DURING ITS WARRANTY PERIOD, THE VEHICLE EXHIBITED RUST AT LOAD-BEARING AREAS OF SEVERAL CROSSMEMBERS WHICH SUPPORT THE PICKUP BED. THE RUST OCCURS EXCLUSIVELY BETWEEN THE STAMPED STEEL CROSSMEMBER ITSELF AND A STAMPED STEEL REINFORCING PLATE WHICH IS SPOT-WELDED TO EACH CROSSMEMBER WHERE IT INTERSECTS AND MAKES LOAD-BEARING CONT…
Read full complaint
DURING ITS WARRANTY PERIOD, THE VEHICLE EXHIBITED RUST AT LOAD-BEARING AREAS OF SEVERAL CROSSMEMBERS WHICH SUPPORT THE PICKUP BED. THE RUST OCCURS EXCLUSIVELY BETWEEN THE STAMPED STEEL CROSSMEMBER ITSELF AND A STAMPED STEEL REINFORCING PLATE WHICH IS SPOT-WELDED TO EACH CROSSMEMBER WHERE IT INTERSECTS AND MAKES LOAD-BEARING CONTACT WITH THE VEHICLE'S FRAME. BECAUSE THE RUST AND ANY MOISTURE, SALT, ETC. ARE CAPTIVE BENEATH THE REINFORCING PLATE, RUST IS CONCEALED FROM VIEW UNTIL IT PROCEEDS BEYOND THE PERIPHERY OF EACH PLATE. THIS MAKES IT DIFFICULT TO KNOW THE DEPTH TO WHICH RUST HAS PENETRATED EACH CROSSMEMBER. AS THE LOAD-BEARING PORTIONS OF THE PICKUP BED CROSSMEMBERS ARE WEAKENED BY RUST, THE VEHICLE'S RATED PAYLOAD CAPACITY IS COMPROMISED ACCORDINGLY AND THE POTENTIAL FOR CROSSMEMBERS TO COLLAPSE AT OR BELOW THE VEHICLE'S RATED PAYLOAD CAPACITY BECOMES A CONCERN. COLLAPSE OF THE CROSSMEMBERS WHICH SUPPORT THE PICKUP BED AND ITS PAYLOAD COULD RESULT IN SUDDEN DESTABILIZATION OF THE PAYLOAD AND THE VEHICLE, LEADING TO LOSS OF CONTROL OF THE VEHICLE AND POSSIBLY A CRASH. FURTHER CONCERN IS THAT THE UPPERMOST PORTION OF THE FUEL TANK IN THIS VEHICLE (WITH GASOLINE ENGINE) IS PROTECTED BY A CLEARANCE BETWEEN IT AND THE UNDERSIDE OF THE PICKUP BED, AS MAINTAINED BY THE HEIGHT OF THE CROSSMEMBERS. EXPOSED ATOP THE FUEL TANK IS THE EXTERIOR PORTION OF THE FUEL TANK SENDER ASSEMBLY AND ITS FITTINGS, COMPRISED OF A PRESSURIZED FUEL LINE AND CORRESPONDING FUEL RETURN LINE, FUEL VAPOR LINES, AND ELECTRICAL POWER TO THE FUEL PUMP. THERE IS CONCERN THAT THE UNDERSIDE OF THE PICKUP BED MAY MAKE DAMAGING CONTACT WITH THESE FITTINGS SHOULD A COLLAPSE OF ITS CROSSMEMBERS OCCUR. THE VEHICLE HAS BEEN SURRENDERED TWICE FOR WARRANTY REVIEW, EACH DENIED. A THIRD ATTEMPT AT REPAIR IS PRESENTLY IN NEGOTIATION WITH FORD MOTOR COMPANY IN AN OPEN CASE, CUSTOMER TO ASSUME HALF OF ALL COSTS. *TR
Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Palfleet will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 29, 2014. Owners may contact Palfleet customer service at 1- 502-376-2458.
Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was never being utilized. This will be done free of charge. The recall is expected to begin in mid-July 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Iowa Mold Tooling Co., Inc. will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 28, 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Stahl will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. Owners may contact Stahl customer service at 1-800-277-8245, or Muncie at 1-800-367-7867.
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Additional source detail variants (2)
Equipment
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Engine And Engine Cooling:engine:gasoline
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Additional source detail variants (2)
Equipment
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Engine And Engine Cooling:engine:gasoline
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Tactical Vehicle Outfitters (Tactical) is recalling certain model year 2010-2014 Ford F-350 and F-550 vehicles modified by Tactical and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Tactical will notify owners, and dealers will install a new PTO pressure switch, free of charge. The recall began on August 1, 2014. Owners may contact Tactical customer service at 1-405-603-6700.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2010 Ford F-350 Sd Problems, Complaints & Recalls | Skip That Year
Illustration