The contact owns a 2013 Ford Flex. The contact stated that the vehicle had experienced several electrical failures, including that door erroneously locking and unlocking and the Lane Departure safety feature malfunctioning. The vehicle was taken to the local dealer who determined that the electronic body control module was fault…
Read full complaint
The contact owns a 2013 Ford Flex. The contact stated that the vehicle had experienced several electrical failures, including that door erroneously locking and unlocking and the Lane Departure safety feature malfunctioning. The vehicle was taken to the local dealer who determined that the electronic body control module was faulty. After removing and reinstalling the module, the vehicle was repaired. Additionally, while the vehicle was in for service, the mechanic discovered that the water pump was faulty and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 120,000.
NHTSA ODI #11561820
18,000 miles · May 22, 2014
Engine And Engine CoolingStructure
UPON HARD ACCELERATION EXHAUST FUMES ENTER THE PASSENGER COMPARTMENT. GO TO HTTP://FORDFLEXFORUM/TOPIC/596-FUMES-IN-CABIN/PAGE-2 FOR ACTUAL CARBON MONOXIDE CONCENTRATIONS TEST RESULTS PERFORMED BY A FIRE DEPARTMENT. *TR
NHTSA ODI #10593443
8,026 miles · Oct 18, 2013
Engine And Engine CoolingFuel System, Gasoline
MY VEHICLE MOTOR QUIT ABOUT A MILE FROM MY HOME AND I COASTED TO THE SIDE OF THE ROAD AND TRIED TO RESTART THE MOTOR. THE SMELL OF GAS BECAME VERY STRONG AND I GOT OUT AND COULD SEE WHERE A STREAM OF GAS HAD STARTED 50 YARDS BACK ON THE STREET AND A PUDDLE WAS UNDER THE GAS TANK. I GOT THE HECK OUT OF THERE AND CALLED FORD RO…
Read full complaint
MY VEHICLE MOTOR QUIT ABOUT A MILE FROM MY HOME AND I COASTED TO THE SIDE OF THE ROAD AND TRIED TO RESTART THE MOTOR. THE SMELL OF GAS BECAME VERY STRONG AND I GOT OUT AND COULD SEE WHERE A STREAM OF GAS HAD STARTED 50 YARDS BACK ON THE STREET AND A PUDDLE WAS UNDER THE GAS TANK. I GOT THE HECK OUT OF THERE AND CALLED FORD ROAD ASSISTANCE. THE VEHICLE WAS TRANSPORTED TO THE FORD DEALER.THE SAFETY RECALL 13S04 FOR REPLACING THE FUEL PUMP HAD BEEN PERFORMED ABOUT A MONTH AGO AND 1000 MILES AGO. THE DEALER HAD NOT INSTALL THE O RING SEAL PROPERLY. THEY DID IT AGAIN AND SAY IT IS GOOD TO DRIVE. I AM NOT SO SURE. *TR
NHTSA ODI #10548472
10,100 miles · Jul 23, 2013
Engine And Engine Cooling
ON 7/20/13 I DROPPED OFF THE FLEX AT THE DEALER FOR THE TIMELY SERVICE AND ALSO TO HAVE THE A/C CHECKED. FOR ABOUT 2 MONTHS A TERRIBLE ODOR HAS BEEN COMING FROM THE A/C AND AFTER THE CAR WAS UNUSED FOR A DAY, THE ODOR WAS UNBEARABLE WHEN WE TURNED ON THE CAR A/C. ON 7/22/13 AT THE END OF THE WORK DAY, THE SERVICE DEPT CALLED ST…
Read full complaint
ON 7/20/13 I DROPPED OFF THE FLEX AT THE DEALER FOR THE TIMELY SERVICE AND ALSO TO HAVE THE A/C CHECKED. FOR ABOUT 2 MONTHS A TERRIBLE ODOR HAS BEEN COMING FROM THE A/C AND AFTER THE CAR WAS UNUSED FOR A DAY, THE ODOR WAS UNBEARABLE WHEN WE TURNED ON THE CAR A/C. ON 7/22/13 AT THE END OF THE WORK DAY, THE SERVICE DEPT CALLED STATING ALL WORK WAS COMPLETED, THAT THE A/C WAS WORKING PROPERLY AND THAT THERE WAS NO A/C PROBLEMS TO REPAIR. WHEN I AGAIN INFORMED THEM ABOUT THE TERRIBLE ODOR, I WAS INFORMED THAT THE FLEX HAS A PROBLEM WITH MILDEW IN THE A/C BUT THAT THERE WAS ABSOLUTELY NOTHING THEY COULD DO TO FIX THE PROBLEM. I DID NOT PICK UP MY CAR FROM SERVICE AND CALLED THE SERVICE MANAGER TO INFORM HIM/HER OF WHAT I WAS TOLD BY THE SERVICE ADVISOR.THE SERVICE MANAGER AGREED THAT THIS WAS A PROBLEM WITH THE FORD FLEX A/C, THAT FORD WAS AWARE OF THIS A/C ISSUE AS OF A YEAR AGO, BUT THAT THERE WAS NO SOLUTION TO THE PROBLEM. I IMMEDIATELY CALLED FORD CUSTOMER SERVICE. I WAS INFORMED THAT A REGIONAL REP WOULD CALL ME IN TWO DAYS. I SAID THAT I COULD NOT PICK UP THE CAR AS MY DAUGHTER SUFFERS FROM UPPER RESPIRATORY AILMENTS AND THAT I WOULD NOT PICK UP THE CAR UNTIL THE MOLD AND MILDEW WAS REMOVED AND THE PROBLEM FIXED. I INFORMED THEM THAT I NEEDED A CAR IN THE MEANTIME TO GHETTO WORK, ETC. I WAS TOLD THAT THEY COULD NOT GIVE ME A LOANER AND THAT I SHOULD GET A RENTAL CAR AT MY OWN EXPENSE AND THAT THERE MAY, OR MAY NOT, BE A POSSIBILITY OF A REFUND FOR THE RENTAL EXPENSE. I AM CURIOUS IF ANYONE ELSE HAS HAD THIS A/C PROBLEM WITH FORD AND IT WAS CORRECTED? *TR
