Fuel System, Diesel. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Gasoline. Review the 6 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

0 crash reports0 fire reports0 injury reports

Suspension complaints

2 reports

Clear category filter

1,639 miles · May 9, 2007

Suspension

Read full complaint

TL*THE CONTACT OWNS A 2005 FORD F-450 SUPER DUTY. WHILE DRIVING 45 MPH OR GREATER, THE REAR OF THE VEHICLE VEERS FROM LEFT TO RIGHT IN CLEAR ROAD CONDITIONS. THE DEALER STATED THAT THE VEHICLE NEEDED A WHEEL ALIGNMENT AND PERFORMED THE REPAIR; HOWEVER THE FAILURE STILL OCCURRED. THE VEHICLE HAS NOT BEEN INSPECTED AGAIN. THE CONTACT REPLACED ALL OF THE VEHICLE'S TIRES, BUT THIS DID NOT RESOLVE THE FAILURE. THE CURRENT MILEAGE IS 12,000 AND FAILURE MILEAGE WAS 1,639.

NHTSA ODI #10190286

18,500 miles · Mar 14, 2007

Suspension

I WAS DRIVING MY FORD F-450 TRUCK ON A SECONDARY ROAD IN BAJA CALIFORNIA WHEN THE LEFT FRONT COIL SPRING FELL OFF, PRESUMABLY WHILE PASSING OVER A BUMP IN THE ROAD. I WAS NOT IMMEDIATELY AWARE THAT THE SPRING WAS MISSING, AND WAS NOT ABLE TO FIND THE SPRING WHEN I LATER SEARCHED THE ROADWAY. *JB

NHTSA ODI #10185086

Official recalls

11V352000 · Exterior Lighting:brake Lights; Exterior Lighting:tail Lights

Jul 13, 2011

FORD IS RECALLING CERTAIN MODEL YEAR 2011 RANGER TRUCKS BUILT FROM JANUARY 25, 2011, THROUGH APRIL 25, 2011 AT THE TWIN CITIES ASSEMBLY PLANT, AND SERVICE PARTS DISTRIBUTED TO DEALERS FOR CERTAIN 2004 THROUGH 2011 MODEL YEAR RANGER TRUCKS, 2002 THROUGH 2005 MODEL YEAR EXCURSION VEHICLES, AND 2002 THROUGH 2007 MODEL YEAR F-250, F-350, F-450, AND F-550 TRUCKS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE MULTI-FUNCTION SWITCH WAS SHIPPED WITH A SUBCOMPONENT (SLIDER) THAT MAY EXPERIENCE DEFORMATION. A MULTI-FUNCTION SWITCH WITH A DEFORMED SLIDER MAY MALFUNCTION CAUSING THE TURN SIGNAL, TAIL LIGHTS, HAZARD WARNING SIGNAL FLASHERS AND/OR BRAKE LIGHTS NOT TO ACTIVATE.

Consequence & remedy

Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Additional source detail variants (2)

Exterior Lighting:brake Lights

Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

Exterior Lighting:tail Lights

Consequence: NON-FUNCTIONING LIGHTS COULD INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SWITCHES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 15, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.

05V270000 · Electrical System:wiring

Jun 10, 2005

CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.

Consequence & remedy

Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

05V266000 · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Jun 9, 2005

ON CERTAIN PICKUP TRUCKS AND CHASSIS CAB VEHICLES EQUIPPED WITH 5.4L OR 6.8L GASOLINE ENGINES, THE FUEL JUMPER LINE MAY HAVE AN INCORRECT END FORM.

Consequence & remedy

Consequence: THE FUEL LINE MAY SEPARATE AT THE CONNECTION TO THE MAIN FUEL BUNDLE. IF THE FUEL LINE SEPARATES, AN OPERATOR MAY NOTICE A GASOLINE ODOR AND/OR FUEL ON THE GROUND, LOSS OF POWER, AND THE ENGINE WILL EVENTUALLY STALL. FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Remedy: DEALERS WILL INSTALL AN EXTERNAL RETENTION CLIP AT THE FUEL JUMPER LINE TO THE MAIN FUEL BUNDLE CONNECTION. THE RECALL BEGAN ON JUNE 20, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.

05V135000 · Steering:gear Box:shaft Pitman

Apr 6, 2005

ON CERTAIN CHASSIS CAB TRUCKS, THE STEERING GEAR MAY HAVE SOME GEARS WITH A GEAR PISTON THAT WAS ASSEMBLED WITH AN INCORRECT RE-CIRCULATING BALL TUBE RETAINER. AN INCORRECT RETAINER MAY RESULT IN AN IMPROPERLY RETAINED RE-CIRCULATING BALL TUBE, WHICH MAY NOT KEEP THE RE-CIRCULATING BALLS IN PLACE DURING STEERING GEAR ACTUATION.

Consequence & remedy

Consequence: IF THE RE-CIRCULATING BALLS BECOME DISLODGED A VEHICLE OPERATOR MAY NOTICE NOISE AND INCREASED STEERING EFFORTS THAT MAY EVENTUALLY PROGRESS TO IMPAIRED STEERING OR POTENTIAL LOSS OF STEERING WHICH COULD RESULT IN A CRASH.

Remedy: DEALERS WILL INSPECT THE STEERING GEAR FOR A SPECIFIC DATE CODE AND REPLACE IF NECESSARY FREE OF CHARGE. THE RECALL BEGAN ON APRIL 4, 2005. OWNERS MAY CONTACT AT 1-800-392-3673.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.