Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 2 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Service Brakes. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes, Hydraulic. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
2 reports
60,542 miles · Sep 22, 2014
Service Brakes
TL* THE CONTACT OWNS A 1991 FORD WINNEBAGO F-53 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH ATTEMPTING TO ENGAGED THE BRAKES, THE VEHICLE DELAYED TO STOP AND ALMOST RESULTED IN A CRASH. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILU…
Read full complaint
TL* THE CONTACT OWNS A 1991 FORD WINNEBAGO F-53 CHASSIS. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH ATTEMPTING TO ENGAGED THE BRAKES, THE VEHICLE DELAYED TO STOP AND ALMOST RESULTED IN A CRASH. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,542.
NHTSA ODI #10638098
49,100 miles · Apr 24, 2003
Service Brakes, Hydraulic
I HAVE A SEVERE BREAK FADING PROBLEM. I HAPPENS AFTER YOU HAVE DESCENDED A STEEP DOWNGRADE AND STOP. AT THAT POINT THE BREAK PEDAL GOES COMPLETELY TO THE FLOOR. AFTER A RESTING PERIOD THE PEDAL COMES BACK AGAIN. FORD HAS TOLD ME THE ONLY WAY TO CORRECT THE PROBLEM WITH MY 1991 M53, 50,000 MILES, IS TO DO A $2,500.00 TO $3,000.…
Read full complaint
I HAVE A SEVERE BREAK FADING PROBLEM. I HAPPENS AFTER YOU HAVE DESCENDED A STEEP DOWNGRADE AND STOP. AT THAT POINT THE BREAK PEDAL GOES COMPLETELY TO THE FLOOR. AFTER A RESTING PERIOD THE PEDAL COMES BACK AGAIN. FORD HAS TOLD ME THE ONLY WAY TO CORRECT THE PROBLEM WITH MY 1991 M53, 50,000 MILES, IS TO DO A $2,500.00 TO $3,000.00 OVERHAUL OF THE BREAK SYSTEM USING PHONELIC PARTS. I FEEL IF AN EXTENSIVE OVERHAUL IS REQUIRED AT THIS POINT, IT WAS A SYSTEM DESIGNED TO FAIL. A SYSTEM DEFECT. THIS PROBLEM COULD HAVE COST THE LIFE OF MY WIFE AND TWO OF MY GRANDCHILDREN AND MYSELF. I HAVE BEEN RESTRICTED TO DRIVING ON FLATLAND EVER SINCE THIS INSTANCE ABOUT 2 YEARS AGO. I HAVE ATTEMPTED TO GET AN ANSWER OR A CORRECTION BUT NO ONE SEEMS TO HAVE ONE EXCEPT $2,500- $3,000. I FEEL FORD HAS A RESPONSIBILITY HERE AND SHOULD PAY ALL OR A SUBSTANTIAL PART OF THE CORRECTION OF THEIR DESIGN ERROR. *NLM
BRAKE LINES IN THE ENGINE COMPARTMENT ARE ROUTED TOO NEAR THE LEFT EXHAUST MANIFOLD, CAUSING THE BRAKE FLUID TO OVERHEAT.
Consequence & remedy
Consequence: BRAKE FLUID LOSES VISCOSITY WHEN IT OVERHEATS, CAUSINGLOSS OF BRAKES OR INCREASED VEHICLE STOPPING DISTANCE WHICH MAY RESULT IN ANACCIDENT.
Remedy: FORD WILL INSTALL A HEAT SHIELD AND BRAKE LINE INSULATION ON ENGINE COMPARTMENT BRAKE LINES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
1991 Ford F53 Problems, Complaints & Recalls | Skip That Year
Illustration