Engine And Engine CoolingFuel System, DieselPower TrainFireInjury
DRIVING AS NORMAL ON FWY HEARD A LOUD NOISE THOUGHT I GOT A FLAT. STOPPED VEHICLE ON SHOULDER, BRAKING WAS DIFFICULT AND WHITE SMOKE WAS AROUND THE CAR. I GOT OUT AND DID NOT SEE ANY FLAT TIRES BUT I SAW SMOKE BETWEEN THE CAB AND BED OF THE TRUCK. I RAN BACK TO THE DRIVER DOOR AND SAW A SMALL FIRE ON THE FLOOR NEXT TO THE 4X4…
Read full complaint
DRIVING AS NORMAL ON FWY HEARD A LOUD NOISE THOUGHT I GOT A FLAT. STOPPED VEHICLE ON SHOULDER, BRAKING WAS DIFFICULT AND WHITE SMOKE WAS AROUND THE CAR. I GOT OUT AND DID NOT SEE ANY FLAT TIRES BUT I SAW SMOKE BETWEEN THE CAB AND BED OF THE TRUCK. I RAN BACK TO THE DRIVER DOOR AND SAW A SMALL FIRE ON THE FLOOR NEXT TO THE 4X4 SHIFTER FOR THE TRANSFER CASE. I IMMEDIATELY GRABBED MY 3 YEAR OLD DAUGHTER FROM HER CAR SEAT AS THE CAB FILLED WITH SMOKE AND RAN APPROXIMATELY 300 FEET AWAY AND TOLD MY DAUGHTER TO STAY. I JUMPED INTO THE BACK OF THE TRUCK GRABBED A LARGE FIRE EXTINGUISHER AND DISCHARGED IT INTO THE HOLE IN THE FLOORBOARD NEXT TO THE TRANSFER CASE IT WENT OUT AND IMMEDIATELY CAME STARTED UP AGAIN. I THEN CALLED 911. SOME PEOPLE STOPPED AND HELPED ME REMOVE A FEW POSSESSIONS FROM THE TRUCK BED. WITHIN 3 MINUTES THE TRUCK FIRE FLASHED AND WE ALL STOOD BACK AND VIDEO TAPED THE VEHICLE BURN TO THE GROUND. THE WITNESSES SAID WHAT APPEARED TO BE SOMETHING METAL CAME OFF OF MY TRUCK STRUCK THEIR CAR AND THE REASON THEY PULLED OVER IS BECAUSE THEY THOUGHT THEY HAD A FLAT BUT WHEN THEY LOOKED BACK THEY SAW FIRE UNDERNEATH MY TRUCK AND RAN TO HELP. THE FD ARRIVED THEY SHOT FOAM ON THE FIRE BUT IT CONTINUED TO GO OUT THEN START BACK IT TOOK THEM APPROXIMATELY 30 MIN TO EXTINGUISH. I AM VERY MECHANICAL AND BELIEVE MECHANICAL FAILURE IN THE EXHAUST CANNINSTERS THAT COLLECT THEN BURN HYDRO CARBON PARTICLES BEFORE THEY ARE RELEASED INTO THE CAT CONVERTER, SENT EXCESSIVE HEAT TO THE TRANSMISSION THEN THE TRANSFER CASE(DIRECTLY BELOW THE FUEL LINES), THUS MELTING THE FUEL LINES WHICH DRIPPED ON THE RED HOT TRANSFER CASE AND STARTED THE FIRE. THE VEHICLE WAS IN THE SHOP PREVIOUSLY UNDER A FORD RECALL FOR SHOOTING FLAMES OUT OF THE TAIL PIPES SO I ASSUME THEY MUST HAVE RESTRICTED THE FLAMES WHICH KEPT THE MORE HEAT INSIDE THE VEHICLE EXHAUST SYSTEM AND IS SERIOUSLY DANGEROUS! MY DAUGHTER AND I WOULD HAVE BEEN KILLED IF THE AIR BAGS HAD DEPLOYED OR AN ACCIDENT. *TR
FORD IS RECALLING 87,515 MY 2008 F250, F-350, F-450, AND F-550 VEHICLES FOR FAILING TO COMPLY WITH ALL THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207, "SEATING SYSTEMS." SOME 40% SPLIT AND CAPTAIN'S CHAIR DRIVER'S SEATS, EQUIPPED WITH LUMBAR SUPPORTS, MAY HAVE IMPROPER WELDS AT THE JOINT OF THE SEAT BACK PIVOT BRACKET AND THE SEAT BACK FRAME.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE SEAT SIDE PIVOT BRACKET MAY CRACK OR BREAK, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL ADD A REINFORCEMENT TO THE DRIVER'S SEAT BACK FRAME ON THE 40% SPLIT OR CAPTAIN'S CHAIR SEAT EQUIPPED WITH LUMBAR SUPPORT OR, IF NECESSARY, THE SEAT BACK FRAME WILL BE REPLACED. THE RECALL BEGAN ON MARCH 28, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, EXCESSIVE TEMPERATURES IN THE DIESEL PARTICULATE FILTER IN THE EXHAUST SYSTEM MAY RESULT FROM EXCESS HYDROCARBONS IN THE EXHAUST.
Consequence & remedy
Consequence: LACK OF POWER OR ROUGH OPERATION, UNUSUAL NOISES FROM THE ENGINE OR EXHAUST, WHITE SMOKE FROM THE EXHAUST, AND POTENTIALLY A VISIBLE FLAME OUT THE TAILPIPE CAN OCCUR.
Remedy: DEALERS WILL REPROGRAM THE POWER TRAIN CONTROL MODULE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH A 6.4L DIESEL ENGINE, INSUFFICIENT CLEARANCE OF THE BATTERY POSITIVE (B+) WIRE TO THE RIGHT HAND SPLASH SHIELD BOLT MAY RESULT IN THE BATTERY B+ WIRE CONTACTING THE SPLASH SHIELD BOLT.
Consequence & remedy
Consequence: LONG TERM CONTACT COULD CAUSE WIRE CHAFE, RESULTING IN COPPER WIRE BEING EXPOSED. IF THIS CONDITION OCCURS, THE BATTERY B+ WIRE COULD SHORT TO GROUND INCREASING THE RISK OF A FIRE.
Remedy: DEALERS WILL INSPECT THE BATTERY B+ WIRE LOCATION AND, IF NECESSARY, REPOSITION THE WIRE. THE RECALL BEGAN ON APRIL 3, 2007. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2008 Ford F-450 Sd Problems, Complaints & Recalls | Skip That Year
Illustration