2014 Ford Flex

The contact owns a 2014 Ford Flex. The contact stated that on various occasions, the vehicle failed to start. The contact also stated that the vehicle failed to unlock using the key fob. The contact had a locksmith go to her residence, and the key fob battery, and two unknown fuses were replaced. The vehicle was repaired; however, the failure reoccurred. The contact stated that on various occasions, the "No Key Detected" message was displayed. The vehicle was taken to a local dealer, where the failure could not be duplicated. The contact stated that the failure persisted and that when the vehicle was taken back to the dealer, it was diagnosed that the key fob needed to be replaced. The vehicle was repaired; however, the contact stated that the failure reoccurred. The vehicle was towed back to the dealer, where it was diagnosed that the remote function actuator module needed to be replaced; however, the part for the repair was discontinued. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The approximate failure mileage was 99,000.

We were experiencing an intermittent electrical issue where the vehicle would crank but not start every time. The vehicle was towed to the dealership on two separate occasions and the mechanic was unable to properly test the vehicle and/or recreate the problem. After some further research, I found a recall on slightly older VIN numbers for this model Flex. The recall for the Fuel Pump Control Module: Fuel system, gasoline: Delivery: Fuel pump Recall date 2016-08-24 Recall no. 16V621000 Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump. Recall consequence: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash. Recall action: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31. In addition, I located a forum of owners who were experiencing the same issues. These individuals either replaced the component themselves or had the service performed by a mechanic. https://www.fordflex.net/forums/viewtopic.php?p=212782&sid=6b719ac74855e58a8f26cce53f76b60f#p212782 We are the single owners of this vehicle, and the miles are low at 38,036. I replaced the Fuel Pump Control Module GA8Z-9D370-A several days ago and it started immediately, without exception or issue. I saved the part in case the NHTSA needs it for any testing. I would urge the consideration of expanding the coverage of recalls to include more VINs since the risk for engine shutdown could cause a crash.

Approximately 2 months ago car would not start. Towed to dealer on Friday. Dealer evaluated it on Monday but car resumed starting. Retrieved car. This morning problem returned. Having already done a lot of research on this apparently common issue it seems most of the time it is the fuel pump control module located behind the plastic trim on the passenger side B pillar. A replacement part was acquired from a Ford Parts Dealer and installed into the car. Car starts and runs fine now.

The contact owns a 2014 Ford Flex. The contact stated that the dealer had previously replaced the master window switch; however, the failure recurred, preventing all four windows from rolling up or down as well as the sunroof from opening. The vehicle was taken to the dealer where it was diagnosed that the body control module (BCM) needed to be replaced; however, the part was no longer manufactured. The vehicle was not repaired. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA. The failure mileage was approximately 95,000.

The Driver Door Ajar light comes on even when the door has been closed. It takes a few times of closing the door hard before the light goes off. The alert means the interior lights stay on and it keeps alerting me that I'm not in Park. If I can't get the alert light to go off, this would be a hazard to driving, especially at night.

BOUGHT USED WITH 65,000 MILES, AT 75,000 MILES PASSENGER BACK DOOR SENSOR WENT BAD CAUSING CAR TO SAY "RIGH BACK DOOR AJAR" AND THE LIGHTS STAY ON, DOORS DO NOT LOCK WHEN DRIVING, ALARM GOES OFF INTERMITTENTLY. WHY HAS FORD NOT DONE SOMETHING ABOUT THIS - CLEARLY A PROBLEM. ALSO THE 2ND ROW SEAT BELTS HAVE BEEN A NIGHTMARE. KIDS ALWAYS GETTING STUCK - CNA'T UNLATCH THEM. ONE OF THE RECEPTECLES JUST FELL APART - NOT SAFE! WHY HASN'T FORD DONE SOMETHING ABOUT THIS. I OWN 5 FORD VEHICLES AND THE OLDER VEHICLES RUN GREAT - NO ISSUES. SEEMS LIKE FROM 2012 AND NEWER THERE IS NOTHING BUT PROBLEMS. WHAT HAPPENED TO THE QUALITY AND CARE FROM FORD?