HOW CAN THE FRAME OF MY TRUCK RUST OUT FASTER THAN THE BED OR CAB. THE CAB MOUNTS ARE GONE. THE SHACKLES OF THE LEAF SPRINGS ARE PAPER THIN AND READY TO COLLAPSE. WHEN I DRIVE DOWN THE ROAD AND HIT A BUMP IT SOUNDS LIKE THE CAB IS GOING FALL TO THE GROUND. I AM AFRAID ONE OF THESE DAYS , I'LL GET IN AN ACCIDENT AND THE ENTIRE CA…
Read full complaint
HOW CAN THE FRAME OF MY TRUCK RUST OUT FASTER THAN THE BED OR CAB. THE CAB MOUNTS ARE GONE. THE SHACKLES OF THE LEAF SPRINGS ARE PAPER THIN AND READY TO COLLAPSE. WHEN I DRIVE DOWN THE ROAD AND HIT A BUMP IT SOUNDS LIKE THE CAB IS GOING FALL TO THE GROUND. I AM AFRAID ONE OF THESE DAYS , I'LL GET IN AN ACCIDENT AND THE ENTIRE CAB IS GOING TO FLY OFF THE TRUCK. THE MOTOR HAS OUTLASTED THE FRAME. MAKE LAUGH.
NHTSA ODI #10904264
140,000 miles · Feb 17, 2012
Structure
THE FRAME HAS RUSTED UNTIL THE TRUCK IS NO LONGER DRIVABLE. IT IS FOUR WHEEL DRIVE AND I HAVE ALREADY REPLACED THE REAR SPRING SHACKLES WHEN THEY RUSTED OUT IN 2006. I BOLTED A PIECE OF ANGLE TO THE TRANSMISSION SUPPORT TO REPAIR IT AFTER IT RUSTED INTO AND DROPPED THE TRANSMISSIOM AND TWISTED THE DRIVE SHAFT INTO WHILE DRIVING …
Read full complaint
THE FRAME HAS RUSTED UNTIL THE TRUCK IS NO LONGER DRIVABLE. IT IS FOUR WHEEL DRIVE AND I HAVE ALREADY REPLACED THE REAR SPRING SHACKLES WHEN THEY RUSTED OUT IN 2006. I BOLTED A PIECE OF ANGLE TO THE TRANSMISSION SUPPORT TO REPAIR IT AFTER IT RUSTED INTO AND DROPPED THE TRANSMISSIOM AND TWISTED THE DRIVE SHAFT INTO WHILE DRIVING DOWN THE ROAD I TOOK IT UP ON 2/9/2012 TO GET A NEW EXHAUST PUT ON IT AND AND GOT A CALL FROM THE SERVICE GARAGE TO COME LOOK AT THE UNDER CARRAIGE OF THE TRUCK. THE BED HAS A RUSTED OUT SUPPORT, THE TRANSMISSION SUPPORT CROSSMEMBER IS RUSTED INTO ON THE OTHER SIDE FROM WHERE I REPAIRED IT BEFORE AND THE FRONT SUPPORT CROSSMEMBER UNDER THE RADIATOR IS RUSTED OUT. THE SUPPORT FOR THE SPARE TIRE RUSTER OUT YEARS AGO. THE ENGINE AND DRIVE TRAIN WORK GREAT BUT THE TRUCK IS SCRAP NOW BECAUSE THERE IS NOTHING LEFT OF THE FRAME AND BODY SUPPORTS. *TR
NHTSA ODI #10448299
93,000 miles · Jun 17, 2011
Power TrainService Brakes, HydraulicStructure
ON MY 1993 FORD RANGER,MY BRAKE & CLUTCH MOUNTING BRACKET FAILED DUE TO STRESS FRACTURE OF WELDS. THIS CAUSED LOSE OF BRAKES AND USE OF CLUTCH. FORD HAS A RECALL ON FAILURE OF STUDS ON THE POWER BRAKE BOOSTER THAT IS MOUNTED ON THIS BRACKET, BUT NOTHING ON THE FAILURE OF THE BRACKET. *TR
NHTSA ODI #10407219
138,761 miles · May 31, 2011
Structure
TL* THE CONTACT OWNS A 1993 FORD RANGER. THE CONTACT STATED THE FRONT FRAME WAS CORRODED AND RUSTED. THE DEALER WAS CONTACT AND OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 138,761. UPDATED 07/08/11*LJ UPDATED 08/05/11
