALL JOINTS ON ANY CAR UNDER 150,000 MILES MY ENTIRE LIFE, THERE IS A PROBLEM HERE, THIS IS A '98 FORD RANGER. *TR
1998 Ford Ranger
Owner reports · Recalls · Investigations
More warning signs than most Ranger years
Owner complaints for the 1998 Ford Ranger are substantially higher than the model-year median of 144.
About this comparison →How this year compares
Owner complaints by model year
Compare all Ranger years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 109 of 576 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 136 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 60 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
66 crash reports29 fire reports34 injury reports
Suspension complaints
52 reportsDT*: THE CONTACT STATED WHILE DRIVING AT ANY SPEED A SQUEAKING NOISE CAME FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE UPPER AND LOWER CONTROL ARMS, TIE RODS AND BEARINGS WERE REPLACED.
AT APPROXIMATELY 150,000 VEHICLE MILES, THE MIDDLE LEAF ON BOTH REAR SPRINGS HAS FRACTURED JUST IN FRONT OF THE REAR AXLE. DISCOVERED 5/27/2005 WHEN THE BROKEN PIECE FELL OUT OF THE LEFT SPRING. SUBSEQUENTLY DISCOVERED THE IDENTICAL PIECE WAS MISSING FROM THE RIGHT SIDE. RECOVERED PIECE SHOWS FATIGUE FAILURE.
WHILE TURNING, THE CONSUMER WOULD HEAR A LOUD POPPING NOISE/HEAVY VIBRATION COMING FROM THE FRONT END. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. THE CAUSE WAS NOT DETERMINED. *AK
WHEN THE BRAKE PEDAL WAS DEPRESSED THE ENTIRE VEHICLE VIBRATED. A MECHANIC TEST DROVE THE VEHICLE, AND INDICATED THAT SOMETHING WAS WRONG, BUT HAS TO INSPECT THE VEHICLE TO LOCATE THE CAUSE OF THE VIBRATION.*AK
PASSENGER SIDE LOWER CONTROL ARM JOINT GREASE PROTECTOR HAS DETERIORATED ALLOWING MOISTURE AND DIRT TO ENTER THE JOINT.*AK
WHILE DRIVING IN A PARKING LOT AND MAKING A LEFT WITHOUT WARNING FRONT END OF THE TRUCK MALFUNCTIONED. INVESTIGATOR FROM FORD INVESTIGATED VEHICLE, STATING THAT MALFUNCTION RESULTED IN THE MANUFACTURING OF THE TRUCK AND NOT THE DRIVER.*AK
AT 30000, THE FIRST SERPENTINE BELT WAS REPLACED. THE DEALER SAID THERE WAS NOTHING THEY COULD DO BECAUSE THE BELT WAS NOT COVERED UNDER THE WARRANTY. THE BELT HAS BEEN REPLACED TWICE MORE SINCE THEN, AND THE VEHICLE ONLY HAS 52000 MILES. AROUND 40000 MILES, THE FRONT SUSPENSION STARTED CLUNKING EVERY TIME YOU HIT A BUMP. TH…
Read full complaint
AT 30000, THE FIRST SERPENTINE BELT WAS REPLACED. THE DEALER SAID THERE WAS NOTHING THEY COULD DO BECAUSE THE BELT WAS NOT COVERED UNDER THE WARRANTY. THE BELT HAS BEEN REPLACED TWICE MORE SINCE THEN, AND THE VEHICLE ONLY HAS 52000 MILES. AROUND 40000 MILES, THE FRONT SUSPENSION STARTED CLUNKING EVERY TIME YOU HIT A BUMP. THE MECHANIC WHO INSPECTED THE FRONT END STATED THAT THE FRONT SUSPENSION BUSHINGS ARE WHAT IS CAUSING THE CLUNK.*AK
AFTER READING OTHER CUSTOMER COMPLAINTS REGARDING THE FORD RANGER , I FEEL I MUST REPAIR THE FRONT WHEELS ON MY TRUCK. THE FRONT WHEELS STARTED MAKING LOUD NOISES WHEN THEY TURNED LEFT OR RIGHT.. I WAS TOLD THE WHEEL BEARINGS NEEDED REPLACING. THIS IS EXPENSIVE. THIS CAR ONLY HAS 27,000.00 MILES ON IT AND REPLACING THE WHEEL …
Read full complaint
AFTER READING OTHER CUSTOMER COMPLAINTS REGARDING THE FORD RANGER , I FEEL I MUST REPAIR THE FRONT WHEELS ON MY TRUCK. THE FRONT WHEELS STARTED MAKING LOUD NOISES WHEN THEY TURNED LEFT OR RIGHT.. I WAS TOLD THE WHEEL BEARINGS NEEDED REPLACING. THIS IS EXPENSIVE. THIS CAR ONLY HAS 27,000.00 MILES ON IT AND REPLACING THE WHEEL BEARINGS SOUND A LITTLE TO MAJOR FOR A LOW MILEAGE CAR. YET FOR MY SAFETY AND OTHERS I NEED TO HAVE THIS DONE.*AK
THE REAR AXLE OF THE VEHICLE FELL APART WHILE THE CONSUMER WAS TRAVELING, RESULTING IN LOSS OF CONTROL. *YH
Official recalls
507V336000 · Vehicle Speed Control
Aug 3, 2007
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
99V204000 · Power Train:automatic Transmission
Jul 28, 1999
VEHICLE DESCRIPTION: ELECTRIC VEHICLES. THE TRANSAXLE MAY HAVE BEEN MANUFACTURED WITH THE PARK DETENT SPRING MISALIGNED. IF THE SPRING IS MISALIGNED, THE PARK MECHANISM MAY NOT ENGAGE WHEN THE SHIFT LEVER IS PLACED IN THE PARK POSITION.
