2014 Ford Flex

The contact owns a 2014 Ford Flex. The contact stated that on various occasions, the vehicle failed to start. The contact also stated that the vehicle failed to unlock using the key fob. The contact had a locksmith go to her residence, and the key fob battery, and two unknown fuses were replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that on various occasions, the "No Key Detected" message was displayed. The vehicle was taken to a local dealer, where the failure could not be duplicated. The contact stated that the failure persisted and that when the vehicle was taken back to the dealer, it was diagnosed that the key fob needed to be replaced. The vehicle was repaired; however, the contact stated that the failure reoccurred. The vehicle was towed back to the dealer, where it was diagnosed that the remote function actuator module needed to be replaced; however, the part for the repair was discontinued. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 99,000.

Driving down road at 45MPH, vehicle lost power, motor quite running. Due to being on 4 lane divided road, and cars all around, I quickly hit my hazard lights, put it in neutral and coasted best I could and was able to turn on a side road to safety. This was very dangerous. Dash lights were on, no warning lights, messages before, during or after event. Tried restarting vehicle and it cranked away. Figured out had to repush the push start button to keep it from cranking away longer. Towed to local Ford dealer. They determined cause to be Fuel Pump Driver Module failed, (explains engine stop since there was no fuel supply, and needed replacement. In addition I had another issue, they found water pump was leaking out weep hole. I then discovered they built the water pump into the engine block, behind the timing chain. It takes 13 hours to replace, and if you don't replace, the water goes into the engine oil. Very bad design, knowing it would need to be replaced. Cost over $2500 and 1 week to change a water pump! Ridiculous. I know a class action lawsuit has been filed-while not a safety issue directly, I think many people will not change it (due to expense), and then the engine blows up while driving creating a safety hazard.

The contact owns a 2014 Ford Flex. The contact stated while driving approximately 20 MPH, the vehicle experienced a loss of power steering assist, requiring excessive force while steering the vehicle. No warning lights were illuminated. The vehicle had not yet been taken to an independent mechanic or local dealer to be diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 150,000.

The contact owns a 2014 Ford Flex. The contact stated that while driving approximately 40 MPH, the steering wheel became inoperable. There were no warning lights illuminated. The contact stated the failure never occurred during inclement weather. While the vehicle was at the car wash, the failure self-corrected. The vehicle was taken to the local dealer where it was diagnosed that the steering module and steering rack needed to be replaced. The vehicle was not repaired. The manufacturer was contacted, and the contact was referred to NHTSA Hotline. The failure mileage was approximately 100,000.

We were experiencing an intermittent electrical issue where the vehicle would crank but not start every time. The vehicle was towed to the dealership on two separate occasions and the mechanic was unable to properly test the vehicle and/or recreate the problem. After some further research, I found a recall on slightly older VIN numbers for this model Flex. The recall for the Fuel Pump Control Module: Fuel system, gasoline: Delivery: Fuel pump Recall date 2016-08-24 Recall no. 16V621000 Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump. Recall consequence: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash. Recall action: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31. In addition, I located a forum of owners who were experiencing the same issues. These individuals either replaced the component themselves or had the service performed by a mechanic. https://www.fordflex.net/forums/viewtopic.php?p=212782&sid=6b719ac74855e58a8f26cce53f76b60f#p212782 We are the single owners of this vehicle, and the miles are low at 38,036. I replaced the Fuel Pump Control Module GA8Z-9D370-A several days ago and it started immediately, without exception or issue. I saved the part in case the NHTSA needs it for any testing. I would urge the consideration of expanding the coverage of recalls to include more VINs since the risk for engine shutdown could cause a crash.

The contact owns a 2014 Ford Flex. The contact stated that while the vehicle was parked in the garage, there was fluid leaking underneath. No warning light was illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that the water pump assembly and timing chain needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The approximate failure mileage was 100,000.

My vehicle steering system had a loss of communication/loss of power to the electrical power steering. It nearly resulted in a very bad accident at an elementary school drop-off. I recorded a video of what is happening after the fact for documentation. Basically, it sounds as though there is a known communication issue from the fully electric steering to the primary electrical system on the vehicle. It appears from my reading that this is a known problem. I would strongly consider this to be a recall issue as it could be catastrophic and potentially deadly.

The contact owns a 2014 Ford Flex. The contact stated while approaching the vehicle, he noticed a fluid leak underneath the engine. The contact took the vehicle to an independent mechanic and was informed that the water pump and timing chain needed to be replaced. The vehicle was not repaired. The contact called the local dealer and made them aware of the failure. The manufacturer had not been informed of the failure. The failure mileage was approximately 130,000.