NHTSA ODI #10403810
70,000 miles · Mar 23, 2011
Structure
FRAME IS ROTTING - REPAIRED THE REAR SECTION AND NOW THE FRONT IS ROTTING WHERE THE SHOCKS/SPRINGS ARE MOUNTED TO THE FRAME. THE ENTIRE FRAME IS A MESS BUT THE REST OF THE BODY IS GOOD. *TR
NHTSA ODI #10392689
Mileage unknown · Jul 17, 2010
Structure
REAR BUMPER LITERALLY FELL OFF. INVESTIGATION REVEALED NON REPAIRABLE RUST TO FRAME AND BUMPER BRACKETS. FRAME IS SEVERELY RUSTED. *TR
NHTSA ODI #10343775
84,000 miles · Jan 5, 2005
Structure
WHEN USING THE TAILGATE, THE LEFT TAIL GATE SUPPORT STRAP SNAPPED. THIS CAUSED THE TAILGATE TO FALL. PLEASE PROVIDE MORE INFORMATION. *JB THE CONSUMER STATED THAT THE CABLE WAS CORRODED UNDER THE PLASTIC COVER. *TC
NHTSA ODI #10105022
Mileage unknown · Jun 26, 2002
Parking BrakeStructure
WHEN PARKED AND EMERGENCY BRAKE APPLIED VEHICLE WILL ROLL IN EITHER DIRECTION IF PARKED AT A SLIGHT INCLINE OR DOWN GRADE.*AK CONSUMER IS AWARE THERE IS A CAMPAIGN 94591 RELATING TO THE CONDITION. ADDITIONAL LEAVES ARE BUILDING UP IN THE HEATER COMPARTMENT. *TT
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
DURING EXTREME COLD, NORTHERN CLIMATE WINTER CONDITIONS, ICE CAN FORM IN THE THROTTLE BODY OF THE ENGINE CAUSING THE THROTTLE PLATE TO REMAIN IN THE HIGHWAY CRUISING POSITION AFTER THE ACCELERATOR IS RELEASED OR THE SPEED CONTROL IS DEACTIVATED.
Consequence & remedy
Consequence: THE VEHICLE STOPPING DISTANCES CAN BE INCREASED POSSIBLY RESULTING IN AN ACCIDENT.
Remedy: DEALERS WILL REPLACE THE AIR INTAKE DUCT AND VALVE ASSEMBLY WITH REVISED UNITS.
THE PARKING BRAKE CONTROL SELF-ADJUST PAWL DOES NOT LINE UP PROPERLY WITH THE SELF-ADJUST RACHET CAUSING THE PAWL TO SLIP OVER ONE OR MORE TEETH IN THE RACHET.
Consequence & remedy
Consequence: WHEN THE ABOVE OCCURS, IT CAN RESULT IN PARKING BRAKE SYSTEM INEFFECTIVENESS. THE PARKING BRAKE WILL NOT HOLD THE VEHICLE, CAUSING THE VEHICLE TO ROLL FREELY, IF THE TRANSMISSION IS NOT LEFT IN GEAR.
Remedy: A WEDGE WILL BE INSTALLED WHICH WILL SERVE TO LOCK THE PARKING BRAKE SELF-ADJUST MECHANISM PAWL INTO ENGAGEMENT WITH THE RACHET. ALSO, OWNERS WILL BE ADVISED TO RELEASE AND REAPPLY THE PARKING BRAKE WHENEVER TOOTH SKIP OCCURS AND WILL BE REMINDED TO ALWAYS TURN OFF THE ENGINE AND LEAVE THE VEHICLE IN GEAR WHEN THE VEHICLE IS PARKED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE93045 · Steering Gear Bolt Broken
Opened May 7, 1993 · Closed Aug 31, 1993
Status: closed (inferred from source dates) · Steering
There is no summary currently available
1993 Ford Ranger Problems, Complaints & Recalls | Skip That Year
Illustration