2016 Ford F-350 Sd

The contact owns a 2016 Ford F-350. The contact stated while driving 45–55 MPH, the vehicle lost motive power. The contact was able to pull over and restart the vehicle, which reset the vehicle. The vehicle then went into LIMP Mode. The contact stated that the RPM failed to exceed 2,500 RPM. The vehicle was idling. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, who referred the contact to a Ford dealer for assistance. The vehicle was taken to another independent mechanic, who determined that the failure was due to the turbo. The vehicle was taken to the local dealer, where it was diagnosed that the turbo needed to be replaced. The vehicle was repaired, but the failure recurred. The manufacturer was contacted, and the contact was informed that the turbo charger was good for approximately three to four years; no assistance was provided. The contact was referred to the NHTSA hotline for assistance. The failure mileage was approximately 50,000.

The contact owns a 2016 Ford F-350. The contact stated while driving at speeds of 51 MPH or exceeding that speed, the vehicle experienced the "Death Wobble". The failure also occurred while driving over rough road surfaces. The contact stated that during the failure, the “Traction Control Loss” warning light was illuminated. The dealer was made aware of the failure. The dealer confirmed that the VIN was not included in a recall. The contact was referred to the manufacturer who confirmed that the VIN was not included in a recall. The manufacturer had referred the contact to the NHTSA Hotline to file a safety complaint. The failure mileage was 120,000.

We purchased this truck as a certified used vehicle in January of 2019. In September of 2023 we started experiencing a death wobble every time we try and take the truck over 55 mph. We have taken the truck to the ford dealership six different times to try and fix the issue, and ford can not figure out the cause of the wobble. Currently the truck has been in the shop at ford for almost 2 months continuously with them trying to figure out what is causing the issue.

For years my truck starts vibrating excessively, shaking the entire vehicle when driving over certain sections of roadway or bumps. Sometimes, my steering is difficult to maintain when this happens. This occurs at speeds around 50 mph+. I always assumed it was just a bad road section and never pursued any repair as I didn't think it was a truck issue. Recently, I have come across some articles, that described my exact situation/condition when driving my truck. It makes me have to slow way down below the speed limit for the violent shaking to stop. Sometimes, I though it was just my stiff suspension on bad roads. It is being called the Ford Death Wobble and affects many Ford Super Duty Trucks. Who knows what other components of my truck have been unduly affected due to this manufacturer's safety issue with my truck and that appears to be a situation that occurs often with other Ford Super Duty trucks. I'm concerned one day it will cause me to lose control and crash or crash into another vehicle. To my knowledge Ford has not issued any recall's regarding these safety problems. My truck has been to the Ford shops many times but nothing addressed regarding this condition. It has occurred so many times, I can not even count, well over hundreds of times over 8 years. The most recent time it occurred was about two weeks ago on [XXX] in Colorado Springs. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2016 Ford F-350. The contact stated that while driving at an undisclosed speed, the engine seized. The check engine warning light illuminated. The contact stated that the vehicle failed to restart. The vehicle was towed to an independent mechanic where it was diagnosed with a failed fuel pump and metal shavings inside the fuel system. The contact was informed that the fuel system and injectors needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 150,000.

I have had a recurring problem with the so-called "death wobble" whereby the vehicle starts to shake violently when hitting certain bumps above about 50 mph and cannot be brought back under control without completely coming to a stop. I've had the front end components, including tie rods, stabilizers, drag link, etc completely replaced THREE TIMES and within a year of normal driving it comes back. It has always been repaired at a Ford service center. It happens without warning, though I've learned now how the vehicle feels when the front end starts getting loose so I can have it repaired before it becomes dangerous.

Airbags are not faulty if you look at sticker they have warning due to old age the plastic becomes brittle and can cause fragments to impale driver only way to prevent this is not replace the airbag but to cover with duct tape, this recall needs to be updated Takata is not responsible, they operate as designed as I said the air bag fill with high pressure air and in older cars will crack plastic cover. Please update this recall this is not a manufacturer error.

The contact owns a 2016 Ford F-350. The contact stated that while driving on several occasions at various speeds, the A/C unit turned off without being disengaged. The tire pressure warning light flashed on the instrument panel. Additionally, the indicator lights were blinking quickly, and trailer turn light failed to illuminate properly and there was a delay when the trailer was connected. The vehicle was taken to a dealer where it was diagnosed that the brain control module needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was notified of the failure and a complaint was filed. The failure mileage was approximately 88,000.

The contact owns a 2016 Ford F-350. The contact stated while driving at various speeds, the transmission was shifting hard and was slipping. Additionally, the vehicle was shuddering while the transmission was shifting. An unknown warning light was illuminated. The vehicle was taken to the dealer; however, the cause of the failure could not be determined. The contact stated that the failure persisted. The vehicle was taken to a transmission specialist, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was being repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 50,000. The VIN was unavailable.