Ford Motor Company (Ford) is recalling certain 2013-2018 Lincoln MKT and Ford Flex and Taurus vehicles with the Police Interceptor or SHO Performance Pack. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, free of charge. Remedy parts are not currently available. Owners were notified about the recall on March 3, 2020. A second notice will be mailed when remedy parts become available, which is currently expected to be the end of September 2020. The recall began October 28, 2020. Owners may contact Ford customer service at 1-866-436-7332 or Lincoln customer service at 1-800-521-4140. Ford's number for this recall is 20S04.
Ford Motor Company (Ford) is recalling certain model year 2013-2015 Ford Taurus, Ford Flex, Lincoln MKS and Lincoln MKT vehicles equipped with 3.5L GTDI Ecoboost engines and 2013-2015 Ford Taurus Police Interceptor vehicles. A component within the fuel pump electric module (PEM) may overheat causing a loss of electrical power to the fuel pump.
Consequence & remedy
Consequence: A loss of power to the fuel pump will cause the engine to stall or prevent the vehicle from starting, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the fuel PEM part number and replace the fuel PEM, as necessary, free of charge. The recall began on December 1, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S31.
Ford Motor Company (Ford) is recalling certain model year 2013 Explorer, Explorer Police Utility, Taurus, Taurus Police Interceptor, Flex, Lincoln MKS, and Lincoln MKT vehicles. In the affected vehicles, the fuel delivery module may crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on December 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 13S04-S1.
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Ford Motor Company (Ford) is recalling certain model year 2012-2014 Ford Edge and Lincoln MKX vehicles manufactured September 2, 2010, to November 30, 2013; 2013-2014 Ford Taurus and Lincoln MKS vehicles manufactured August 25, 2011, to November 30, 2013; and 2013-2014 Ford Flex and Lincoln MKT vehicles manufactured September 12, 2011, to November 30, 2013. In the affected vehicles, the halfshaft retention circlip may not have been properly installed, and as a result, the halfshaft may move outward and disengage from the linkshaft while driving and without prior warning.
Consequence & remedy
Consequence: If the halfshaft and linkshaft become disengaged while driving, power will no longer be transmitted to the wheels, increasing the risk of a vehicle crash. Additionally, if the parking brake is not applied before exiting the vehicle, the vehicle may roll away despite the transmission being placed in 'Park', increasing the risk of injury to exiting occupants and bystanders.
Remedy: Ford will notify owners, and dealers will inspect the vehicles to make sure that the halfshaft is properly retained. If it is not, dealers will replace the linkshaft and also replace the halfshaft if it shows evidence of spline damage, free of charge. The recall began on August 4, 2014. Owners may contact Ford customer service at 1-800-392-3673. Ford's number for this recall is 14S10.
Ford is recalling certain model year 2013 Explorer, Taurus, Flex, Fusion, Police Interceptor Sedan and Police Interceptor Utility vehicles; and certain model year 2013 Lincoln MKS, MKT, and MKZ vehicles. In the affected vehicles, the fuel delivery module may develop a crack, allowing fuel to leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Ford will notify owners, and dealers will replace the fuel delivery module, free of charge. The recall began on July 20, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1-866-436-7332. Ford's recall campaign number is 13S04.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2013 Ford Flex Problems, Complaints & Recalls | Skip That Year
Illustration