IllustrationTHERE A CLICKING SOUND COMING FROM THE GLOVE BOX LIKE MODULATOR GONE BAD NOT SURE WHAT IT IS BUT EVERY TIME I TURN THE AIR OR HEAT ON I HEAR A CLICKING SOUND ABOUT EIGHTEEN TIMES AND THAN IT STOPS. I I TURN THE AIR HEAT OFF I HEAR THE SOUND AGAIN FOR EIGHTEEN TIMES. NOT SURE WHAT THE PROBLEM IS.
2011 Ford Flex
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2011 Ford Flex do not stand out strongly from the model-year median of 139.
About this comparison →How this year compares
Owner complaints by model year
Compare all Flex years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1525–50K
2550–75K
1075–100K
35100–150K
12150K+
117 reports with mileage · 27 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Steering. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 19 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports1 fire reports8 injury reports
What owners actually said
144 reportsI HAVE A FORD FLEX TRUCK 2011 ECO BOOST LIMITED AND THE WHEN I GO TO THE CAR WASH FOR SOME REASON WATER IS COME THRU. I CHECK THE SEAL ON THE TOP OF THE VEHICLE AND THERE SEEM TO BE NO WEAR OR TERE ON THE RUBBER SEAL THAT AROUND THE TOP OF THE GLASS.
THE MIDDLE ROW SEATS BEHIND THE PASSENGER, THAT HAS A HAND BAR PULL FOR FOLDING THE SEAT FLAT THEN UP HAS BROKEN. THE HANDLE LIFTS FULLY BUT NO ACTION HAPPENS ONCE PULLED TO FULLY. THE SEAT IS STUCK IN THE SEATED POSITION NOW.
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT CALLED ON BEHALF OF HER SON. THE CONTACT STATED THAT THE WATER PUMP ON THE VEHICLE FAILED. THE CONTACT STATED THAT HER SON CALLED AN UNKNOWN FORD DEALER AND INFORMED THEM OF THE FAILURE. THE DEALER INFORMED HIM THAT IT WAS THE WATER PUMP THAT FAILED. THE CONTACT STATED THAT THE …
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT CALLED ON BEHALF OF HER SON. THE CONTACT STATED THAT THE WATER PUMP ON THE VEHICLE FAILED. THE CONTACT STATED THAT HER SON CALLED AN UNKNOWN FORD DEALER AND INFORMED THEM OF THE FAILURE. THE DEALER INFORMED HIM THAT IT WAS THE WATER PUMP THAT FAILED. THE CONTACT STATED THAT THE VEHICLE WAS UNDRIVABLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE CONTACT WAS REFERRED TO NHTSA FOR ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED WHILE STARTING THE VEHICLE, SHE HEARD AN ALARM AND BECAME AWARE THAT THE POWER STEERING ASSIST WARNING LIGHT WAS ILLUMINATED. THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT CALLED CLEVELAND FORD LOCATED AT 2496 S LEE HWY, CLEVELAND, TN 37311, (423) 218-1622 AND THE…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED WHILE STARTING THE VEHICLE, SHE HEARD AN ALARM AND BECAME AWARE THAT THE POWER STEERING ASSIST WARNING LIGHT WAS ILLUMINATED. THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT CALLED CLEVELAND FORD LOCATED AT 2496 S LEE HWY, CLEVELAND, TN 37311, (423) 218-1622 AND THE DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE HAD NOT BEEN DIAGNOSED NOR REPAIRED. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. UPON INVESTIGATION, THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 15V340000 (STEERING) HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 171,234.
