National Traffic and Motor Vehicle Safety Act of 1966 (Safety Act), S571.120 Tire/Rim Selection, S5.1.2, requires the sum of the maximum load ratings of the tires fitted to the axle shall be not less than the gross axle weight rating (GAWR) of the axle system specified on the vehicle's certification label required by 49 CFR part…
Read full complaint
National Traffic and Motor Vehicle Safety Act of 1966 (Safety Act), S571.120 Tire/Rim Selection, S5.1.2, requires the sum of the maximum load ratings of the tires fitted to the axle shall be not less than the gross axle weight rating (GAWR) of the axle system specified on the vehicle's certification label required by 49 CFR part 567. 567.77 requires any alterer of the vehicle to continue conformity with these requirements and assumes legal liability for certification under the Safety Act. The Siberian RV (see pic) is a customized off-road expedition vehicle manufactured by ProVan Industries, West Columbia South Carolina. They utilize a Ford F550 Super Duty 4x4 as the chassis and customize the RV to travel into off-grid extreme environments and road conditions. Provan alters the standard Ford F550 dual rear wheel to a single rear wheel The altered Certification Label affixed to the vehicle (see pic) establishes the rear axle GAWR at 14,706 pounds. The Tire/Wheel (Rim) assembly chosen by Provan as their alteration is listed as a TOYO M608Z 285/70R 19.5" on a Hutchinson Beadlock Wheel. ProVan neglected to list the capacity of this tire on the Certification Label, instead filling "X" in this spot (VIOLATION). TOYO Inflation Chart determines the MAX load capacity of this tire to be 6395# at 125 MAX Inflation (see chart). The Hutchinson Wheel has a stamped MAX inflation capacity of 120psi which lowers the load capacity of the tires to 6185# per tire. Either way the sum of the maximum capacity of the tires is either 12,790# or 12,270# safely. The tires are far short of the 14,706# required by the Safety Act. At 22,500 miles and roughly 50% tread wear the rear tire sidewalls developed a split in the bead seam near the rim (see pics). This unsafe tire condition was noticed and immediately pulled out of service. Toyo states this is an overload condition. ProVan refuses to take responsibility for their defective design in violation of the Safety Act. Please Help
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & remedy
Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
Unruh Fire, Inc. (Unruh Fire) is recalling certain 2017-2018 Ford F-550-based fire trucks equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Consequence & remedy
Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Remedy: Unruh Fire has notified owners and will replace the brake lights, free of charge. The recall began in May 20, 2019. Owners may contact Unruh Fire customer service at 1-800-856-7080.
Taylor Made Ambulances is recalling certain 2017-2018 Ford E-350, F-450, E-450, F-550, and GMC G3500-based ambulances equipped with Whelen brake lights. Depending on the specific wiring of the vehicle, these brake lights may illuminate when the brake pedal has not been pressed.
Consequence & remedy
Consequence: If the brake lights incorrectly illuminate, it can confuse other drivers, possibly increasing the risk of a crash.
Remedy: Taylor Made will notify owners and Whelen will replace the brake lights, free of charge. The recall began June 5, 2019. Owners may contact Taylor Made Ambulances customer service at 1-800-468-1310.
Ford Motor Company (Ford) is recalling certain 2015-2019 Ford F-150 and 2017-2019 Ford F-250 Super Duty, F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty pick-up trucks equipped with an engine block heater. Water and contaminants may get into the block heater cable's splice connector causing corrosion and damage.
Consequence & remedy
Consequence: When the heater is plugged in, prolonged corrosion could cause a resistive short, increasing the risk of overheated or melted wiring which can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will disable the block heater cable, free of charge. Once parts are available, Dealers will replace the engine block heater cable, free of charge. The recall began June 3, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 18S45.
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence & remedy
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Additional source detail variants (2)
Latches/locks/linkages:doors:latch
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Structure:body:door
Ford Motor Company (Ford) is recalling certain 2015-2017 F-150, and 2017 F-250, F-350, F-450, and F-550 vehicles originally produced with black or body colored exterior door handles that may have been subsequently equipped with a chrome exterior door handle cover accessory kit purchased from a Ford dealer. These accessory door handle covers may cause the doors to unlatch in a side impact collision. As such, these vehicles may fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 206, "Door Locks and Door Retention Components."
Consequence: If the doors unlatch and open in a side impact collision, the occupants have an increased risk of injury.
Remedy: Ford will notify owners, and dealers will remove the accessory covers and refund the purchase price. The recall began July 13, 2017. Owners may contact Ford at 1-866-436-7332. Ford's number for the recall is 17C09.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2017 Ford F-550 Problems, Complaints & Recalls | Skip That Year
Illustration