Consequence & remedy
Consequence: IF THE PARK MECHANISM DOES NOT ENGAGE AND THE VEHICLE OPERATOR HAS NOT APPLIED THE PARKING BRAKE, THE VEHICLE COULD ROLL FREE AS IF IN NEUTRAL.
Remedy: DEALERS WILL INSPECT THE TRANSAXLE AND ANY WITH MISALIGNED PARK DETENT SPRINGS WILL BE REPLACED.
99V062001 · Vehicle Speed Control
Mar 30, 1999
VEHICLE DESCRIPTION: CERTAIN 1997-1999 RHD EXPLORER EQUIPPED WITH 4.0L OHV/SOHC ENGINES AND CRUISE CONTROL BUILT FROM MAY 29, 1996 THROUGH MARCH 4, 1999; 1998-1999 EXPLORER/MOUNTAINEERS EQUIPPED WITH 4.0L OHV/SOHC OR 5.0L ENGINES OR 1998-1999 RANGERS EQUIPPED WITH 2.5L, 3.0L FFV/EFI OR 4.0L ENGINES AND CRUISE CONTROL BUILT FROM JANUARY 5, 1998 THROUGH MARCH 4, 1999; 1998-1999 MUSTANGS EQUIPPED WITH 3.8L, 4.6L 2-VALVE OR 4-VALVE ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; 1999 F250/F350/F450/F550 (OVER 8,500 LBS.) TRUCKS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999; AND 1999 F-53 STRIPPED CHASSIS EQUIPPED WITH 5.4L OR 6.8L ENGINES AND CRUISE CONTROL BUILT FROM MARCH 2, 1998 THROUGH MARCH 4, 1999. A CRUISE CONTROL CABLE CAN INTERFERE WITH THE SPEED CONTROL SERVO PULLEY AND NOT ALLOW THE THROTTLE TO RETURN TO IDLE WHEN DISENGAGING THE CRUISE CONTROL.
Consequence & remedy
Consequence: IF THE CRUISE CONTROL IS USED AND THIS CONDITION IS PRESENT, A STUCK THROTTLE COULD RESULT, WHICH COULD POTENTIALLY RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CRUISE CONTROL CABLES. AT THE PRESENT TIME, THE REPLACEMENT CABLES ARE NOT AVAILABLE. CUSTOMERS ARE BEING ADVISED NOT TO USE THE CRUISE CONTROL SYSTEM UNTIL A REPLACEMENT CAN BE MADE.
98V021000 · Equipment:other:labels
Feb 2, 1998
VEHICLE DESCRIPTION: LIGHT DUTY FOUR-WHEEL DRIVE PICKUP TRUCKS EQUIPPED WITH OFF-ROAD OPTION. THE TIRE AND RIM IDENTIFICATION INFORMATION IS INCORRECT ON THESE VEHICLES. THIS DOES NOT COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: THE 16" TIRES COULD NOT BE INFLATED ON THE SPECIFIED 15X7.0J RIM.
Remedy: OWNERS WILL BE SENT A SAFETY CERTIFICAITON LABEL PARTIAL OVERLAY WHICH WILL CONTAIN THE CORRECT RIM SIZE, AND INSTRUCTIONS FOR AFFIXING THIS LABEL TO THE VEHICLE. IF AN OWNER SO DESIRES, THEIR FORD DEALER CAN INSTALL THE LABEL FOR THEM.
97V186001 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Oct 28, 1997
VEHICLE DESCRIPTION: LIGHT DUTY PICKUP TRUCKS EQUIPPED WITH 4.0L ENGINES. THE FLEXIBLE SECTION OF THE CHASSIS MOUNTED FUEL LINE THAT CONNECTS TO THE ENGINE WAS ROUTED TOO CLOSE TO THE EXHAUST MANIFOLD. THE LINE COULD CONTACT THE MANIFOLD.
Consequence & remedy
Consequence: THIS COULD POTENTIALLY RESULT IN DAMAGE TO THE FUEL LINE, OR IN SOME CASES, CAUSE A FUEL LEAK. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL CLIP TO HOLD THE FUEL LINE IN THE INTENDED DESIGN POSITION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE99045 · Steering Knuckle Separations
Opened Jul 6, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
There is no summary currently available