TRAVELING ALONG THE INTERSTATE AT REGULAR SPEED, THE ENGINE BEGAN TO OVERHEAT. A LEAK FROM THE WATER PUMP OCCURRED AND FLOODED THE ENGINE AND OIL RESERVOIR CAUSING THE VEHICLE TO IMMEDIATELY SMOKE AND OVERHEAT. AFTER ALLOWING THE VEHICLE TO SIT AND COOL DOWN SO NOT TO START A FIRE WHEN THE HOOD IS LIFTED, THE DAMAGE TO THE ENG…
Read full complaint
TRAVELING ALONG THE INTERSTATE AT REGULAR SPEED, THE ENGINE BEGAN TO OVERHEAT. A LEAK FROM THE WATER PUMP OCCURRED AND FLOODED THE ENGINE AND OIL RESERVOIR CAUSING THE VEHICLE TO IMMEDIATELY SMOKE AND OVERHEAT. AFTER ALLOWING THE VEHICLE TO SIT AND COOL DOWN SO NOT TO START A FIRE WHEN THE HOOD IS LIFTED, THE DAMAGE TO THE ENGINE TOOK PLACE. THE HEAD GASKET BLEW AND ANTIFREEZE MIXED IN WITH THE MOTOR OIL.
MY VEHICLE EXPERIENCES A LOSS OF POWER STEERING ASSIST, EXTRA STEERING EFFORT IS REQUIRED AT LOWER SPEEDS. IT FEELS UNSAFE WHEN STEERING AT LOW SPEEDS.
MY STEERING WHEEL WILL CONSISTENTLY LOSE POWER STEERING IN A TURN ESP[ECIALLY NOTICEABLE AT LOW SPEEDS. IT APPEARS TO ONLY HAPPEN WHEN I'M TURNING LEFT AT THIS POINT. I HAVE CHECKED FLUIDS AND THERE IS NO DAMAGE TO THE STEERING BOX.
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THE SECOND-ROW DRIVER'S SIDE SEAT RELEASE HANDLE WAS INOPERABLE. THE CONTACT STATED THAT THE SECOND-ROW SEAT FAILED TO MOVE FORWARD WHICH MADE THIRD-ROW PASSENGER'S UNABLE TO EXIT THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. KELLY FORD LOCATED AT 776 MAG…
Read full complaint
TL* THE CONTACT OWNS A 2011 FORD FLEX. THE CONTACT STATED THAT THE SECOND-ROW DRIVER'S SIDE SEAT RELEASE HANDLE WAS INOPERABLE. THE CONTACT STATED THAT THE SECOND-ROW SEAT FAILED TO MOVE FORWARD WHICH MADE THIRD-ROW PASSENGER'S UNABLE TO EXIT THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. KELLY FORD LOCATED AT 776 MAGNOLIA AVE, MELBOURNE, FL 32935, (321)216-2042 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 133,000.*DT*JB
WHILE TURNING MY STEERING WHEEL TO PARK MY CAR MY STEERING WHEEL DETACHED FROM THE COLUMN.
Official recalls
216V247000 · Air Bags:frontal
Apr 26, 2016
Ford Motor Company (Ford) is recalling certain model year 2009-2012 Ford Flex, 2008 and 2010-2012 Ford Taurus, 2008-2009 Ford Taurus X, 2008 Mercury Sable, 2009 and 2011 Lincoln MKS vehicles. The driver frontal air bag may improperly inflate during second-stage deployment in the event of a high speed crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: An improperly inflated air bag increases the risk of injury in the event of a crash.
Remedy: Ford will notify owners, and dealers will inspect and replace the driver's frontal air bag module, as necessary, free of charge. The recall is expected to begin on June 13, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16C06.
15V340000 · Steering:electric Power Assist System
Jun 2, 2015
Ford Motor Company (Ford) is recalling certain model year 2011-2012 Ford Fusion vehicles without a 3.5L engine and Lincoln MKZ hybrid electric vehicles, 2011 Mercury Milan vehicles, 2011-2012 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with a 3.5L GTDI engine and 2013 Ford Taurus, Ford Flex, Lincoln MKS, and Lincoln MKT vehicles equipped with any available engine. The affected vehicles have electric power steering assist systems that may shut down as a result of a steering motor sensor fault.
Consequence & remedy
Consequence: If the vehicle experiences a loss of power steering assist, extra steering effort will be required at lower speeds, increasing the risk of a vehicle crash.
Remedy: Ford will notify owners, and dealers will check the Power Steering Control Module (PSCM) for Diagnostic Trouble Codes (DTC). If dealers find any loss of steering assist DTCs, the steering gear will be replaced, free of charge. If, no codes are found during the PSCM inspection, the PSCM software will be updated, free of charge. The recall began on July 21, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S18.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.