The contact owns a 2019 Thor Motor coach Windsport built on a 2018 Ford F-53 Chassis. The contact stated that while she was cleaning the RV, she noticed that the metal screws that maintained the overhead unit of the driving compartment attached to the ceiling were pulling out. However, the brackets installed on each side of the …
Read full complaint
The contact owns a 2019 Thor Motor coach Windsport built on a 2018 Ford F-53 Chassis. The contact stated that while she was cleaning the RV, she noticed that the metal screws that maintained the overhead unit of the driving compartment attached to the ceiling were pulling out. However, the brackets installed on each side of the overhead unit prevented it from falling. An independent RV mechanic diagnosed that the failure was due to metal screws being installed on the wooden surface. The independent mechanic informed the contact that brackets needed to be installed to maintain the overhead unit into position. The RV was not repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure but did not provide any assistance. The failure mileage was approximately 9,000.
NHTSA ODI #11491692
12,424 miles · Jun 3, 2020
Structure
MAIN DOOR HATCH PLUNGER BROKE ON TRIMARK 72130 DOOR HATCH /DEAD BOLT , LOCKING US OUT. IF WE HAD BEEN INSIDE WE WOULD HAVE BEEN TRAPPED INSIDE. THE VEHICLE WAS PARKED AT THE TIME. HAD TO FIND A LADDER A CLIMB THRU WINDOW AND AFTER A COUPLE HOURS WERE ABLE TO TAKE APART TO GET UNLATCH AND FOUND BROKEN PLUNGER/HATCH. *TR
NHTSA ODI #11327052
3,500 miles · Jun 7, 2018
Structure
WHILE DRIVING ON THE FWY THE BUNK DOORS ON MY MOTORHOME FAILED WHERE THE DOOR SCREWS INTO THE HINGE BRAKET CAUSING THE 45LBS DOOR TO FALL OFF. ON A SEPERATE OCCASION ON THE OTHER DOOR, THE WELD IN THE BRACKET FAILED AND THE OTHER DOOR FELL OFF. THESE DOORS ARE IN A STRAIT LINE WITH THE DRIVER AND PASSENGER SEATS AND IN THE EVENT…
Read full complaint
WHILE DRIVING ON THE FWY THE BUNK DOORS ON MY MOTORHOME FAILED WHERE THE DOOR SCREWS INTO THE HINGE BRAKET CAUSING THE 45LBS DOOR TO FALL OFF. ON A SEPERATE OCCASION ON THE OTHER DOOR, THE WELD IN THE BRACKET FAILED AND THE OTHER DOOR FELL OFF. THESE DOORS ARE IN A STRAIT LINE WITH THE DRIVER AND PASSENGER SEATS AND IN THE EVENT OF A PANIC STOP OR TRAFFIC COLLISION COULD CAUSE GREAT BODILY HARM OR DEATH. THE MANUFACURE OF THE VEHICLE DID NOT ENGINEER THE BRACKETS AND MOUNTING DEVICES PROPERLY AND HAVE CREATED A POTENTIAL HAZARD IN ALL SIMILARLY EQUIPED VEHICLES.
NHTSA ODI #11100307
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE20021 · Trimark 060-1650 Door Latch Failures
Opened Nov 23, 2020 · Closed Dec 13, 2024
Status: closed (inferred from source dates) · Equipment
On November 23, 2020, the Office of Defects Investigation (ODI) opened PE20021 to investigate allegations of inoperative Trimark THP 060-1650 door lock/latches originally equipped on model years (MY) 2015-2017 Class A and Class C motorhomes.ODI received forty-six Vehicle Owner’s Questionnaires (VOQs) describing consumers being locked in or out of their vehicles.The door latch, containing a die-cast zinc plunger, was produced by Equality during calendar years 2014-2016. The die-cast may become porous and brittle over time and can break without warning, causing the vehicle owner to be unable to open the recreational vehicle door equipped with the latch.If the motorhome does not have any other doors such as some Class A models, occupants could be trapped inside, needing to climb out using the emergency exits. If locked out, owners would be unable to easily get in and retrieve children and pets. ODI analyzed the data provided by Trimark in response to its January 27, 2021 information request letter.Although an elevated failure rate was evident on a specific combination of plunger bolt, door lock/latch assembly and door, the data showed that most failures occurred within the first two years of service on the affected 2015-2017 vehicles.This data suggests that component failures generally would have already occurred.Further, ODI data reflects a downward trend in complaints after calendar year 2018 and for post- MY 2016 vehicles.This downward trend may be attributed Trimark's actions in 2016 such as changes in the manufacturing process of its zinc plunger component for the relevant population and its 2016 decision to switch to a steel plunger. In view of the nature of early-life failure, and failure rate trending downward for model years 2017 and newer, this Preliminary Evaluation (PE) is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist.The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2018 Ford F-53 Problems, Complaints & Recalls | Skip That Year
Illustration