2012 Ford Flex

There is serious safety trouble occurring with the power steering components, and the brake system. I went to the Ford dealership and they said the recalls weren’t fixed back in 2015. And those recalls are the same issues that are occurring with my 2012 Ford Flex SE now. I just bought this vehicle and there is grinding noise when steering my vehicle and the ABS brake system comes on as soon as I crank up the vehicle and the brake goes down to the floor too loosely. The dealership says these potential recalls were noted for this 2012 Ford Flex in 2015. But the owner at the time didn’t have them fixed then because not all 2012 Ford Flex received the recalls at the same time. And the power steering components and brake system problems are very unsafe while I’m driving the vehicle and as I was told could cause a fatal car accident if not fixed.

The contact owns a 2012 Ford Flex. The contact stated that while driving at approximately 30 MPH, the ABS and the ESC warnings illuminated. The contact stated that she had recently heard an abnormal grinding sound while turning the steering wheel. The contact had taken the vehicle to an independent mechanic, where it was diagnosed and determined that the ABS sensor needed to be replaced. The contact stated that the mechanic had heard the abnormal sound coming from the steering wheel but had not run a diagnostic test. The vehicle was not repaired. The contact had researched online and had related the failure to NHTSA Campaign Number: 15V340000(Steering), however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.

Ford said the recall was fixed 10 years ago, however it went out on me last night. It's been towed to the Folsom Ford dealership in California, they quoted me $3,000 to fix my power steering assistant failure that had a Safety recall and it was a 'safety recall'. I couldn't steer my car. Very scary! please investigate this and make sure that it was fixed right the first time. it should not have gone out. I hardly drive my car. thank you

The contact owns a 2012 Ford Flex. The contact stated while the vehicle was parked, the vehicle intermittently became difficult to maneuver. The failure occurred on several occasions, including while the contact was driving. An unknown warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed that the power steering control module needed to be reprogrammed. The contact researched and was made aware of NHTSA Campaign Number: 15V340000 (Steering); however, the VIN was not included. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 40,000.

The contact owns a 2012 Ford Flex. The contact stated while his granddaughter was driving 10 MPH and attempting to leave a parking lot, the steering wheel became difficult to maneuver. After the failure occurred, the "Power Steering Assist Fault" message was displayed. The vehicle was parked, and then the contact drove the vehicle to an independent mechanic. The contact was awaiting a diagnostic test from the independent mechanic but was informed that the rack and pinion might need to be replaced and the power train control module needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The contact researched online and became aware of NHTSA Campaign Numbers: 15V340000 (Steering) however, the VIN was not included in the recall. The failure mileage was approximately 108,000.

I was driving around 55 and suddenly lost control and fish tailed to the right, then to the left over the center line, then back to the right. Luckily no other vehicles on the road. The rear driver side toe link broke. I discovered there's a recall for this exact problem with the exact possible worst case scenario that I went through. [FORD RECALL CODE: 2oSo4] This recall includes "2013-18 Ford Flex and Lincoln MKT vehicles built at Oakville Assembly Plant, Sept. 12, 2011, to June 1, 2017" My vehicle was manufactured at the same plant in 02/12 but for some reason is not qualified. I think my 2012 model needs to be included in this recall, obviously. I talked with Ford Dealer and Ford Customer Service and they said they would pass this info to NHTSA. I had both links replaced at a local mechanic and hope to get reimbursed in the future.

The contact owns a 2012 Ford Flex. The contact stated while driving 60 MPH, the steering wheel stiffened while attempting to steer the vehicle to the left. The power steering failure message was displayed. The contact used excessive force to steer the vehicle to the shoulder of the highway where the vehicle remained. The contact called the dealer and was informed that the VIN was not included in NHTSA Campaign Number: 15V340000 (Steering). The contact was referred to the manufacturer who then referred the contact to the NHTSA Hotline for assistance. The vehicle was not repaired. The failure mileage was unknown.

Vehicle power steering will stop working while driving and notification of (power steering assist failure) will appear. Vehicle becomes extremely unsafe to operate as the steering wheel is very difficult to move. I reached out to Ford and was advised that the recall for this was already repaired and a second recall was opened for vehicles that still had the issue. They advised that the recall only extended the warranty to 10 years and my vehicle is a few months past the 10 year mark with exceptions only made for mileage. My vehicle only has 48,000 miles.